Pickering 42-724 Manual de usuario

pickeringtest.com

Issue 1.2 November 2022

40/42-724 User Manual

PXI/PXIe 32x8 RF Matrix Module

Page (II) 32X8 RF MATRIX MODULE 40/42-724

pickering

Page (II) REED RELAY MODULE 40-110/115/120/125

pickering

No part of this publication may be reproduced, transmitted, transcribed, translated or stored in any form, or by

any means without the written permission of Pickering Interfaces.

Technical details contained within this publication are subject to change without notice.

ISO 9001

Reg No. FM38792

Page (III)

32X8 RF MATRIX MODULE 40/42-724

pickering

Page (III)

REED RELAY MODULE 40-110/115/120/125

pickering

TECHNICAL SUPPORT

For Technical Support please contact Pickering Interfaces either by phone, the website or via e-mail.

WARRANTY

All products manufactured by Pickering Interfaces are warranted against defective materials and workmanship for a period of

three years, excluding programmable power supplies, from the date of delivery to the original purchaser. Any product found to be

defective within this period will, at the discretion of Pickering Interfaces be repaired or replaced.

Products serviced and repaired outside of the warranty period are warranted for ninety days.

Extended warranty and service are available. Please contact Pickering Interfaces by phone, the website or via e-mail.

ENVIRONMENTAL POLICY

Pickering Interfaces operates under an environmental management system similar to ISO 14001.

Pickering Interfaces strives to full all relevant environmental laws and regulations and reduce wastes and releases to the

environment. Pickering Interfaces aims to design and operate products in a way that protects the environment and the health and

safety of its employees, customers and the public. Pickering Interfaces endeavours to develop and manufacture products that can

be produced, distributed, used and recycled, or disposed of, in a safe and environmentally friendly manner.

Worldwide Technical Support and Product Information

pickeringtest.com

Germany

Tel: +49 89 125 953 160

E-mail: [email protected]

Sweden

Tel: +46 340-69 06 69

E-mail: [email protected]

USA

Tel: (West) +1 541 471 0700

Tel: (East) +1 781 897 1710

E-mail: [email protected]

Czech Republic

Tel: +420 558 987 613

E-mail: [email protected]

France

Tel +33 9 72 58 77 00

E-mail [email protected]

Pickering Interfaces Headquarters

Stephenson Road Clacton-on-Sea CO15 4NL United Kingdom

Tel: +44 (0)1255-687900

E-Mail: [email protected]

China

Tel: +86 4008 799 765

E-mail: [email protected]

Page (IV) 32X8 RF MATRIX MODULE 40/42-724

pickering

Page (IV) REED RELAY MODULE 40-110/115/120/125

pickering

MEANING / DESCRIPTION SYMBOL

PROTECTIVE EARTH (GROUND)

To identify any terminal which is intended for connection to an external conductor for

protection against electric shock in case of a fault, or the terminal of a protective earth

(ground) electrode.

DANGEROUS VOLTAGE

To indicate hazards arising from dangerous voltages.

WARNING / CAUTION

An appropriate safety instruction should be followed or caution to a potential hazard

exists.

Refer to the relevant instructions detailed within the product manual.

HEAVY

If this product is heavy reference should be made to the safety instructions for

provisions of lifting and moving.

STATIC SENSITIVE

To indicate that static sensitive devices are present and handling precautions should

be followed.

SAFETY SYMBOLS

PRODUCT SAFETY

The following safety symbols may be used on the product and throughout the product documentation.

Page (V)

32X8 RF MATRIX MODULE 40/42-724

pickering

Technical Support and Warranty................................................III

Product Safety .............................................................................IV

Contents (this page)....................................................................V

Warnings and Cautions ..............................................................VII

Section 1

Technical Specication...............................................................1.1

Section 2

Technical Description .................................................................2.1

Functional Description..........................................................2.1

Section 3

Installation....................................................................................3.1

Pre Operation Checks...........................................................3.1

Hardware Installation ............................................................3.2

Software Installation .............................................................3.2

Testing Operation ..................................................................3.3

Section 4

Programming Guide....................................................................4.1

Programming Options For Pickering PXI/PXIe Modules ...4.1

Module Architecture..............................................................4.2

Programming Sub-Units ......................................................4.3

Programming The Module ....................................................4.4

Section 5

Connector Information................................................................5.1

Section 6

Trouble Shooting .........................................................................6.1

Section 7

Maintenance Information............................................................7.1

Switching System Test Tools ...............................................7.1

Relay Lookup Tables ............................................................7.1

Component Layout ...............................................................7.3

CONTENTS

Page (VI) 32X8 RF MATRIX MODULE 40/42-724

pickering

THIS PAGE INTENTIONALLY BLANK

Page (VII)

32X8 RF MATRIX MODULE 40/42-724

pickering

Page (VII)

REED RELAY MODULE 40-110/115/120/125

pickering

WARNINGS AND CAUTIONS

WARNING - HAZARDOUS ENVIRONMENTS SYMBOL

atmospheres. If the product is to be used in hazardous environments we recommend that the user

ensures suitable protective measures are taken.

