Mitsubishi Electric Melsensor FA-CF26-SR Manual de servicio

Code Reader Setting Guide

-CF26-SR

-CF26-LR

This product is designed and manufactured by Cognex Corporation.

*Note that the warranty and general specifications of this product

differ from that of programmable controller products.

SAFETY PRECAUTIONS

(Read these precautions before using this product.)

Before using this product, please read this manual and the relevant manuals carefully and pay full attention to safety to handle

the product correctly.

The precautions given in this manual are concerned with this product only. For the safety precautions for other modules, refer

to their respective user's manuals.

In this manual, the safety precautions are classified into two levels: " WARNING" and " CAUTION".

Under some circumstances, failure to observe the precautions given under " CAUTION" may lead to serious

consequences.

Observe the precautions of both levels because they are important for personal and system safety.

Make sure that the end users read this manual and then keep the manual in a safe place for future reference.

[Installation Precautions]

[Wiring Precautions]

[Startup and Maintenance Precautions]

WARNING

●Before handling the product, touch a conducting object such as a grounded metal to discharge the

static electricity from your body. Failure to do so may cause the code reader to fail or malfunction.

●Be sure to install an I/O connector module to a main module. If not installed, dust or water-proof

performance may not be obtained.

CAUTION

●IP protection rating is guaranteed only when all the connectors are connected with cables or sealed

with sealing caps.

●The cable is designed to connect with its key aligned with the keyway of the connector on the code

reader. Do not force the connections or damage may occur.

CAUTION

●Use only 24 VDC and observe the indicated polarity. Otherwise, fire or damage may result.

CAUTION

●Do not clean this product with highly irritating or corrosive solvent such as caustic alkali solution,

methyl ethyl ketone (MEK), and gasoline. Doing so may cause a fault.

WARNING Indicates that incorrect handling may cause hazardous conditions, resulting in

death or severe injury.

CAUTION Indicates that incorrect handling may cause hazardous conditions, resulting in

minor or moderate injury or property damage.

CONDITIONS OF USE FOR THE PRODUCT

(1) This code reader shall be used in conditions;

i) where any problem, fault or failure occurring in the code reader, if any, shall not lead to any major or serious accident;

and

ii) where the backup and fail-safe function are systematically or automatically provided outside of the code reader for

the case of any problem, fault or failure occurring in the code reader.

(2) This code reader has been designed and manufactured for the purpose of being used in general industries.

MITSUBISHI SHALL HAVE NO RESPONSIBILITY OR LIABILITY (INCLUDING, BUT NOT LIMITED TO ANY AND ALL

RESPONSIBILITY OR LIABILITY BASED ON CONTRACT, WARRANTY, TORT, PRODUCT LIABILITY) FOR ANY

INJURY OR DEATH TO PERSONS OR LOSS OR DAMAGE TO PROPERTY CAUSED BY THIS CODE READER

THAT ARE OPERATED OR USED IN APPLICATION NOT INTENDED OR EXCLUDED BY INSTRUCTIONS,

PRECAUTIONS, OR WARNING CONTAINED IN MITSUBISHI'S USER, INSTRUCTION AND/OR SAFETY MANUALS,

TECHNICAL BULLETINS AND GUIDELINES FOR the CODE READER.

("Prohibited Application")

Prohibited Applications include, but not limited to, the use of the code reader in;

• Nuclear Power Plants and any other power plants operated by Power companies, and/or any other cases in which the

public could be affected if any problem or fault occurs in the code reader.

• Railway companies or Public service purposes, and/or any other cases in which establishment of a special quality

assurance system is required by the Purchaser or End User.

• Aircraft or Aerospace, Medical applications, Train equipment, transport equipment such as Elevator and Escalator,

Incineration and Fuel devices, Vehicles, Manned transportation, Equipment for Recreation and Amusement, and

Safety devices, handling of Nuclear or Hazardous Materials or Chemicals, Mining and Drilling, and/or other

applications where there is a significant risk of injury to the public or property.

Notwithstanding the above, restrictions Mitsubishi may in its sole discretion, authorize use of the code reader in one or

more of the Prohibited Applications, provided that the usage of the code reader is limited only for the specific

applications agreed to by Mitsubishi and provided further that no special quality assurance or fail-safe, redundant or

other safety features which exceed the general specifications of the code readers are required. For details, please

contact the Mitsubishi representative in your region.

