Sunbeam EM9300 Caffe Bellissimo Manual de usuario
EM9300 Café Bellissimo Issue: A Page 1 of 21
SERVICE MANUAL
EM9300
Café Bellissimo
ISSUE: A
DATE: 26
TH
October 2011
EM9300 Café Bellissimo Issue: A Page 2 of 21
SPARE PARTS LIST
Note: Not all parts are available as spare parts. Please check price list.
Item
Description
Material Specification
No. of Parts
Supplier’s Cod
e
Sunbeam Part No.
1 Housing Cover Left 1
9310231600
2 Housing Top Cover 2 9310197700
3 Housing Cover Right 3 9310197800
4 HSG Lower Part Ass'y 4 9310197000
5 Assembly Milk Box 5 9310231200 EM9300MB
6 Freezer Ass’y 6 9310232200
7 Drip Tray Assembly 7 9310197900 EM930010
8 Brew Unit Assembly 8 9310166500 EM930011
9 Middle Plate 9 9310176200
10 Plug For Communication
Connector
10 9310176400
11 Inner Housing Lower Part 11 9310176300
12 Leg Spring Support Ass'y 12 9310176500
13 Top For Middle Plate 13 9310176600
14 Air Duct Housing Ass'y 14 9310176700 EM93002
15 Bean Container Ass'y 15 9310176800 EM93003
16 Waste Container Assembly 16 9310198000 EM930012
17 Assembly Pump Without Strap 17 9310188200 EM93004
18 Water Tank Assembly 18 9310231700 EM930013
19 Motor Ass'y Without PCB 19 9310188000
See item 19+78
19+78
Motor Ass'y With PCB
9310166900
EM93005
20 Flow Meter 20 1310000600 EM93006
21 Belt Pulley Z 59 21 3010542500 EM93007
EM9300 Café Bellissimo Issue: A Page 3 of 21
Item
Description
Material Specification
No. of Parts
Supplier’s Cod
e
Sunbeam Part No.
22 Belt S3M 6X228 22 5990010500 EM93008
23 Water Filter 23 5990003300 EM93009
24 Water Sensor PCB 24 9310176900 EM930016
25 Assembly Housing Back 25 9310232300 EM930017
26 Slider For Tank 26 9310177000 EM93006
27 Slider For Drip Tray 27 9310197100
28 Assembly Service Card 28 9310231500 EM930018
29 Support Top Cover 29 9310177500
30 Over Press Valve Ass’y V3 30 9310164500 EM930019
31 Assembly Aroma Box 31 9310231800 EM930020
32 Assembly Aroma box Lid 32 9310231900 EM930021
33 Assembly Grinder Adjusting 33 9310177600 EM930022
34 Door Latch 34 5990012400
35 Support For Water Level PCB 35 9310177700
36 Rubber Foot 36 6040043000 EM930023
37 Latte Macchiato Tray 37 9310232000 EM930024
38 Sealing Lower Side 38 5040042700
39 Cable Covering 39 9310177800
40 Support For Gear Wheel 40 9310177900
41 PIN For Micro switch 41 9310178000
42 Assembly Door 42 9310198800
43 Assembly Outlet Welded 43 9310069300
44 Axl_for Door 44 4060005400
45 Drain Water Guiding Part 45 9310178100
46 Assembly Double Micro switch 46 9310178200 EM930025
47 Strain Clip 47 3010219200
48 Assembly Plunger Ball 48 9310179900
49 Power PCB Assembly 49 9310178300 EM930026
50 Drip Tray Plate With Waves 50 4030082700 EM930014
EM9300 Café Bellissimo Issue: A Page 4 of 21
Item
Description
Material Specification
No. of Parts
Supplier’s Cod
e
Sunbeam Part No.
