TerraTrike GranTourismo Manual
Revised: 6/2022
www.TerraTrike.com | 800.945.9910
Build Notes
Revised: 9/2017www.terratrike.com 616-608-8086
BUILD NOTES
Gran Tourismo
Gran Tourismo
Build Notes
Build Notes
Chain Routing:
Chain Tube/Idler Setup:
Top chain tube attachment
Revised: 6/2022
www.TerraTrike.com | 800.945.9910
1
2
3
4
5
8
9
10
Hybrid Steering Stack Assembly*
Assemble the steering stack as shown. Grease the
steerer tube before inserting into head tube. Remove
any excess grease from steerer tube before installing
handlebar. Grease axle before installing wheel.Torque
axle to 23-25Nm.
*Right Hand assembly depicted. Some components
can be purchased individually as well as in pairs, see
parts list below.
Parts List
1 M6x30 Bolt TT000576
2Hybrid Top Cap TT000506
3 Trigger Handlebar - RH TT000649
Trigger Handlebar - LH TT000650
Trigger Handlebar - Pair TT000514
M5x20 Bolt - 2qty (not pictured)
TT000301
4 Hybrid Headset Spacer TT000520
5 Hyrbid Headset Cap TT000505
6 Bushing (pre-installed)
TT000809
7 Hybrid Headset Cup (pre-installed) TT000602
8 Hybrid Headset Bearing TT000600
9 Rapid Axle Hubmount - RH TT000713
Rapid Axle Hubmount - LH TT000714
Rapid Axle Hubmount - Pair TT000516
10 Rapid Axle - RH TT000717
Rapid Axle - LH TT000718
Rapid Axle - Pair TT000563
11 Axle Spacer TT000568
6
7
Revised: 6/2022
www.TerraTrike.com | 800.945.9910
Hybrid Steering Stack Assembly Continued*
11
Install Axle Spacer (11) between brake rotor and hub.
Revised: 6/2022
www.TerraTrike.com | 800.945.9910
Chain Tube Setup
Upper:
Mount the chain tube assemblies as shown below. Ensure the chain tubes do not
rotate in the clamps after tightening the pinch bolts.
Lower:
Revised: 6/2022
www.TerraTrike.com | 800.945.9910
Idler Setup
Upper Assy. Chain Tube, 56 LDPE TT000548 1
Chain Tube Clamp, GT TT000697 1
Spacer, GT Chain Tube TT000700
1
M5x35 SHSCS SS TT000436
1
Lower Assy. Chain Tube, 56 LDPE TT000548
1
Chain Tube, Clamp,Traveler TT000422
2
Idler Wheel Spacer TT000262
2
M8x30mm BHCS SS TT000280
2
M5x18mm PHSS N/A 2
Idler Assy. Idler, 10t Deluxe TT000261 1
Idler “L” Bracket TT000263
1
Idler Wheel Spacer TT000262
2
M8x35mm BHSCS SS TT000279
1
Parts List
Revised: 6/2022
www.TerraTrike.com | 800.945.9910
Chain Routing
Revised: 6/2022
www.TerraTrike.com | 800.945.9910
Cable Routing RH
Cable Routing LH
Brake Cable
Shift Cable
Revised: 6/2022
www.TerraTrike.com | 800.945.9910
Inate tires before performing alignment. The alignment
measurement is approximately 295/8inches (center tread to
center tread), though slight variance is possible. Most importantly,
make sure the alignment remains neutral with a rider seated in
the trike.
Alignment
295/8
295/8
800.945.9910 | www.TerraTrike.com
4460 40th St. SE | Grand Rapids, MI 49512 USA
Tabla de contenidos
Otros manuales de Bicicleta de TerraTrike
TerraTrike
TerraTrike Sportster Manual de usuario
TerraTrike
TerraTrike Rover Manual de usuario
TerraTrike
TerraTrike GTS Manual
TerraTrike
TerraTrike Rover Manual de usuario
TerraTrike
TerraTrike Tour II Manual de usuario
TerraTrike
TerraTrike SPYDER Manual
TerraTrike
TerraTrike Rambler Manual de usuario
TerraTrike
TerraTrike CHARGE Manual
TerraTrike
TerraTrike EVO Manual
TerraTrike
TerraTrike Rover Auto NuVinci Manual de usuario
