Sanuvox S1000 Manual de usuario
1-888-726-8869 www.sanuvox.com Sanuvox Technologies Inc. All rights reserved. 2021-v.2
INSTALLATION MANUAL
SANUVAIR®S1000
AIR DISINFECTION UNIT WITH MERV 15 FINAL FILTER
PLEASE SAVE FOR YOUR RECORDS
DATE INSTALLED : _________________________
INSTALLER CONTACT INFO. : _______________________________________________________________
INSTALLED BY: ___________________________
1-888-726-8869 www.sanuvox.com
B
D
C
E
G
F
HI
J
A
Sanuvox Technologies Inc. All rights reserved. 2021-v.2
INSTALLATION MANUAL
WARNING
Never expose eyes or skin to ultraviolet light
from any source. Before installing or performing
maintenance or service on the purier,
DISCONNECT from main power. Electrical
shock can cause injury or death.
Do not touch Lamp glass without gloves.
Reduced performance of Lamp may result.
Clean Lamp after handling.
The UV Lamp contains a small quantity of
mercury. If a Lamp breaks, clean and dispose
of with care.
Use only specied replacement Lamps with
your Purier. Use of an incorrect Lamp can
result in damage to the Purier and/or Lamp
therefor voids warranty.
A. Holes for 1 x pair of 8" inlet collars
B. Holes for 1 x pair of 8" outlet collars
C. 1 to 4 x 16" UV ‘J’ lamps
D. Aluminum reecting chamber
E. 1 x Ballast
F. Door
G. 1 x 2" MERV 8 pre-lter
H. 1 x 4" MERV 15 nal lter
I. Safety cut-off switch
J. Power 120 Volt or 230 Volt
SAFETY PRECAUTIONS
When servicing UV purication-ltration equipment, observe precautions in the literature, tags and labels attached to the
unit, and other safety measures that may apply. Follow all safety codes. Wear safety glasses and work gloves.
GENERAL
The SANUVAIR® S1000 is a combination Ultraviolet - Filter Air Purication System. The SANUVAIR® S1000 UV
Germicidal Photo-Oxidation process (UVC/UVV) destroys bio-chemical contaminants such as mold, viruses, bacteria,
germs, chemicals, cigarette smoke, VOC’s and odors. The SANUVAIR® S1000 is also equipped with a 2" MERV 8 pre-
lter that captures the large particles, and a MERV 15 nal lter that captures 95% of 0.3 to 1 micron-sized particles.
99.97% HEPA Filter available. Details below.
OPTION
Depending on the model ordered, there may be an additional option available.
MSCFTR12
An optional 99.97% efcient HEPA lter (20" x 20" x 4")
1-888-726-8869 www.sanuvox.com Sanuvox Technologies Inc. All rights reserved. 2021-v.2
INSTALLATION MANUAL
Inlet Collar (left side)
Remove
access door
to the UV
Lamp(s)
Outlet Collar (right side)
STEP 1
Install Inlet / Outlet Collars (each collar is a set of 2 x 8" round inlet and outlet)
Open the access door and insert the two pairs of collars into the SANUVAIR® S1000. Align the holes and screw down
each pair of collars from the top of the SANUVAIR® S1000 with the included philips screws (6 screws per collar). Pay
special attention to the orientation of the notch on the right side collar.The notch (highlighted in black) should be pressed
up against the right side of the SANUVAIR® S1000.
STEP 2
Installation of the UV Lamp
The UV Lamp is to be installed in the Aluminum Reecting Chamber. To slide out the Aluminum Chamber, remove the two
buttery bolts and screws which secure it in place.
UV Lamp(s) and Ballast Position
The lamp should be positioned towards a central point in the middle of the unit’s
aluminum reection chamber. For models with multiple lamps, you must position
the lamps in a ‘X’ to bring them closer to the middle and optimize the UV dose of
the unit, as shown on this image on the right.
* A clamp (or two, if you ordered an optional second lamp) is there to hold the lamp(s).
