Rice Lake OS-10 Manual

RICE LAKE OS-10/OS-25/OS-45

On-Site Hanging Scale

Operators Guide

230 W. Coleman St. • Rice Lake, WI 54868 • USA

U.S. 800-472-6703 • Canada/Mexico 800-321-6703 • International 715-234-9171 • Europe +31 (0)26 472 1319

Rice Lake Weighing Systems is an ISO 9001 registered company.

www.ricelake.com

PN 131079 Rev BJanuary 9, 2020

2 Visit our website www.RiceLake.com

Safety

Failure to heed

may result in minor or moderate injury.

DO NOT operate or work on scale unless you have read and

understand this manual.

Do not use for purposes other than weighing.

Do not leave loads unattended.

Do not Overload - it can damage the scale and will render the warranty null and void.

Cleaning

•Always turn scale off before cleaning.

•Alcohol based wipes when cleaning the scale are recommended.

•DO NOT spray with or submerse into water when cleaning.

•Refrain from using corrosive liquids or high pressure washers.

•Improper cleaning will render the warranty null and void.

Inserting/Replacing Battery

When LO appears on display, replace batteries with

two 1.5V AA batteries.

1. Remove the battery cover located on back of scale.

2. Remove batteries and dispose of properly.

3. Install new AA batteries according to the diagram in

the battery cavity.

4. Replace battery cover securely.

Error Messages

Limited Warranty

All systems and components are warranted against defects in materials and workmanship

for one year. For further information see www.ricelake.com.

Error Action Display

Low Battery Replace the batteries.

Over Load - Total load exceeds the

maximum capacity.

Remove weight from the

scale immediately.

Over Zero - Zero count is higher than the

setting range.

Scale turns off if status

continues 30 secs or longer.

Below Zero

Zero count is below the setting range.

Scale turns off if status

continues 30 secs or longer.

EEPROM error Call for service.

Table 1. Error Messages

CAUTION

IMPORTANT

Batteries

Battery Cover

Err

ErrL

ErrE

Display and Button Functions

Figure 1. Hanging Scale

Operating Scale

Suspend the scale in a secure location.

Use scale in a vertical position only.

1. Press to power on.

2. Press to select units.

3. Suspend container from hook if one will be used.

4. Press to zero scale.

5. Place product on the scale, weight will appear in the display.

6. To turn the scale off, press and hold .

Key Item Description

1 Minus Signifies a negative weight.

2 Hold Signifies the weight is held.

3 Power/Zero Press to turn scale on.

Press to reset scale to zero.

Press and hold to turn scale off.

4 Units Select kilograms, pounds or pounds and ounces.

5 Hold Press to hold weight. Press again to release weight.

Table 2. Display and Button Function

POWER

ZERO

UNITS

Units

Minus

Hold

Capacity: 10.00kgx0.01kg/22lbx0.02lb/22lbx1/4oz

HOLD

Note

POWER

ZERO

UNITS

Units

POWER

ZERO

POWER

ZERO

4 Visit our website www.RiceLake.com

Hold Function

1. Press , when weight stabilizes display will lock and arrow will be steady.

2. Press to release locked weight.

Adjusting Auto-Off

1. Press to power on.

2. Press and hold . When AOFF displays, release.

3. Press to select auto-off time (OFF, 120, 180, 240, 300 seconds).

4. Press to return normal weighing mode.

Calibration

Calibrate using the following process:

1. Press and hold .

2. Press three times, ZERO COUNT displays.

3. Press , zero displays.

4. Press to select calibration unit.

5. Load appropriate amount of weight on scale (See Table 3). Display shows span count.

6. Press , CAL displays, then the weight.

7. Remove the weight, re-power the scale and calibration is complete.

Table 3. Calibration Weights

Model kg lb

OS10 10kg 20lb

OS25 20kg 40lb

OS45 20kg 40lb

HOLD

POWER

ZERO

UNITS

Units

HOLD

UNITS

Units

POWER

ZERO

UNITS

Units

POWER

ZERO

UNITS

Units

POWER

ZERO

Certification

This device complies with Part 15 of the FCC Rules.

Operation is subject to the following two conditions:

(1) this device may not cause harmful interference, and

(2) this device must accept any interference that may

cause undesired operation.

Otros manuales para OS-10

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Escala de Rice Lake

Rice Lake

Rice Lake 140-10-7 Series Instrucciones de funcionamiento

Rice Lake

Rice Lake CLS420 Manual de usuario

Rice Lake

Rice Lake Summit SB-1000 Manual de usuario

Rice Lake

Rice Lake RL1200 Manual de usuario

Rice Lake

Rice Lake Versa-portion RLP-S Manual de usuario

Rice Lake

Rice Lake MSI-4260 IS Manual de usuario

Rice Lake

Rice Lake Digi DI-10 Manual de usuario

Rice Lake

Rice Lake Digi DC-400 Manual de usuario

Rice Lake

Rice Lake D300 Series Manual de usuario

Rice Lake

Rice Lake 150-10-5 Manual de usuario

Rice Lake

Rice Lake TC Manual de usuario

Rice Lake

Rice Lake equipoise Manual de usuario

Rice Lake

Rice Lake 250-10-2 Manual de usuario

Rice Lake

Rice Lake RL1100EM Manual de usuario

Rice Lake

Rice Lake RS-130 Manual de usuario

Rice Lake

Rice Lake RoughDeck FXB Manual de usuario

Rice Lake

Rice Lake 260-10-1 Manual de usuario

Rice Lake

Rice Lake 112566 Manual de usuario

Rice Lake

Rice Lake Ishida Uni-7 Series Guía del usuario

Rice Lake

Rice Lake IQ-6000 Manual de usuario

Rice Lake

Rice Lake 350-10-3 Manual de usuario

Rice Lake

Rice Lake Summit SD-1150-WP Manual de usuario

Rice Lake

Rice Lake RL-MPS-50 Manual de usuario

Rice Lake

Rice Lake VS-11 Manual de usuario

Manuales populares de Escala de otras marcas

AWS

AWS ZEO-50 Manual de usuario

Gima

Gima Glass Body Fat Analyzer Manual de lista de piezas

Seca

Seca 374 Manual de usuario

TEC

TEC TEC SL59 SERIES Manual de usuario

Axis

Axis B/E Series Manual de usuario

Alecto

Alecto ACW-40 Manual de usuario

IKA

IKA RCT basic safety control Manual de usuario

ADE

ADE M20011 Manual de usuario

Duronic

Duronic KS3000 Manual de usuario

Digi

Digi SM-720 Manual de usuario

Cardinal

Cardinal CS Series Manual de usuario

Korona

Korona Kastella Manual de usuario

A&D

A&D FC-50Ki Manual de usuario

BDA

BDA CAMARGUE Manual de usuario

Tanita

Tanita HD-357 Manual de usuario

Leifheit

Leifheit 03173 Manual de usuario

Lumme

Lumme LU-1340 Manual de usuario

Fidelity Electronics

Fidelity Electronics G2e Manual de usuario