WARNING - DANGER OF ELECTRIC SHOCK SYMBOL

This module may contain hazardous voltages. Before removing the module from the rack remove all

supplies and disconnect user I/O signals.

Unused slots in the host chassis are populated with blanking plates to prevent access to user

I/O signals that may be present. Blanking panels are available to order from Pickering in a variety

of slot widths. If the product is not used in this manner for example by using an extender card then

additional care must be taken to avoid contact with exposed signals.

CAUTION - HANDLING OF ELECTROSTATIC-SENSITIVE DEVICES SYMBOL

Certain semiconductor devices used in this equipment are liable to damage due to static voltage.

Observe the following precautions when handling these devices in their unterminated state, or

sub-assemblies containing these devices:

1. Persons removing sub-assemblies from equipment using these devices must be earthed by a

wrist strap and a resistor at the point provided on the equipment.

2. Soldering irons used during the repair operations must be low voltage types with earthed tips and

isolated from the mains voltage by a double insulated transformer.

3. Outer clothing worn must be unable to generate static charges.

anti-static bags.

CAUTION - PRODUCT DOCUMENTATION SYMBOL

and understood before attempting to install or operate the product.

SAFETY INSTRUCTIONS

All cleaning and servicing requires the equipment to be isolated and disconnected from the power source and user I/O

signals (refer to the Maintenance Section).

• Appropriate manual handling procedures should be followed as dictated by the weight of the individual module or

the combined weight of the modules & chassis.

• Should a fault occur with the module or chassis, immediately isolate and disconnect the incoming power to the

chassis and the user I/O signals.

• Ensure the equipment is installed, operated and maintained by trained and authorised personnel.

• For suitably equipped products in the event of an emergency press the red “emergency stop” button situated on

the front of the unit.

Page (VIII) 32X8 RF MATRIX MODULE 40/42-724

pickering

THIS PAGE INTENTIONALLY BLANK

Page 1.1

32X8 RF MATRIX MODULE 40/42-724

pickering SECTION 1 - TECHNICAL SPECIFICATION

SECTION 1 - TECHNICAL SPECIFICATION

pickeringtest.com

PXI/PXIe 32x8 RF Coaxial Matrix Modules 40/42-724

ISSUE 1.2 NOV 2022

yAvailable as PXI or PXIe Modules

yEasy to Use Loop-thru Option Allows Unlimited

X Axis Expansion

y300 MHz Usable Bandwidth, 150 MHz With Loop-thru

yVISA & IVI Drivers Supplied for Windows

yPXI Version Supported by PXI or LXI Chassis

ySupported by

eBIRST

™

y3 Year Warranty

40/42-724-021-L

32x8 Matrix With

Loop-Thru

The 40-724 (PXI) and 42-724 (PXIe) are RF matrix modules

suitable for switching frequencies up to 300 MHz. Having a

50 Ω characteristic impedance and front panel SMB

connectors, these modules provide a simple and scalable

bidirectional matrix for RF and are intended for the easy

construction of high performance switching systems.

The 40/42-724-021-L version includes Y loop-thru connectors

to allow easy matrix expansion between adjacent modules.

All X and Y connections have isolation switches. These can be

used to disconnect the matrix from the external test ﬁxture to

maximize isolation and RF performance.

Matrix Operation

The 40/42-724 is a high density matrix designed to provide a

Y to X connection to maximize bandwidth.

This module is based on the same construction as the

popular 40-725 RF matrix, but has increased capacity and

optional Y axis loop thru allowing easy expansion.

Supported by

eBIRST

This module is supported by eBIRST test tools. These

simplify switching fault-ﬁnding by quickly testing the

system and graphically identifying the faulty relay.

