THERMORY Barrels 63 Manual de usuario
Installation guide Barrel Nº63
BARRELS
© THERMORY 2021
Installation
Guide
These are assembly instructions for
standalone Thermory Barrel Sauna no 63,
which is meant for 6 people
has a window.
Barrel Nº63
These installation guidelines are purely informative and
based on the best knowledge currently available, and they
should be used accordingly. We advise you to follow the
regulations of your country where they conflict with the
general recommendations found in this guide.
Installation guide Installation guideBarrel Nº63 Barrel Nº63
BARRELS BARRELS
PARTS 1
x3 x2
x2
x1
x1
x2 x4
x1
x6
x2
x1
x2
x1
*if needed for
heater installation.
AH
J
B
D
F1
J1 V
C
O
J2
I
E
L
R
CRADLES
TOP STAVE
INTERIOR
BENCHES
FRONT
PANEL
RIGHT
PANEL
SECTION
BENCH
SUPPORTING
LEGS
WIRE
ASPEN
ROOF
BOARD
STAVES
METAL
BANDS
LEFT PANEL
SECTION
FLOORING
ADHESIVE
ROOF TAPE
x1
CENTER
STAVE x80 (+1
reserve)
RIGHT
STAVES
PARTS 2
+ +
x10 W
DECORATIVE
ROOF NISHING
BOARDS
x8 x70
x2 x2 x4x24
x120 x24
MP
UP1
NN1
SCREW
5.0X120
SCREW
4.0X50
Ø BOLT
16X140
HEX NUT
FLAT
WASHER
STAINLESS
STEEL SCREW
4.0X50
SCREW
4.2X70
STAINLESS
STEEL SCREW
4.2X70
TOOLS
x2 x2x2
x2 x2
24mm
Rubber
x3 x3
3 People
Recommended
x26´
STEP ZERO
Before you begin, be sure the
location.
Approximately 8’ x 8’ is ideal.
Overall dimensions are shown here.
Be sure the site is level and free of
Concrete, pavers or crushed stone
is preferred.
7´´6´
7´´4´
x1 x2
ZZ1
WATERPROOF
ROOF COVER
WOODEN SLAT
FOR ROOF
COVER
x1 D1
REAR
PANEL
x1 E1
LEFT PANEL
SECTION
x1 F
RIGHT
PANEL
SECTION
Installation guide Installation guideBarrel Nº63 Barrel Nº63
BARRELS BARRELS
STEP ONE
will have no dowel. Carefully level for
Place the center stave (B)
on wooden dowels embedded
Fix the center stave (B)
with screw 4.2 x 70 (N).
STEP THREE
Place 6 sauna body staves (C, C1)
to each side of the center stave (B)
Body staves (C)
Be sure to align the panel
STEP TWO
from corner to corner.
Measurements “a” and “b” should be
equal to ensure the cradles are square.
Be sure cradles remain level.
STEP FOUR
Place front panel with sauna doors
(D) and rear panel (D1) into the
trimmed grooves. Be sure each panel
is centered, leveled, and completely
seated into the floor panel.
Bind these panels together by
temporarily placing one or two
body stave (C) on top of them.
STEP FIVE
Two front side panels (E, F)
back side panels (E1, F1)
by 4 screws 5.0 x 120 (M) and
4 stainless steel screws 4.20 x 70 (N1).
interior of the sauna.
of the rear wall (E1, D1, F1)
the front wall (E, D, F).
A
B
A=B
N
A
B
Centered
Back
Front
C
M
M
E
M
M
M
M
M
E1
N1
F1
F
N1
N1
N1
B
C1
N
x6 pcs x6 pcs
C
D
D1
M
Installation guide Installation guideBarrel Nº63 Barrel Nº63
BARRELS BARRELS
STEP SEVEN
Measure steel bands (I) to ensure
correct length of 276,” +/- 1/2” is
acceptable.
Install steel bands (I) by wrapping
bands around barrel prior to
Place steel bands evenly around
barrel, covering screw heads.
Measure from steel band to barrel
edge to ensure the steel band is
even.
Cover roof with roof tape.
Rub and smooth with pressure to
ensure adhesion.
Install interior aspen roof trim (O)
with 4.0 x 50 (P1) stainless steel
screws.
STEP EIGHT
benches on wall mounts using
stainless steel screws 4.2 x 70 (N1).
Hold the seat and leg assembly tight to
the bench seat is level from front
to back. This will ensure proper
placement.
height using stainless steel screw
4.0 x 50 (P1).
STEP NINE
Wire raceways (V) and flooring
duckboards (L) can be used for wiring
needed for chosen stove.
STEP SIX
Continue placing body staves (C)
tightly on both sides of the sauna
body staves on the front panel with
4.2 x 70 screws and rear window
panel with 4.0 x 50 screws to
prevent glass breakage.
N
H
R
I
O
P1
I
P1
N1
N1
N1
N1
C
.4” .6” .8”
Vent
1” 1.2”
Roof tape
Aspen
roof board
3-15/16´´
C
L
Installation guide Barrel Nº63
BARRELS
WATCH THE VIDEO
Thermory USA - Denver
537 W. Highlands Ranch Pkwy, Ste. 114
Highlands Ranch, CO 80129
720.759.7268
56 Harvester Ave, Ste. 1-201
Batavia, NY 14020
585.591.6590
thermoryusa.com
STEP TEN
Place waterproof roof cover (Z)
and screws 4.0 x 50 (P).
Install front and rear decorative
HERE.
W
P
P
Z1
W
Z
P
Otros manuales de Producto de plomería de THERMORY
Manuales populares de Producto de plomería de otras marcas
Weka
Weka 506.2020.00E Instrucciones de funcionamiento
Kohler
Kohler K-6228 Instrucciones de montaje
UBERHAUS DESIGN
UBERHAUS DESIGN 75175017 Manual de usuario
American Standard
American Standard DetectLink 6072121 Manual de usuario
Uponor
Uponor Contec TS Manual de usuario
Pfister
Pfister Selia 49-SL Manual de usuario
