Rancilio EGRO 5513 Manual de usuario
Egro Operating Man. 5513 V1.3
© Copyright 2007. Rancilio North America
OPERATING MANUAL
EGRO MODEL 5513
INTRODUCTION
HOW TO OPERATE EGRO 5513
DAILY CLEANING INSTRUCTIONS
WEEKLY CLEANING INSTRUCTIONS
9
9
9
9
~2 ~Egro Operating Man. 5513 V1.3
© Copyright 2007. Rancilio North America
OPERATING MANUAL
EGRO MODEL 5513
TABLE OF CONTENTS
A. INTRODUCTION..................................................................................... 3 - 4
- Parts of the machine are identified
B. HOW TO OPERATE................................................................................. 5 - 7
- Explanation of how to operate the machine
- How to steam milk
- How to empty the grounds drawer
C. DAILY CLEANING................................................................................... 8 - 11
- How to run the daily automatic coffee cleaning program
- How to run the daily automatic milk cleaning program
- How to wipe off the machine
D. WEEKLY CLEANING................................................................................ 12 - 15
- How to clean the frother heads
- How to clean the AFV valve
- How to clean the hoppers
E. QUICK TROUBLESHOOTING TIPS............................................................. 16
- What to do if no milk is coming out of frother heads
- What to do if no coffee/espresso is coming out of outlet
~3 ~Egro Operating Man. 5513 V1.3
© Copyright 2007. Rancilio North America
INTRODUCTION TO EGRO 5513
PARTS OF THE MACHINE
FRIDGE
DOOR TO FRIDGE
LEGS
DRIP TRAYS
STEAM WAND
DOOR TO GROUNDS
DRAWER
HOT WATER
WAND
DISPLAY &
KEY PAD
HOPPERS
CLOSE-UP OF MACHINE PARTS
AFV
VALVE
STAINLESS STEEL
OUTLET COVER
COFFEE
OUTLET
FROTHER
HEADS
MILK PUMP
HOUSING
HOSES TO
MILK
STANDARD
MILK
GALLON
~4 ~Egro Operating Man. 5513 V1.3
© Copyright 2007. Rancilio North America
AFV (Air Foam Valve)
The AFV is a mechanical valve that controls the air flow into the
frother heads.
Typically on one-step superautomatic espresso machines,
the air is controlled by expensive air solenoids that become
clogged with milk due to a natural vacuum that can occur.
These solenoids then require a certified technician to clean them.
With the Egro AFV if this natural vacuum occurs and milk is
sucked back up to the AFV it is an easy 3 step process to clean
the valve and you’re back up and running in no time.
We recommend that you clean this valve weekly to ensure that
the machine runs smoothly.
INTRODUCTION TO EGRO 5513
DEFINITION OF PARTS
Frother Heads
The frother heads are where the “magic” of milk
foaming and milk heating takes place. Steam is
used to heat fresh milk, transported from the
fridge through hoses to the frother heads (clear hoses).
Milk is delivered into the side of the top section
of the frother heads via the clear hose.
Steam is delivered into the top of the frother
heads via the pink hose.
Air is delivered to the side of the lower section
of the frother heads via the frosted clear hoses .
Exploded view of
frother head
Top section:
Steam and Milk
hoses connect to
this section
Mid-Section
Lower section:
Air hose
connects to this
section
Bean Slides
Bean slides are used to hold the beans in the hopper
while you remove the hoppers for cleaning. Two are provided with each machine.
Cleaning Tablets and Milk Cleaning Solution
There are several different brands of coffee cleaning tablets and milk cleaning solutions
available. We recommend that you use either Urnex Rinza milk cleaning solution or Puro Caff
milk cleaning solution. When it comes to coffee cleaning tablets we recommend that you
use the cleaning tablets provided with your Egro equipment or the Urnex Cafiza Espresso
Cleaning Tablets.
~5 ~Egro Operating Man. 5513 V1.3
© Copyright 2007. Rancilio North America
HOW TO OPERATE
MAKING A DRINK
1
Adjust the outlet to your cup
size by sliding it up or down
2
Choose the type of drink and
press the button
3
Wait for the machine to make
the drink. Enjoy!
FILLING BEAN HOPPERS
2
1
Remove hopper lid and pour
in beans
Replace hopper lid. Be sure
that is secured tightly into the
hopper
~6 ~Egro Operating Man. 5513 V1.3
© Copyright 2007. Rancilio North America
STEAMING MILK
HOW TO OPERATE
21
3 54
Press the steam button once. A short burst of
water will come out of the steam wand. Press
the steam button again to shut it off.
Fill a steaming pitcher half full with
fresh milk. Slide steaming pitcher
under steam wand and temp.
probe until both tips are under the
surface of milk.
Press Steam button to start
steaming.
Keep steam wand and
temp. probe in milk.
Steaming stops automatically
once milk has reached pre-
programmed temperature.
Press the steam button once. Let
steam escape from wand for
about 2 seconds. Press button
again to shut off.