For more information go to: pickeringtest.com/ebirst

Other RF Matrix Modules in Pickering’s PXI Range:

40-725 8x9 500 MHz, 50 Ω/75 Ω

40-726A 12x8 300 MHz, 50 Ω/75 Ω - Optional Y Loop-Thru

40-727 16x4 300 MHz, 50 Ω/75 Ω - Optional Y Loop-Thru

40-728 16x2 300 MHz, 50 Ω/75 Ω - Optional Y Loop-Thru

40-729 8x4 300 MHz, 50 Ω/75 Ω - Optional Y Loop-Thru

40-750 8x2 1.5 GHz, 50 Ω/75 Ω - Y Loop-Thru

40/42-877A Single/dual 2x2 2.5 GHz, 50 Ω

40/42-837A Single/dual 2x2 2.5 GHz, 75 Ω

45-720A 6 U, 16x16 250 MHz, 50 Ω/75 Ω - Y Loop-Thru

Alternative LXI Ethernet Controlled RF Matrices:

60-760 Single/Dual 24x8 25 MHz, 50 Ω

60-711 Single/Dual 24x8 25 MHz, 75 Ω

65-110A Scalable 24x8 to 104x16 200 MHz, 50 Ω

X30

X31

X32

Isolation

Switches

Crosspoint

40/42-724-021 32x8 Matrix Without Loop-Thru

X30

X31

X32

Isolation

Switches

Crosspoint

YLT1

YLT2

YLT3

YLT4

YLT5

YLT6

YLT7

YLT8

Page 1.2 32X8 RF MATRIX MODULE 40/42-724

pickering

SECTION 1 - TECHNICAL SPECIFICATION

32x8 RF Coaxial Matrix, 40/42-724

pickeringtest.com

Overview

96x8 RF Matrix Created from 2-off 40/42-724-021-L and 1-off 40/42-724-021

(Loop-thru cables interconnect the Y-buses of each 32x8 matrix module)

Y Axis Loop-Thru

The easy to use loop-thru option allows 40/42-724 modules to be cascaded to form larger matrices whilst

minimizing impact on RF performance.

The 40/42-724-021-L version of the module has Y loop-thru connectors on the front panel which are simply

plugged into the Y connectors of the adjacent matrix module via SMB to SMB coaxial cables.

The loop thru system is designed to provide an extended connection from Y to X.

The inter-module front panel wiring for an example 96x8 matrix is shown below and the switching diagram is

show overleaf.

40/42-724-021-L

Module #1

40/42-724-021-L

Module #2

40/42-724-021

Module #3

X Connections

Y Connections

Y Loop-Thru

Connections

Y Loop-Thru

Coaxial Cables

pickering pickering pickering

X Connections

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Unidad de control de Pickering

Pickering

Pickering 40-265 Manual de usuario

Pickering

Pickering 40-528A Manual de usuario

Pickering

Pickering 40-262 Manual de usuario

Pickering

Pickering 40-533B Manual de usuario

Pickering

Pickering 45-542 Manual de usuario

Pickering

Pickering 40-651 Manual de usuario

Pickering

Pickering SYSTEM 10 Manual de usuario

Pickering

Pickering 4x-727A Manual de usuario

Pickering

Pickering PXI 40-855 Manual de usuario

Pickering

Pickering 40-670A Manual de usuario

Pickering

Pickering 40-220A Manual de usuario

Pickering

Pickering PXI 40-785 Manual de usuario

Pickering

Pickering 41-180 Manual de usuario

Pickering

Pickering PXI 40-795-001 Manual de usuario

Pickering

Pickering 40-656A Manual de usuario

Pickering

Pickering 41-761 Manual de usuario

Pickering

Pickering 40-519A Manual de usuario

Pickering

Pickering Pxi 41-660 Manual de usuario

Pickering

Pickering SYSTEM 10 Manual de usuario

Pickering

Pickering 40-519B Manual de usuario

Pickering

Pickering 40-581 Manual de usuario

Pickering

Pickering 40-574 Manual de usuario

Pickering

Pickering PXI 40-710 Manual de usuario

Pickering

Pickering 41-670 Manual de usuario

Manuales populares de Unidad de control de otras marcas

Festo

Festo Compact Performance CP-FB6-E Manual de lista de piezas

Elo TouchSystems

Elo TouchSystems DMS-SA19P-EXTME Manual de usuario

JS Automation

JS Automation MPC3034A Manual de usuario

JAUDT

JAUDT SW GII 6406 Series Guía rápida

Spektrum

Spektrum Air Module System Manual de usuario

BOC Edwards

BOC Edwards Q Series Manual de usuario

KHADAS

KHADAS BT Magic Manual de usuario

Etherma

Etherma eNEXHO-IL Manual de usuario

PMFoundations

PMFoundations Attenuverter Manual de usuario

GEA

GEA VARIVENT Manual de usuario

Walther Systemtechnik

Walther Systemtechnik VMS-05 Manual de usuario

Altronix

Altronix LINQ8PD Instrucciones de montaje

Eaton

Eaton Powerware Series Manual de usuario

WAGO

WAGO 750-407/040-000 Manual de usuario

Sony

Sony CCU-590 Manual de usuario

Graco

Graco 25D614 Manual de usuario

Task Force Tips

Task Force Tips YE-RF-900 Manual de programación

Shini

Shini SPV-U Series Manual de usuario