SnowEx V-Pro 32300 Manual de usuario

V-Pro™ Hopper Spreader

32300, 32600

Owner's Manual

Original Instructions

This manual is for SnowEx®32300 and 32600 hopper spreaders with serial numbers

beginning with 190901 and higher.

August 15, 2019

Lit. No. 74259, Rev. 00

SnowEx, 531 Ajax Drive, Madison Heights, MI 48071-2429 • www.snowexproducts.com

CAUTION

Read this document before operating

or servicing the spreader.

This manual supersedes all editions with an earlier date.

Lit. No. 74259, Rev. 00 3 August 15, 2019

TABLE OF CONTENTS

PREFACE................................................................... 5

Owner's Information Form .................................... 5

SAFETY ..................................................................... 6

Safety Denitions.................................................. 6

Warning/Caution Labels ....................................... 6

Serial Number Label ............................................. 7

Safety Precautions................................................ 8

Fuses .................................................................... 9

Personal Safety..................................................... 9

Fire and Explosion ................................................ 9

Cell Phones........................................................... 9

Ventilation ............................................................. 9

Battery Safety ....................................................... 9

Torque Chart ....................................................... 10

LOADING ................................................................. 11

Material Weights ................................................. 11

Determining Vehicle Payload.............................. 11

Spreader Specications...................................... 11

MOUNTING THE SPREADER............................... 12

OPERATING THE SPREADER ............................. 14

Driving and Spreading on Snow and Ice ............ 14

Spreading Tips.................................................... 14

Starting and Stopping Motor............................... 14

Cab Control......................................................... 15

Powering the Control.................................... 15

Starting and Stopping Spreader................... 15

Controlling Material Application.................... 20

Cab Control Modes ...................................... 20

Cab Control Codes Table ............................. 17

Setup Procedures......................................... 19

MAINTENANCE ...................................................... 20

Lubrication .......................................................... 20

After Each Use.................................................... 20

Storage ...............................................................20

Fuse Replacement..............................................20

HARNESS WIRING DIAGRAM/

MODULE & CABLES........................................... 21

TROUBLESHOOTING GUIDE............................... 22

Lit. No. 74259, Rev. 00 4 August 15, 2019

Lit. No. 74259, Rev. 00 5 August 15, 2019

PREFACE

This manual has been prepared to acquaint you with

the safety information, operation, and maintenance of

your new hopper spreader. Please read this manual

carefully and follow all recommendations. This will

help ensure protable and trouble-free operation of

your hopper spreader. Keep this manual accessible. It

is a handy reference in case minor service is required.

When service is necessary, bring your hopper

spreader to your distributor. They know your spreader

best and are interested in your complete satisfaction.

NOTE: This spreader is designed to spread snow

and ice control materials only. Do not use it

for purposes other than those specied in this

manual.

OWNER'S INFORMATION

Owner's Name: ______________________________________________________________________

Date Purchased: _____________________________________________________________________

Outlet Name: ______________________________________________ Phone:_________________

Outlet Address: ______________________________________________________________________

Vehicle Model: _______________________________________________ Year: _______________

Spreader Type (Model):________________________________ Serial #:______________________

Length:________________________ Weight: __________________ lb/kg: _________________

Lit. No. 74259, Rev. 00 6 August 15, 2019

SAFETY

SAFETY DEFINITIONS

NOTE: Indicates a situation or action that can

lead to damage to your spreader and vehicle or

other property. Other useful information can also

be described.

WARNING/CAUTION LABELS

Become familiar with and inform users about the

warning and caution labels on the spreader.

NOTE: If labels are missing or cannot be read, see

your sales outlet.

CAUTION

Indicates a potentially hazardous situation

that, if not avoided, may result in minor or

moderate injury. It may also be used to alert

against unsafe practices.

WARNING

Indicates a potentially hazardous situation

that, if not avoided, could result in death or

serious personal injury.

ROTATING AUGER CAN CAUSE

SERIOUS INJURY OR DEATH

• Keep arms, hands, and loose clothing

away from auger.

• Shut o control and unplug spreader

before servicing. D6335

• DO NOT REMOVE SPREADER WITH MATERIAL IN HOPPER

• FASTEN SPREADER DOWN WITH APPROVED RATCHET

STRAPS AND BOLT KIT

• REAR FRAME LOCATOR BARS MUST BE IN PLACE BEFORE

OPERATING VEHICLE

DANGER

D6547

Warning Label – No Step

Warning Label – Rear Camera

Danger Label – Do Not Remove

Warning Label – Rotating Parts

Warning Label – Rotating Auger

ROTATING PARTS AND FLYING OB-

JECTS CAN CAUSE INJURY OR DEATH

• Keep hands, arms, feet and loose clothing away

• Shut o power ans stop engine before servicing

• Read owners manual before operating.

• Keep bystanders at least 60 ft away.

