MasterChef 85-3129-6 Propane Manual de usuario

SELECT 5-BURNER

PROPANE BARBECUE

Assembly Manual

85-3129-6 (G55105) Propane

1 YEAR LIMITED WARRANTY

ANSI Z21.58-2015 / CSA 1.6-2015

ANSI Z21.58-2015 / CSA 1.6-2015 ANSI Z21.58-2015 / CSA 1.6-2015

ANSI Z21.58-2015 / CSA 1.6-2015

READ AND SAVE MANUAL FOR FUTURE REFERENCE.

Assemble your grill immediately.

Missing or damaged parts claims must be submitted within 30 days of purchase date.

For product inquiries, parts, warranty and troubleshooting support,

please call 1-855-453-2150.

DANGER

1. If you smell Gas:

a. Shut o gas to the appliance.

b. Extinguish any open ame.

c. Open lid.

d. If odor continues, keep away from

the appliance and immediately

call your gas supplier or your

re department.

2. Requires two people to complete the

assembly process.

3. Beware of sharp edges.

WARNING

Failure to follow all of the Manufacturer’s

instructions could result in hazardous res,

explosions, property damage, or serious

personal injury or even death.

Follow all leak check procedures carefully

prior to operation of barbecue, even if grill

was dealer assembled. Do not try to light

this barbecue without reading the Lighting

Instructions section of this manual.

THIS MANUAL MUST REMAIN WITH THE PRODUCT AT ALL TIMES

CAUTION

Read and follow all safety statements,

assembly instructions, use and care

directions before attempting to assemble

and cook.

WARNING

1. Do not store or use gasoline or other

ammable liquids or vapours in the

vicinity of this or any other appliance.

2. An LP cylinder not connected for use shall

not be stored in the vicinity of this or any

other appliance.

WARNING

IN DIRECT SUN, AND IN OPERATION,

YOUR BBQ’S STAINLESS STEEL AND

PAINTED STEEL PARTS CAN BECOME

VERY HOT.

CAUTION

Sharp edges. Wear gloves when assembling

your grill.

THIS BARBECUE IS FOR OUTDOOR USE ONLY.

CONTACT CALL CENTRE IF ANY PARTS ARE MISSING.

1-855-453-2150

INSTALLER OR ASSEMBLER/CONSUMER

This manual should be kept with the BBQ at

all times.

HEAVY ARTICLE NEEDS 2 TO LIFT

To ORDER non-warranty replacement parts or accessories, or to register your warranty,

please visit us on the web at

www.masterchefbbqs.com

HARDWARE PACK

1/4”-20UNC X13 Screw

X 20

ST4.2X8 Tapping Screw

X 14

Wheel Spacer

X 2

Control Knob

X 1

NO.10-24UNC Nut

X 3

NO.8-32UNC X10 Screw

X 2

1/4’’-20UNC Nut

X 8

Aluminum Washer

X 8

Hitch Pin

X 1

NO.10-24UNC X18 Screw

X 3

M4 Wing Nut

X 1

Wheel Washer

X 1

Bezel, Control Knob

X 1

Venturi Clip, Side Burner

X 1

1 2 3

4 5 6

KEY # DESCRIPTION PART NUMBER QUANTITY

1 1/4”-20UNC X13 Screw 20120-13013-036 20

2 1/4”-20UNC Nut 31220-13000-036 8

3 ST4.2X8 Tapping Screw 24200-42008-136 14

4 Aluminum Washer G466-0042-9000 8

5 Wheel Spacer G650-0012-9091 2

6 Wheel Washer G650-0013-9091 1

7 Hitch Pin G306-0005-9088 1

8 Control Knob G312-B102-01 1

9 Bezel, Control Knob G430-0027-02 1

10 NO.10-24UNC X18 Screw 20124-10018-036 3

11 NO.10-24UNC Nut 31224-10000-036 3

12 Venturi Clip, Side Burner G405-0019-9200 1

13 M4 Wing Nut 33301-04000-032 1

14 NO.8-32UNC X10 Screw 20132-08010-250 2

TOOLS NEEDED FOR ASSEMBLY

• #2 Star-head screwdriver (long and short)

• ¼” Slotted screwdriver (long and short)

• Adjustable wrench

• Pliers

For correct hardware assembly, always position

the lock washer between the screw and the at

washer.

Caution:

Sheet metal can cause injury. Wear gloves when installing the grill.

Lock Washer

Flat Washer

Screw

BEFORE ASSEMBLING THIS BARBECUE, READ THE INSTRUCTIONS CAREFULLY.