MAKE SURE TO PUT THE RIGHT LAMP IN THE RIGHT CLAMP (see label identier).
Adhere the included foam gasket (included
in the Lamp box) to the porcelain end-cap
with the 4 pins.
Insert the end-cap with foam gasket into the
clamp* assembly and tighten. Be careful not to
over tighten as it may result in end-cap breaking.
Insert the white-plug into the UV Lamp’s 4
pins. The plug will only t in two of four ways.
Either way is ne. The exposed wire-set is
Teon coated and is resistant to UV exposure.
1-888-726-8869 www.sanuvox.com Sanuvox Technologies Inc. All rights reserved. 2021-v.2
INSTALLATION MANUAL
Parts for SANUVAIR®S1000
BST120/277SHS Multi voltage ballast
LMPHGXJ160 T6 Dual Zone high intensity 16" UV ‘J’ lamp
LMPHGJ160 T6 Germicidal high intensity 16" UV ‘J’ lamp
LMPHGXJ160-4 T6 Dual Zone high intensity 16" UV ‘J’ lamp with 4" of oxidation
LMPHXJ160 T6 high intensity 16" UV ‘J’ lamp with UVV only
MSCSWC12 Speed control for use in 120V unit (optional)
MSCFTR12 20"20"X4" HEPA 99,97% lter (optional)
MSCFTR1 20"x20"X4" 95% lter
MSCFTR17 20"X20"x2" pre-lter
MSCMTR9 Motor assembly for 120V. *Must be ordered with MSCCAP4 Capacitor
MSCCAP4 Capacitor for motor 120V
MSCMTR10 Motor assembly for 230V. *Must be ordered with MSCCAP5 Capacitor
MSCCAP5 Capacitor for motor 230V
MAINTENANCE
Visual inspection of the lter media should be performed and replaced as needed. The 2" pre-lter is designed to be an
inexpensive replacement while extending the life of the main lter. Although the Lamp may “shine" for many years, the UV
Lamp does age at which point it may become ineffective. The UV Lamp should be replaced after 17,000 operating hours.
OPERATION
The SANUVAIR® S1000 is now ready to be plugged into a 110V outlet. The SANUVAIR® S1000 may be used in many
diverse applications. When ducting-in the unit, avoid 90 degree elbows when possible.
STEP 3
Insert Filters
Insert the one (1) MERV 8 pre-lter and the main lter. Follow the arrow for airow for proper lter direction. After the main
lter is installed, close the latch to secure the lter in place. Close the door of the blower compartment.
Otros manuales para S1000
3
Tabla de contenidos
Otros manuales de Purificador de aire de Sanuvox
Sanuvox
Sanuvox R MAX Manual de usuario
Sanuvox
Sanuvox S1000 Manual de usuario
Sanuvox
Sanuvox VP900 Manual de usuario
Sanuvox
Sanuvox BIOPUR Manual de usuario
Sanuvox
Sanuvox SANUVAIR S100GX Manual de usuario
Sanuvox
Sanuvox RMax Ductboard Manual de usuario
Sanuvox
Sanuvox GC S300-G2 Manual de usuario
Sanuvox
Sanuvox SANUVAIR S300 OZD Manual de usuario
Sanuvox
Sanuvox VP900 Manual de usuario
Sanuvox
Sanuvox SANUVAIR S1000 CRO Manual de usuario
Sanuvox
Sanuvox R1r Manual de usuario
Sanuvox
Sanuvox Quattro Manual de usuario
Sanuvox
Sanuvox SANUVAIR S100 Manual de usuario
Sanuvox
Sanuvox S300 Manual de usuario
Sanuvox
Sanuvox S1000 Manual de usuario
Sanuvox
Sanuvox P900-GX Manual de usuario
Sanuvox
Sanuvox HRV6 Manual de usuario
Sanuvox
Sanuvox SR MAX Manual de usuario
Sanuvox
Sanuvox S300 Manual de usuario
Sanuvox
Sanuvox Quattro Manual de usuario
