SnowEx SP-9300 Manual de usuario

800-725-8377

Trynex International 2009 (REV 001) L1218 MAX— 1

800-725-8377

Trynex International 20

Owner / Operator’s Manual

Spreaders for Snow & Ice Control

FOR MODEL

This Manual Must Be Read Before Operating The Equipment

CUSTOMER COPY

Warren, Michigan 48089

800-725-8377

Protected by the following patents, #6,089,478, #6,088,865, #Des.425,915

and other pending U.S. and foreign patent applications.

See Back Page for Details!

Warm Up to

with a

Winter Band!

F R E E

SP-9300

MAX — 2

Table of Contents

Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

General Information and Registration . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Safety Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

5 - 7

Spreader Assembly and Exploded Views. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

8 - 17

Wiring Instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

. 18

Electrical System Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

19 - 22

Spreader Mounting System. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

23 - 25

Spreader Operating Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

26 - 30

Troubleshooting Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

31 - 33

Spreader Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Determine Vehicle Payload Chart . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Blank and Note Pages . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

36 - 37

Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

38 - 39

Have a question or need assistance?

SnowEx Customer Service

(800) 725-8377

or (586) 756-6555

Monday through Friday 8:00 AM to 4:30 PM EST

Fax: (586) 427-0552

E-Mail: [email protected]

Website: www.snowexproducts.com

Trynex International 2009 L1218 MAX — 3

Introduction

This manual has been designed for your help. It will assist you and instruct you on the proper set-up, installation and use of

this spreader.

Refer to the table of contents for an outline of this manual.

We require that you read and understand the contents of this manual completely (especially all safety information) before

attempting any procedure contained herein.

THIS SIGN SHOULD ALERT YOU:

The Society of Automotive Engineers has adopted this SAFETY ALERT SYMBOL to pinpoint characteristics

that, if NOT carefully followed, can create a safety hazard. When you see this symbol in this manual or on the

machine itself, BE ALERT! Your personal safety and the safety of others is involved

Dened below are the SAFETY ALERT messages and how they will appear in this manual:

(RED)

Information that, if not carefully followed,

can cause death!

(ORANGE)

Information that, if not carefully followed,

can cause serious personal injury or death!

(YELLOW)

Information that, if not carefully followed,

can cause minor injury or damage to equipment.

L1218 © Trynex International 2009

MAX — 4

General Information

CONGRATULATIONS!

The spreader you have purchased is an example of snow and ice control technology at its nest! Your spreader’s innovative,

self-contained design is a trademark of all Trynex products. Here’s why...

SIMPLICITY: Fewer moving parts manufactured of higher quality means minimal maintenance for your SnowEx spreader.

RELIABILITY: High impact linear low density polyethelyne hopper, state-of-the-art electronic dual variable speed control,

custom engineered powder coated frame, maximum torque 12 volt motor coupled to a custom engineered transmission

found only on SnowEx products.

VERSATILITY: Multi-use capabilities allows spreading of a variety of materials for snow and ice control.

WARRANTY: Best in the industry, hands down! 2 Years Standard and now a 5 Year Extended (optional).

The benets you are about to recognize are that of time, money and eort.

We welcome you to the world of Trynex Performance.

Registration

Record the following information in this manual for quick reference.

Spreader Model Number _____________________________________________________________________________________

Spreader Serial Number_______________________________ Controller Serial Number _______________________________

Date of Purchase___________________________________________________________________________________________

Dealer Where Purchased _____________________________________________________________________________________

When ordering parts, the above information is necessary. This will help to insure

that you receive the correct parts.

At the right is a diagram of the ID tag. This tag on the spreader is located

on the frame.

Please ll out the warranty card with all the necessary information to validate it. This will also give us a record so that

any safety or service information may be communicated to you.

Trynex International 2009 L1218 MAX — 5

Safety

Before attempting any procedure in this book, these safety instructions must be read and understood by all workers who

have any part in the preparation or use of this equipment.

For your safety warning and information decals have been placed on this product to remind the operator of safety

precautions . If anything happens to mark or destroy the decals, please request new ones from Trynex, International.

Unit must be strapped down and locked into position before operating vehicle.

Never exceed the Gross Vehicle Weight Rating of vehicle. Failure to do so may limit a vehicle’s

handling characteristics.

Never attempt to take a unit o a truck with material in it.

Never exceed 45 m.p.h. when loaded spreader is attached to vehicle. Braking distances may

be increased and handling characteristics may be impaired at speeds above 45 m.p.h.

Never allow children to operate or climb on equipment.

Always check areas to be spread to be sure no hazardous conditions or substances are in the area.

Always inspect unit for defects: broken, worn or bent parts, weakened areas on spreader or mount.

Always shut o vehicle and power source before attempting to attach or detach or service

spreader unit. Be sure vehicle/power source is properly braked or chocked.

Always keep hands, feet, and clothing away from power-driven parts. Remember it is the

owner’s responsibility to communicate information on safe usage and proper maintenance of

all equipment.