Wipe steam wand clean
with a damp towel.
CAUTION:
WAND IS HOT
NEVER LET MILK DRY
ON STEAM WAND!
~7 ~Egro Operating Man. 5513 V1.3
© Copyright 2007. Rancilio North America
EMPTYING GROUNDS DRAWER
1 2 3
4
Display will read “Drawer
full” when it is time to
empty the grounds drawer.
5
HOW TO OPERATE
6
Slide the coffee/milk
outlet upward, above the
grounds drawer door.
Pull the steam wand out
and to the side away from
the grounds drawer door.
Push the tea wand upward
above the grounds drawer
door.
Using two hands pull
forward on the grounds
drawer door.
Remove the black plastic
grounds drawer and
dispose of the grounds.
7
Replace the empty grounds
drawer back into the
machine.
Close grounds drawer door.
Be sure to line tabs of door
into slots on machine before
closing.
8
EMPTY THE GROUNDS
DRAWER EVERY TIME YOU
OPEN THE GROUNDS
DRAWER DOOR.
The “Drawer full” alarm will
not work properly if you don’t.
!
!
~8 ~Egro Operating Man. 5513 V1.3
© Copyright 2007. Rancilio North America
DAILY CLEANING GUIDE: EGRO 5513
STEP 1: RUN THE AUTOMATIC
COFFEE
CLEANING PROGRAM
Press and hold STOP button
until display reads:
1. CAP
2. COFFEE
3. AUTO RINSE
Select number 2. COFFEE by
pressing the number 2 (Clean)
button on the key pad.
Display will read:
INSERT TAB.
Insert one coffee cleaning
tablet into chute on top of
machine.
Press STOP button and the
automatic cleaning will
begin. The cleaning
process takes about five
minutes.
Continued on next
page...
Ö
Display will read, PLEASE
SELECT when coffee
cleaning is finished.
1.1 1.2 1.3
1.4 1.5 1.6
~9 ~Egro Operating Man. 5513 V1.3
© Copyright 2007. Rancilio North America
STEP 2: RUN THE AUTOMATIC
MILK
CLEANING PROGRAM
Press and hold STOP button
until display reads:
1. CAP
2. COFFEE
3. AUTO RINSE
Select number 1. CAP by
pressing the number 1
(Decaf) button on the key
pad.
Display will read:
CLEANING PRODUCT.
Open fridge door and
remove hoses from gallon
of milk, and remove it from
fridge.
Place hoses into container
containing milk cleaning
solution.
Press STOP button and
display will read:
CLEANING 99...98...97...
Continued on next
page...
Ö
2.1 2.2 2.3
To mix the milk cleaning
solution, use a clean container
or large steaming pitcher. Mix
1oz (one shot) of Espresso
Dairy Cleaner with about
32oz of water.
NOTE: Water should NOT be hot!
DAILY CLEANING GUIDE: EGRO 5513
2.4 2.5 2.6
~10 ~Egro Operating Man. 5513 V1.3
© Copyright 2007. Rancilio North America
Press the STOP button and the
display will read:
RINSE 99...98...97...
Automatic milk cleaning
program is completed when
the machine is finished rinsing
and the display reads:
PLEASE SELECT
STEP 2: AUTOMATIC
MILK
CLEANING PROGRAM -- Continued
When display reads: CLEAN
WATER remove milk solution
container from fridge and
replace it with a container
containing fresh clean water.
Remove the water container
from the fridge and return
the gallon of milk.
2.7 2.8 2.9
2.10
Continued on next
page...
Ö
DAILY CLEANING GUIDE: EGRO 5513
Tabla de contenidos
Otros manuales de Cafetera de Rancilio
Rancilio
Rancilio Baby 9 Manual de usuario
Rancilio
Rancilio Classe 6 E Manual de usuario
Rancilio
Rancilio Baby 9 Manual de usuario
Rancilio
Rancilio EPOCA E Manual de usuario
Rancilio
Rancilio Classe 8 DE Manual de usuario
Rancilio
Rancilio CLASSE 9 Manual de usuario
Rancilio
Rancilio Classe 8 S Manual de usuario
Rancilio
Rancilio Classe 10S Manual de usuario
Rancilio
Rancilio EPOCA 2GR. E Manual de usuario
Rancilio
Rancilio Classe 6 E Manual de usuario
Rancilio
Rancilio CLASSE 5 Manual de usuario
Rancilio
Rancilio Silvia PID Kit Manual de usuario
Rancilio
Rancilio 10 USB Manual de usuario
Rancilio
Rancilio Baby 9 Manual de usuario
Rancilio
Rancilio EPOCA E Manual de usuario
Rancilio
Rancilio EGRO 55 Series Manual de usuario
Rancilio
Rancilio EGRO ONE Touch Pure Coffee Manual de usuario
Rancilio
Rancilio S20 Guía del usuario
Rancilio
Rancilio Classe 8 S Guía del usuario
Rancilio
Rancilio Silvia Manual de usuario