CONTENTS

SAFETY PRECAUTIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1

CONDITIONS OF USE FOR THE PRODUCT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2

CHAPTER 1 INTRODUCTION 5

1.1 About This Manual . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

Relevant manuals . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

1.2 DataMan Setup Tool Overview . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

CHAPTER 2 SetupTool INSTALLATION 7

2.1 Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

Operating environment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

Installation procedure . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

CHAPTER 3 CODE READER SETUP FLOW CHART 11

3.1 Setup Flow Chart . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11

CHAPTER 4 CONFIGURATIONS 13

4.1 Configuration and Wiring of CF 26 Series . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13

CHAPTER 5 CONNECTING with SetupTool 15

5.1 How to Check and Set Personal Computer IP Address . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16

5.2 Starting SetupTool. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19

5.3 How to Check and Set Code Reader IP Address . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20

CHAPTER 6 SetupTool SCREEN 23

6.1 Screen Configuration . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23

6.2 Shortcut Operation Icon . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25

6.3 Application Steps . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26

6.4 Menu Tabs and Operation Icons . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27

6.5 Image Panel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28

6.6 Result History . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30

6.7 Screen Layout Customization (1). . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31

6.8 Screen Layout Customization (2). . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32

6.9 Screen Layout Customization (3). . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 33

CHAPTER 7 SETTING CODE READER 35

7.1 Installing a Code Reader . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 35

Points for installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 35

7.2 Settings in Tune. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 36

7.3 Parameter Setting Using a Configuration File . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 38

CHAPTER 8 Application Steps 40

8.1 Optimize Image . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 40

8.2 Code Details. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 43

8.3 Application Details . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46

Trigger settings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46

Exposure . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 51

Decode Settings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 53

8.4 Format Data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 55

8.5 Inputs/Outputs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 57

TRIG Button. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 57

TUNE Button . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 59

Inputs. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 60

Outputs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 62

Output Delay . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 63

8.6 Communications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 64

Serial . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 64

Ethernet: CC-Link IE Field Basic . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 64

Ethernet: SLMP . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 65

8.7 Save Settings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 66

CHAPTER 9 HOME TAB FUNCTIONS 67

9.1 Backup . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 67

9.2 Restore . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 69

9.3 Update Firmware . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 72

9.4 Language Settings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 74

APPENDIX 76

Appendix 1 Read Setups . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 76

Appendix 2 Code Quality. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 79

Appendix 3 External Transfer of Images and Reading Results Using FTP . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .81

Appendix 4 Supplemental Remarks for Tuning (1) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85

Appendix 5 Supplemental Remarks for Tuning (2) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 86

Appendix 6 Tuning After Optimizing Maximum Exposure Time . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 87

Appendix 7 Exposure Time, Gain Factor, and Image Filtering . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 89

Appendix 8 Customizing Output Data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 91

Appendix 9 Setting an IP Address to a Code Reader (DHCP) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 93

Appendix 10Virtual Device . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 94

REVISIONS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .97

TRADEMARKS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .98

1 INTRODUCTION

1.1 About This Manual 5

1INTRODUCTION

1.1 About This Manual

This manual describes the basic operations of DataMan Setup Tool.

For more detailed description of the DataMan Setup Tool, use [Q & A] or [Help] on the DataMan Setup Tool menu.

Relevant manuals

1.2 DataMan Setup Tool Overview

DataMan Setup Tool (hereafter referred to as SetupTool) is a tool for setting the operation of MELSENSOR Code Reader CF

Series. Each process for connecting, adjusting, and testing MELSENSOR Code Reader CF Series can be set easily in

accordance with application steps.

Manual name [Manual number] Description Available form

Code Reader CF26 User's Manual

[SH-082092ENG]

Functions, installation methods, system configuration, and required hardware

components etc. of the code reader

e-Manual

PDF

Code Reader Connection Guide

[BCN-P5999-1074]

Procedures for connecting a code reader to a MELSEC programmable

controller to control a code reader through a CC-Link IE Field Network Basic

connection, an SLMP connection, an RS-232 connection or an I/O connection

e-Manual

PDF

61 INTRODUCTION

1.2 DataMan Setup Tool Overview

MEMO

2 SetupTool INSTALLATION

2.1 Installation 7

2SetupTool INSTALLATION

2.1 Installation

Operating environment

Installation procedure

For information on how to obtain SetupTool, please contact your local Mitsubishi Electric sales office or representative.