D6544

NO STEP

• Slippery Surface When Wet.

• May Cause Severe Injury

D6545

Lit. No. 74259, Rev. 00 7 August 15, 2019

SAFETY

SERIAL NUMBER LABEL

• Read Owner’s Manual for Installation Instructions.

• Secure spreader to truck with ratchet straps.

• Anchor spreader securely to truck body with bolt kit provided to

prevent slipping or sliding.

• Routinely check straps and handware to make sure they are secure.

D6548

Warning Label – Read Owner's Manual

Warning Label – GVWR

Code Denition

YY 2-Digit Year

MM 2-Digit Month

DD 2-Digit Day

LL 2-Digit Location Code

XXXX 4-Digit Sequential Number

ZZZZZZ 5- to 7-Digit Assembly PN

Lit. No. 74259, Rev. 00 8 August 15, 2019

SAFETY

SAFETY PRECAUTIONS

Improper installation and operation could cause

personal injury and/or equipment and property

damage. Read and understand labels and the

Owner's Manual before installing, operating, or

making adjustments.

WARNING

• Driver to keep bystanders minimum of

25 feet away from operating spreader.

• Before working with the spreader, secure all

loose-tting clothing and unrestrained hair.

• Before operating the spreader, verify that all

safety guards are in place.

• Before servicing the spreader, wait for

conveyor, auger, and spinner to stop.

• Do not climb into or ride on spreader.

CAUTION

If rear directional, CHMSL light, or brake

stoplights are obstructed by the spreader, the

lights shall be relocated, or auxiliary directional

or brake stoplights shall be installed.

WARNING

Overloading could result in an

accident or damage. Do not exceed

GVWR of vehicle. See Loading

section to determine maximum

volumes of spreading material. CAUTION

Disconnect electric and/or hydraulic power

and tag out if required before servicing or

performing maintenance.

NOTE: Lubricate grease ttings after each use.

Use a good quality multipurpose grease.

CAUTION

DO NOT leave unused material in

hopper. Material can freeze or solidify,

causing unit to not work properly.

Empty and clean after each use.

CAUTION

• Do not operate a spreader in need of

maintenance.

• Before operating the spreader, reassemble

any parts or hardware removed for cleaning

or adjusting.

• Before operating the spreader, remove

materials such as cleaning rags, brushes,

and hand tools from the spreader.

• Before operating the spreader, read the

engine owner's manual, if so equipped.

• While operating the spreader, use auxiliary

warning lights, except when prohibited by law.

• Tighten all fasteners according to the

Torque Chart. Refer to Torque Chart for the

recommended torque values.

WARNING

Vehicles <10,000 lb GVWR: Obstructing

the visibility from the vehicle's rear camera

could result in serious injury or damage. An

auxiliary camera system shall be installed

if the vehicle's rear camera is removed or

blocked.

Lit. No. 74259, Rev. 00 9 August 15, 2019

SAFETY

CELL PHONES

A driver's rst responsibility is the safe operation of

the vehicle. The most important thing you can do

to prevent a crash is to avoid distractions and pay

attention to the road. Wait until it is safe to operate

Mobile Communication Equipment such as cell phones,

text messaging devices, pagers, or two-way radios.

VENTILATION

BATTERY SAFETY

WARNING

Gasoline is highly ammable and gasoline

vapor is explosive. Never smoke while

working on vehicle. Keep all open ames

away from gasoline tank and lines. Wipe up

any spilled gasoline immediately.

CAUTION

Batteries normally produce explosive gases

which can cause personal injury. Therefore,

do not allow ames, sparks, or lit tobacco

to come near the battery. When charging or

working near a battery, always cover your

face and protect your eyes, and also provide

ventilation.

• Batteries contain sulfuric acid, which burns

skin, eyes, and clothing.

• Disconnect the battery before removing or

replacing any electrical components.

WARNING

Vehicle exhaust contains lethal fumes.

Breathing these fumes, even in low

concentrations, can cause death. Never

operate a vehicle in an enclosed area without

venting exhaust to the outside.

FUSES

The electrical system contains several automotive-style

fuses. If a problem should occur and fuse replacement

is necessary, the replacement fuse must be of the

same type and amperage rating as the original.

Installing a fuse with a higher rating can damage the

system and could start a re.

PERSONAL SAFETY

• Remove ignition key and put the vehicle in PARK

or in gear to prevent others from starting the

vehicle during installation or service.

• Wear only snug-tting clothing while working on

your vehicle or spreader.

• Do not wear jewelry or a necktie, and secure

long hair.

• Wear safety goggles to protect your eyes from

battery acid, gasoline, dirt, and dust.

• Avoid touching hot surfaces such as the engine,

radiator, hoses, and exhaust pipes.

• Always have a re extinguisher rated BC handy,

for ammable liquids and electrical res.