Assemble the barbecue on a flat, clean surface. Grill is heavy. Two people are recommended

to complete assembly.

PARTS LIST PROPANE FOR 8531296 G55105

KEY # QUANTITY DESCRIPTION PART NO.

AA 1 Top Lid Assembly G551-6700-01

AB 1 Thermometer and Bezel G312-B201-01

AC 2 Lid Handle Brackets G352-0015-01

AD 1 Top Lid Handle G551-0001-01

AE 2 Lid Bumpers, Back G303-0038-01

AF 2 Lid Bumpers, Front G430-00B8-01

AG 2 Screws for Lid G430-0024-02

BA 1 Burner Box Assembly G551-0300-01

BB 5 Burner G432-B600-01

BC 1 Electrode Set, Main Burner G501-0010-01

BD 4 Burner Brace Assembly G551-0006-01

BE 5 Flame Tamer G432-0096-01

BF 3 Cooking Grate G551-0400-01

BG 1 Warming Rack G551-0005-01

CA 1 Control Panel G551-0013-01

CB 1 Manifold Assembly G551-5200-01

CC 1 Metal Hose, Side Burner G430-2403-01

CD 1 Side Burner Valve, LP G551-5201-01

CE 1 Regulator G311-0503-01

CF/#9 6 Bezel, Control Knob G430-0027-02

CG/#8 6 Control Knob G312-B102-01

CH1 1 Electronic Ignition Assembly G409-0021-A1

CH2 1 Electronic Ignition Button G409-0030-01

CI 1 Grease Cup Hook G305-0043-01

CJ 1 Grease Cup G430-0033-02

CK 1 Heat Shield G551-0003-01

DA 1 Cart Side Panel, Right G551-0900-01

DB 1 Cart Side Panel, Left G551-0800-01

DC 2 Back Brace G551-1000-01

DD 1 Upper Front Panel G551-0008-01

DE 1 Lower Front Panel G551-0009-01

DF 2 End Caps G430-0023-01

DG 2 Wheel G401-0058-01

DH 1 Wheel Axle G651-0027-01

DI 1 Match Holder G401-0079-01

DJ 3 Tank Exclusion G551-0011-01

DK 1 Gas Tank Support G551-0010-01

EA 1 Side Shelf Table, Right G451-0B00-01

EB 1 Side Shelf Fascia, Right G551-6901-01

EC 1 Side Shelf Table, Left G551-0600-01

ED 1 Side Shelf Fascia, Left G551-6801-01

EE 1 Side Burner Drip Pan G651-0038-01

EF 1 Side Burner G551-5500-01

EG 1 Electrode Set, Side Burner G430-0042-02

EH 1 Side Burner Grate G430-0053-01

EI 1 Side Burner Lid G430-0018-A1

F1 1 Hardware Pack G551-B005-01

F2 1 Assembly Instructions G551-M005-01

F3 1 Safe Use and Care Manual G551-M005-02

EXPLODED DIAGRAM PROPANE FOR 8531296 G55105

BG AB

CH2

CH1

HARDWARE

PACK

F2 F3

ASSEMBLY

MANUAL

SAFETY

AND CARE

MANUAL

Note: Two people required for all assembly steps.

Assemble the Upper Front Panel (DD) and Lower

Front Panel (DE) to the the Left and Right Cart Side

Panels (DB and DA) as shown.

ASSEMBLY INSTRUCTIONS

YOU WILL NEED:

X 8

Back View

Assemble the two Back Braces (DC) to the

Left and Right Cart Side Panels (DB and DA) as

shown.

DA DB

Close Up

Note: Turn Cart assembly upside down.

a. Place Wheel (DG) and Wheel Spacer (#5) onto

the Wheel Axle (DH). “Cone”side of wheel

should be against cart side panel. Figure B.

b. Insert Wheel Axle Assembly (DH) through

wheel axle hole in the front and rear of the Left

Cart Side Panel (DB), as shown.

c. To complete wheel assembly position the

Wheel Spacer (#5), Wheel (DG), Wheel Washer

(#6) and Hitch Pin (#7), onto Wheel Axle (DH)

as shown.

d. Insert End Caps (DF) into Right Cart Side Panel

(DA).

ASSEMBLY INSTRUCTIONS

876

YOU WILL NEED:

X 2

X 1

Assemble the three Tank Exclusion Wires (DJ) to

the Lower Back Brace (DC) and the Front Panel

(DD and DE) as shown.

Back View

Close up - front view

Close up - back view

YOU WILL NEED:

10 11

X 3 X 3

Close upClose up

Note: TWO PEOPLE required for this step.