51 Assembly Restrictor Ass'y 51 9310178500 EM930027
52 Y-Connection 52 3010781100 EM930028
53 Adjust Lever For Grinder 53 9310178600 EM930029
54 Press Block 54 1050001000 EM930030
55 Grinder 9757.00 Assembly 55 9310178700 EM930031
56 Assembly Coffee Outlet 56 9310187900 EM930032
57 Milkfrother Base Ass’y 57 9310166300 EM930033
58 Milkfrother Connector Ass’y 58 9310178900 EM930034
59 Bean Cont. Powder Cover 59 9310231300
60 Filter Adapter 60 9310179100 EM930035
61 Silicone Elbow 61 5040042200 EM930036
62 Slider For Coffee Puck Drawing
Ass'y
62 9310179200
63 Heater 1 Assembly 63 9310179300 EM930037
64 Heater 2 Assembly 64 9310179400 EM930038
65 Isolation Cover Assembly 65 9310179500
66 Heater Support Assembly 66 9310179600
67 LCD 67 9310079000 EM930039
68 Panel PCB Assembly 68 9310191100 EM930040
69 Dispensing Unit 69 9310232100 EM930015
70 Motor Valve Assembly V4-1 70 9310167100
71 Motor Valve Assembly V4-2 71 9310167200
70+71
Double Motor Valve assembly
9310214000
EM930041
72 Hose Connector Triple Ass'y 72 9310180000 EM930042
73 Support For Motor Valve 73 9310179800
74 Grinder CAP Ass'y 74 9310180100 EM930043
75 Brew unit Locking Lever 75 9310180200
76 PCB Cover 76 9310180300
77 Strap For Pump 77 5990006000
EM9300 Café Bellissimo Issue: A Page 5 of 21
Item
Description
Material Specification
No. of Parts
Supplier’s Cod
e
Sunbeam Part No.
19+78
Motor Ass'y With P
CB
9310166900
EM93005
78 Filter PCB 78 9310188100 See item 19+78
79 Wire of switch for brew unit 100 9310180500
80 Wire or waster 101 9310180700
81 Wire of switch for front door 102 9310180600
82 Wire of switch for heater 1 front 103 9310180800
83 Wire of switch for
heater1&2back
104 9310181000
84 Wire of panel and power pcb 105 9310181100
85 Wire of NTC 1 350 mm 106 9310182100
86 Wire of power pcb 107 9310181200
87 Wire of motor 1 and 2 108 9310181300
88 Wire of flowmeter 109 9310181400
89 Wire of pump 110 9310181500
90 Wire of DC motor 111 9310181600
91 Wire of grinder motor and pump 112 9310181700
92 Wire of power and water level
pcb
113 9310181800
93 H.CORDSET 10A 250V SAA
WHITE
114 9310231400
94 Wire of switch for heater2 front
red
115 9310180900
95 Wire of NTC 2 270 mm 116 9310182200
96 Wire of DC motor with switch 117 9310182400
97 Wire of hall sensor 118 9310181900
98 Wire of uart communication 119 9310182000
99 Fuse Assembly 1 120 9310188300
100 Fuse Assembly 2 121 9310188400
101 Flow Meter To Pump Tube 200 9310182500
EM9300 Café Bellissimo Issue: A Page 6 of 21
Item
Description
Material Specification
No. of Parts
Supplier’s Cod
e
Sunbeam Part No.
102 From Pump To Y Connector 201 9310183000
103 From Y Connector To Coffee
Heater
202 9310182800
104 From Coffee Heater To Coffee MV 203 9310001600
105 From Coffee MV To Brew Unit 204 9310164600
106 Tube to Y Connector 205 9310183200
107 Noise reduction Tube 206 9310183300
108 From Coffee MV To Hose
Connector
207 9310183600
109 From Hose Connector To Middle
Plate
208 9310183700
110 From Hose Connector To OV
Pressure
209 9310183800
111 Flow Y Connector To Back
Pressure
210 9310182900
112 From Back Pressure To OV
Valve
211 9310182700
113 From OV Valve To Steam
Heater
212 9310183100
114 From Steam Heater To Steam
MV
213 9310182600
115 From Steam MV To Y
Connector
214 9310056200
116 Milk Suck Tube 215 9310183400 EM930044
117 Tube For Cup Tube 216 9310183500
118 SCREW 2.6x8 PAN CROSS HD 300 5030005600
119 SCREW TORX 3x10 S.STEEL 301 5030006600
120 SCREW 3x18 PAN CROSS HD 302 5030007300
121 SCREW 3.5x12 ZN-PL CROSS
HD
303 5030010800
EM9300 Café Bellissimo Issue: A Page 7 of 21
Item
Description
Material Specification
No. of Parts
Supplier’s Cod
e
Sunbeam Part No.