Always make sure personnel are clear of areas of danger when using equipment. Maintain 60'

distance from all bystanders when operating the spreader.

Inspect the unit periodically for defects. Parts that are broken, missing, or worn out must be

replaced immediately. The unit, or any part of it cannot be altered without prior written

permission from the manufacturer.

Never use V-Maxx 9300 with foreign debris in the spreader. These units are designed to handle

clean, free-owing material.

L1218 © Trynex International 2009

MAX — 6

Safety

Always inspect pins and latches whenever attaching or detaching spreader, and before

traveling.

Never leave material in hopper for long periods of time. Be aware that all ice melters are

hygroscopic and will attract atmospheric moisture and harden up.

Remember, most accidents are preventable and caused by human error. Exercising of care

and precautions must be observed to prevent the possibility of injury to operator or

others!

Never operate equipment when under the inuence of alcohol, drugs, or medication that

might alter your judgment and/or reaction time.

Before working with the spreader, secure all loose tting clothing and unrestrained hair.

Always wear safety glasses with side shields when servicing spreader. Failure to do this

could result in serious injury to the eyes.

Trynex International 2009 L1218 MAX— 7

D 6546

D 6548

D 6335

D 6544

D 6545

D 6859

SERIAL NUMBER

ON REVERSE SIDE

Safety and Warning Labels

Model # SP-9300

L1218 © Trynex International 2009

MAX— 8

V-Maxx SP-9300

Component Assembly Views

Spinner Drive

Assembly

Auger Drive

Assembly

Electrical System

Assembly

Hopper

Assembly

Frame

Assembly

Trynex International 2009 L1218 MAX — 9

THIS PAGE INTENTIONALLY LEFT BLANK

L1218 © Trynex International 2009

MAX — 10

Auger Drive Assembly Parts Breakdown

Model # SP-9300

Tabla de contenidos

Otros manuales de Esparcidor de SnowEx

SnowEx

SnowEx HELIXX Manual de usuario

SnowEx

SnowEx Renegade S150A Manual de usuario

SnowEx

SnowEx Drop Pro 600 Manual de usuario

SnowEx

SnowEx SP-65 Manual del propietario

SnowEx

SnowEx Super Maxx SP-9300XH Instrucciones de funcionamiento

SnowEx

SnowEx Vee Pro 3000 Manual de usuario

SnowEx

SnowEx SP-8550 Manual del propietario

SnowEx

SnowEx SP-85 Instrucciones de funcionamiento

SnowEx

SnowEx SP-100 Manual del propietario

SnowEx

SnowEx V-Pro SP-2000 Manual de usuario

SnowEx

SnowEx SR-210 Instrucciones de funcionamiento

SnowEx

SnowEx Bulk Pro SP-1575 Instrucciones de funcionamiento

SnowEx

SnowEx HELIXX Manual de usuario

SnowEx

SnowEx SP-85 Manual del propietario

SnowEx

SnowEx Bulk-Pro 1875 Manual de usuario

SnowEx

SnowEx SP-9500X Manual de usuario

SnowEx

SnowEx SP-575V Manual del propietario

SnowEx

SnowEx 7500 Manual de usuario

SnowEx

SnowEx SP-1675 Manual de usuario

SnowEx

SnowEx SP-100-1 Manual de usuario

SnowEx

SnowEx Tailgate Pro 575X Manual de usuario

SnowEx

SnowEx Precision Pro SP-1675 Manual de usuario

SnowEx

SnowEx V-Pro 32300 Manual de usuario

SnowEx

SnowEx Sidewalk-Pro SD-95 Instrucciones de funcionamiento

Manuales populares de Esparcidor de otras marcas

PEQUEA

PEQUEA GT-100 Manual de usuario

Herculano

Herculano H2RS9 Manual de usuario

Epoke

Epoke SKE8 Manual de usuario

GEA

GEA EL44 Hoja de especificaciones

Boss Snowplow

Boss Snowplow TGS 800 Manual de usuario

Fisher

Fisher EMERSON 168 Series Manual de usuario

Fisher

Fisher POLY-CASTER 78601 Manual de usuario

TurfEx

TurfEx RS7200 Manual del propietario

Ferris

Ferris Pathfinder Series Manual de usuario

Fayat Group

Fayat Group DYNAPAC S100 Guía de solución de problemas

Art's-Way Manufacturing

Art's-Way Manufacturing X700 Manual de instalación y operación

EASTMAN

EASTMAN CR 500 Manual de usuario

Nogueira

Nogueira RoyalFlow-600 Manual de usuario

Buyers

Buyers TGS05B Manual de usuario

Magnum

Magnum V-BOX PV Series Suplemento

Meyer's

Meyer's VB280 Manual de usuario

Kramer

Kramer VM-400HDCP Manual de usuario

H&S

H&S 5134 Manual de usuario