1. Close all running applications.

2. Run the obtained installer.

Select a language to be used for installation and click the [Next] button.

Item Description

Operating system (English version) MicrosoftWindows 7 Professional, Service Pack 1 (32-bit, 64-bit)

MicrosoftWindows10 Professional (32-bit, 64-bit)

Available hard disk capacity 2GB or more

Ethernet 100 Mbps

(1000 Mbps recommended)

82 SetupTool INSTALLATION

2.1 Installation

3. Check that all other applications are closed, and click the [Next] button.

4. After checking the software license agreement, select "I accept the terms of the license agreement" and click the [Next]

button.

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Accesorios de Mitsubishi Electric

Mitsubishi Electric

Mitsubishi Electric PAC-SE41TS-E Manual de usuario

Mitsubishi Electric

Mitsubishi Electric Lossnay PZ-70CSW-E Guía rápida

Mitsubishi Electric

Mitsubishi Electric EMU-CT100 Manual de usuario

Mitsubishi Electric

Mitsubishi Electric R410A Manual de usuario

Mitsubishi Electric

Mitsubishi Electric MELSENSOR Vision Sensor VS20 Series Manual de usuario

Mitsubishi Electric

Mitsubishi Electric MELSENSOR VS70 Series Instrucciones de uso

Mitsubishi Electric

Mitsubishi Electric KD Series Manual de usuario

Mitsubishi Electric

Mitsubishi Electric PAC-SH91MK-E Manual de usuario

Mitsubishi Electric

Mitsubishi Electric KD Series Manual de usuario

Mitsubishi Electric

Mitsubishi Electric PZ-70CSW-E Manual de usuario

Mitsubishi Electric

Mitsubishi Electric KD Series Manual de usuario

Mitsubishi Electric

Mitsubishi Electric MELSENSOR Vision Sensor VS20 Series Manual de instrucciones

Mitsubishi Electric

Mitsubishi Electric MELSEC iQ-R Series Manual de usuario

Mitsubishi Electric

Mitsubishi Electric MELSENSOR Vision Sensor VS20M-11F310 Manual de instrucciones

Mitsubishi Electric

Mitsubishi Electric PZ-70CSB-E Guía rápida

Mitsubishi Electric

Mitsubishi Electric k-con KS9-BS1-A Manual de usuario

Mitsubishi Electric

Mitsubishi Electric KD Series Manual de usuario

Mitsubishi Electric

Mitsubishi Electric RC-380P1 Manual de usuario

Mitsubishi Electric

Mitsubishi Electric IQSS-R-E Manual de usuario

Mitsubishi Electric

Mitsubishi Electric DPLS2 Manual de usuario

Mitsubishi Electric

Mitsubishi Electric PAC-AK53BC Manual de usuario

Mitsubishi Electric

Mitsubishi Electric MELSENSOR VS70 Series Manual de usuario

Manuales populares de Accesorios de otras marcas

Hillco

Hillco 2810 Manual de usuario

Siemens

Siemens QSA2700D Manual del operador

Contours

Contours ZY024 Manual de usuario

Saivod

Saivod VS621 Manual de usuario

Virtuox

Virtuox VirtuCLEAN 2.0 Manual de usuario

SCE

SCE ENVIRO-THERM SCE-TE170B24VSS Manual de usuario

Z-Wave

Z-Wave HSD-200Z Manual de usuario

turck

turck FMX-IM-2UPLI63FX Manual de usuario

Decagon Devices

Decagon Devices 10HS Manual de usuario

UPPAbaby

UPPAbaby Cup Holder Manual de usuario

Elko

Elko SmartSensor Leakage Wireless Manual de usuario

Grizzly

Grizzly H8371 Manual de usuario

Panasonic

Panasonic HG-T Series Manual de usuario

IFM Electronic

IFM Electronic Efector 250 Series Guía de referencia

DigiDesign

DigiDesign 888/24 I/O Manual de usuario

PROZIS

PROZIS QUAY Manual de usuario

patagonia

patagonia PSI Vest Manual de usuario

SFC Energy

SFC Energy EFOY GO! Manual de usuario