122 SCREW 3x13 PAN CROSS HD 304 5030011000
123 SCREW FOR GRINDER M3x5 305 5030011400
124 SCREW M5x20 TAPTITE 306 5030017100
125 SCREW DIN 7985 M3x5 307 5030024700
126 SCREW 2.3x7.5 CROSS
COUNT HD N
308 5030024800
127 SCREW M2.6x6 PAN CROSS
TYP-H
309 5030027900
128 SCREW 3.5x13 SPECIAL PAN
HEAD
310 5030030200
129 SCREW ST 2.9x6.5-F-Z ISO
7049
311 5030030400
130 HEXAGON HEAD SCREW
EN24017 M5x13
312 5030030601
131 SCREW ST 2.9x16-F-Z ISO
7049
313 5030030700
132 SCREW ST 2.9x13-F-Z ISO
7049
314 5030030800
133 SCREW ST 2.0x9.5-Z 2.0x9.5-
F-Z
315 5030033200
134 SCREW SUS 2.9x9.5PA (T10) 316 5030033800
135 SCREW M5x13 317 5030035100
136 SCREW 2.0X10.0MM
ST.STEEL COUNTERSUNK CR
318 5030040000
137 SCREW 2.3X7.5MM ST.STEEL
PAN CROSS HD
319 5030040100
138 SCREW 3x16 SS PAN CROSS
HD TYPE BT
320 5030040300
139 SCREW M4x16 SS DIN7985
FOR MOTOR VALVE
321 5030040400
EM9300 Café Bellissimo Issue: A Page 8 of 21
Item
Description
Material Specification
No. of Parts
Supplier’s Cod
e
Sunbeam Part No.
140 M4x30 FILLISTER HEAD SCREW 322 5030042900
141
SCREW WITH CYLINDER FOR ABS
323 5030045400
EM9300 Café Bellissimo Issue: A Page 9 of 21
EXPLODED VIEW DRAWING
EM9300 Café Bellissimo Issue: A Page 10 of 21
Otros manuales para EM9300 Caffe Bellissimo
1
Tabla de contenidos
Otros manuales de Cafetera de Sunbeam
Sunbeam
Sunbeam Automatic Coffeemaster Manual de usuario
Sunbeam
Sunbeam Aroma Coffee PC4700 Manual de usuario
Sunbeam
Sunbeam Mr Coffee VM Series Manual de usuario
Sunbeam
Sunbeam MINI BARISTA EM4300S Manual de usuario
Sunbeam
Sunbeam TORINO Manual de usuario
Sunbeam
Sunbeam BARISTA MAX EM5300 Manual de usuario
Sunbeam
Sunbeam 6960-33 Manual de usuario
Sunbeam
Sunbeam Bar Espresso EM3500 Manual de usuario
Sunbeam
Sunbeam EM5900 Artista Manual de usuario
Sunbeam
Sunbeam 3256 Manual de usuario
Sunbeam
Sunbeam EM3820 Manual de usuario
Sunbeam
Sunbeam EM8900 Manual operacional
Sunbeam
Sunbeam 3287 Manual de usuario
Sunbeam
Sunbeam Cafe Series EM7100 Manual operacional
Sunbeam
Sunbeam 3278 Manual de usuario
Sunbeam
Sunbeam SDP1500BK Manual de usuario
Sunbeam
Sunbeam 6391 Manual de usuario
Sunbeam
Sunbeam EM6910 Cafe Series Guía de instalación
Sunbeam
Sunbeam 5735-33 Manual de usuario
Sunbeam
Sunbeam Cafe Barista EM8800 Manual de usuario