Ensure that the regulator hose (CE) (Propane

models only) is hanging outside of cart.

a. Position the Lid and Burner Box Assembly

(A & B), onto the cart assembly (C).

b. Assemble the Burner Box Assembly (BA) to the

cart assembly (C) as shown in gure B.

YOU WILL NEED:

ASSEMBLY INSTRUCTIONS

X 4

A B

PROPANE MODEL ONLY.

Assemble the Gas Tank Support (DK) to Left Cart

Side Panel (DB).

Back View

Close up

ASSEMBLY INSTRUCTIONS

7RIGHT SIDE SHELF ASSEMBLY

a. Insert the Right Side Shelf Assembly (EA and

EB) into the support brackets located on the

right side of the Burner Box Assembly (BA).

b. Ax the Right Side Shelf Table (EA) to the

Burner Box Assembly (BA) as shown in

gures B and C.

c. Ax the Right Side Shelf Fascia (EB) to the

Control Panel (CA).

Securely tighten all hardware.

YOU WILL NEED:

X 3

Front, right side view

Back View

View, under right side shelf

X 4 X 4

X 4

ASSEMBLY INSTRUCTIONS

8LEFT SIDE SHELF ASSEMBLY

a. Insert the Left Side Shelf Assembly (EC and ED)

into the support brackets located on the right

side of the Burner Box Assembly (BA).

b. Ax the Left Side Shelf Table (EC) to the Burner

Box Assembly (BA) as shown in gures B and C.

c. Ax the Left Side Shelf Fascia (ED) to the

Control Panel (CA).

Securely tighten all hardware.

YOU WILL NEED:

X 3

YOU WILL NEED:

X 4

View, under left side shelf

Back view

Front, left side view

View, under left side shelf

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Parrilla de MasterChef

MasterChef

MasterChef G36401 Manual de usuario

MasterChef

MasterChef 85-1208-0 Guía rápida

MasterChef

MasterChef S550 Manual de usuario

MasterChef

MasterChef 085-3602-8 Manual de usuario

MasterChef

MasterChef C0NB903A Manual de usuario

MasterChef

MasterChef T480 Manual de usuario

MasterChef

MasterChef S480 Manual de usuario

MasterChef

MasterChef E480 Manual de usuario

MasterChef

MasterChef ELITE G45325 Manual de usuario

MasterChef

MasterChef G42602 Manual de usuario

MasterChef

MasterChef T405 Guía rápida

MasterChef

MasterChef S480 Manual de usuario

MasterChef

MasterChef 76 cm (30?) Guía rápida

MasterChef

MasterChef 85-1261-0 Guía rápida

MasterChef

MasterChef Outdoor Stovetop Guía rápida

MasterChef

MasterChef 085-3134-2 Manual de usuario

MasterChef

MasterChef S280 Manual de usuario

MasterChef

MasterChef 085-3175 Manual de usuario

MasterChef

MasterChef GRILL TURISMO 085-0109-2 Manual

MasterChef

MasterChef RSH013929 Manual de usuario

MasterChef

MasterChef S420 Manual de usuario

MasterChef

MasterChef PRIME 85-3135-0 Manual de usuario

MasterChef

MasterChef 085-2202-6 Manual de usuario

MasterChef

MasterChef E480 Manual de usuario

Manuales populares de Parrilla de otras marcas

Orbegozo

Orbegozo GR 2300 Manual de usuario

bora

bora PT11 Manual de usuario

Klarstein

Klarstein 10031664 Manual de usuario

Garland

Garland MWE3W Manual de usuario

Char-Broil

Char-Broil 463722714 Manual de usuario

Nexgrill

Nexgrill 720-0830HK Manual de usuario

Kenmore

Kenmore 415.16123800 Manual de usuario

Camp Chef

Camp Chef PG24CLAU Manual de usuario

Tucker Barbecues

Tucker Barbecues GTR Series Instrucciones de montaje

Monogram

Monogram ZGG540NCP1SS Manual de usuario

Equipex

Equipex Sodir Savoy Manual de usuario

Gaggenau

Gaggenau VR 414 610 Manual de usuario

Miele

Miele KM 408-1 Manual de usuario

George Foreman

George Foreman GGR50B Manual de usuario

AOG

AOG T series Manual de usuario

Gorenje

Gorenje TG2000CB Manual de instrucciones

Weber

Weber Genesis Silver-B Permamount NG 051701 Manual de usuario

Glen

Glen SA 3037 Manual de usuario