FIRE AND EXPLOSION

Be careful when using gasoline. Do not use gasoline

to clean parts. Store only in approved containers away

from sources of heat or ame.

Lit. No. 74259, Rev. 00 10 August 15, 2019

SAFETY

TORQUE CHART

CAUTION

Read instructions before assembling. Fasteners

should be nger tight until instructed to

tighten according to the Torque Chart. Use

standard methods and practices when

attaching spreader, including proper personal

protective safety equipment.

1/4-20 14

1/4-28 16

5/16-1

03 287

5/16-2

30 325

3/8-16 36

3/8-24 40

7/16-1458

7/16-20

9/16-12

9/16-18

5/8-11

5/8-18

3/4-10

3/4-16

7/8-9

7/8-14 64

2321-8

1-12 9541349

1/2-13

1/2-20

16.2

18.5

33.3

36.9

59.1

36.5

72.2

126

200

67.0

94.6

105.6

144.3

162.7

11.4

13.1

23.6

26.0

41.8

47.5

67.0

74.8

102.1

115.2

M6 x 1.00

M12 x 1.75

M8 x 1.25

M14 x 2.00

M10 x 1.50

M27 x 3.00

M22 x 2.50

M30 x 3.50

M24 x 3.00

M20 x 2.5015.0

26.4

52.2

145

10.4

831

1055

1544

2095

610

580

762

1079

1515

M33 x 3.50

M36 x 4.00

2849

3662

1990

2647

441

M16 x 2.00 313226

M18 x 2.50 431301

Recommended Fastener Torque Chart

Size Size

Torque (N·m)

Grade

Metric Fasteners Class 8.8 and 10.9

These torque values apply to fasteners

except those noted in the instructions.

Torque (N·m)

Grade

Size Size

Torque (N·m)

Class

8.8

Class

10.9

Torque (N·m)

Class

8.8

Class

10.9

Inch Fasteners Grade 5 and Grade 8

Otros manuales para V-Pro 32300

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Esparcidor de SnowEx

SnowEx

SnowEx SP-1675 Manual de usuario

SnowEx

SnowEx SP-1675 Manual de usuario

SnowEx

SnowEx HELIXX Manual de usuario

SnowEx

SnowEx Vee Pro 3000 Manual de usuario

SnowEx

SnowEx V-Pro 32200 Manual de usuario

SnowEx

SnowEx VX-4210 Manual de usuario

SnowEx

SnowEx V-Pro SP-2000 Manual de usuario

SnowEx

SnowEx Super Maxx SP-9300XH Instrucciones de funcionamiento

SnowEx

SnowEx SP-85 Instrucciones de funcionamiento

SnowEx

SnowEx V-Pro 32300 Manual de usuario

SnowEx

SnowEx SP-2400 Manual del propietario

SnowEx

SnowEx SP-2200 Manual de usuario

SnowEx

SnowEx VX-6010 Manual de usuario

SnowEx

SnowEx SP-100-1 Manual de usuario

SnowEx

SnowEx SP-65 Instrucciones de funcionamiento

SnowEx

SnowEx SP-7550 Manual del propietario

SnowEx

SnowEx Bulk Pro 1575 Manual de usuario

SnowEx

SnowEx Drop Pro 600 Manual de usuario

SnowEx

SnowEx SP-100 Manual del propietario

SnowEx

SnowEx SP-575V Manual del propietario

SnowEx

SnowEx HELIXX Series Manual de usuario

SnowEx

SnowEx SP-65 Manual del propietario

SnowEx

SnowEx SP-325 Instrucciones de funcionamiento

SnowEx

SnowEx Bulk-Pro 1875 Manual de usuario

Manuales populares de Esparcidor de otras marcas

PEQUEA

PEQUEA GT-100 Manual de usuario

Herculano

Herculano H2RS9 Manual de usuario

Epoke

Epoke SKE8 Manual de usuario

GEA

GEA EL44 Hoja de especificaciones

Boss Snowplow

Boss Snowplow TGS 800 Manual de usuario

Fisher

Fisher EMERSON 168 Series Manual de usuario

Fisher

Fisher POLY-CASTER 78601 Manual de usuario

TurfEx

TurfEx RS7200 Manual del propietario

Ferris

Ferris Pathfinder Series Manual de usuario

Fayat Group

Fayat Group DYNAPAC S100 Guía de solución de problemas

Art's-Way Manufacturing

Art's-Way Manufacturing X700 Manual de instalación y operación

EASTMAN

EASTMAN CR 500 Manual de usuario

Nogueira

Nogueira RoyalFlow-600 Manual de usuario

Buyers

Buyers TGS05B Manual de usuario

Magnum

Magnum V-BOX PV Series Suplemento

Meyer's

Meyer's VB280 Manual de usuario

Kramer

Kramer VM-400HDCP Manual de usuario

H&S

H&S 5134 Manual de usuario