Kozy heat KZK-036 Manual de usuario

KZK-036 1Rev. 1 - July 2023

Komfort Zone Kit #KZK-036

For use with Nordik 36 DV (#NDK-36-DV)

English and French installation manuals are available

through your local dealer. Visit our website

www.kozyheat.com.

Les manuels d’installation en français et en anglais sont

disponibles chez votre détaillant local. Visitez

www.kozyheat.com.

READ ALL THESE STEPS BEFORE STARTING INSTALLATION. LEAVE THESE INSTRUCTIONS WITH THE APPLIANCE.

This kit must be installed by a qualied installer, service agency, or gas supplier at the me of the heater installaon.

These instrucons must be used in conjuncon with the installaon and operaon manual provided with the appliance.

Please read all appliance owner’s manual completely before performing any procedures in these instrucons.

INSTALLER: Leave this manual with the appliance.

CONSUMER: Retain this manual for future reference.

IMPORTANT: Failure to read and follow these instrucons

may create a possible hazard and will void the replace

warranty.

1.0 Introducon............................................................. 3

1.1 Kit Contents ............................................................. 3

1.2 Suggest Conguraons............................................ 4

1.3 Dimensions and Overview....................................... 5

1.4 Air Duct Run............................................................. 6

2.0 Framing and Clearances........................................... 7

2.1 Clearance to Sprinkler ............................................. 7

2.2 Framing.................................................................... 8

3.0 Facing and Finishing............................................... 11

3.1 Non-combusble Requirements ........................... 13

3.2 Finish Requirements.............................................. 14

3.3 Hearth and Mantel Clearances.............................. 16

4.0 Fireplace Preparaon & Installaon....................... 17

4.1 Nordik 36 DV.......................................................... 17

This oponal convecon duct kit redistributes the warm air ow away from the replace opening to a more desirable

locaon using natural convecon without the use of a fan. The warm air ow would be relocated to a posion higher up the

wall. The result is much cooler wall temperatures above the replace opening for locang televisions, artwork, etc.

P.O. BOX 557 204 INDUSTRIAL PARK DRIVE

LAKEFIELD, MINNESOTA USA 56150-0577

KZK-036 2Rev. 1 - July 2023

KZK-036 3Rev. 1 - July 2023

1.1 Kit Contents

ALL kit contents must be installed.

• (1) 36" plenum kit: KZK-036

• (1) plenum discharge trim: KZK-036DT

• (2) plenum support brackets

• (8) 6" collars - (4) to aach to the boom of the ple-

num; (4) to aach to the unit where the cover plates

are removed.

Addional Required Items

• (1) KZK-410-6 (sold separately) is used for a 10' vent

run. If you are mounng the plenum above the re-

place 10' (3m) or less, use (1) KZK-410-6 kit.

Oponal Items

• KZK-CPL6 (sold separately) is (6) 6" couplers that

connect (2) KZK-410-6. You will only need (4) 6" cou-

plers for installaon. If you are mounng the ple-

num above the replace between 10' to 20', you will

need (2) KZK-410-6 kit and (1) #KZK-CPL6 coupler kit.

1.0 Introducon

Figure 1.1 - #KZK-036

Figure 1.2 - #KZK-410-6

KZK-036 4Rev. 1 - July 2023

1.2 Suggested Conguraons

• When installing the #KZK-036, take in consideraon the replace venng and the plenum tube conguraon.

• The #KZK-036 plenum must be installed so it discharges heat into the room the Nordik 36 DV is installed in.

Figure 1.3 - Nordik 36 DV Suggested Plenum Conguraons

Nordik 36 DV

KZK-036 5Rev. 1 - July 2023

1.3 Dimensions and Overview

Figure 1.4 - KZK-036 Dimensions

KZK-036 6Rev. 1 - July 2023

1.4 Air Duct Run

IMPORTANT: The air duct pipe cannot run horizontally without a vercal rise.

IMPORTANT: The 1/2" clearance around the air duct pipes must be maintained.

Use #KZK-410-6 UL181 Class 0 Air Duct piping to connect the plenum(s) to the unit.

Hussong Mfg. Co., Inc. requires pipes to be listed as UL181 Class 0 Air Duct to connect the plenum(s) to the unit.

Maximum Vent Run: 20’ (6m)

Figure 1.5 - Nordik 36 DV Horizontal Run

Nordik 36 DV

KZK-036 7Rev. 1 - July 2023

2.0 Framing and Clearances

2.1 Clearance to Sprinkler

• In a situaon where a sprinkler head is installed within the proximity to a #KZK discharge opening, the diagram below

MUST be followed.

• The distance between a sprinkler head and discharge opening cannot be less than 60" (1524mm) in length at every point

from the origin of the discharge opening. You must also verify the sprinkler head sensor is set to the proper heat seng so

it does not acvate when the room heats up from the replace being operated normally.

• Please follow local building codes to determine what temperature seng is relevant for your installaon.

Figure 2.1 - Clearance to Sprinkler

KZK-036 8Rev. 1 - July 2023

2.2 Framing

Shown in this secon are the rough opening dimensions and

clearances for the plenum, unit installaon, and unit installa-

on with a TV recess construcon.

Rough opening framing dimensions should allow for wall cov-

ering thickness and facing materials. Please refer to Secon 3.0

for specic facing and nishing opons.

Figure 2.3 show the minimum height of plenum framing from

the base of that specic replace.

Figure 2.2 - Plenum Framing

Nordik 36 DV

Figure 2.3 - Nordik 36 DV Plenum Framing

KZK-036 9Rev. 1 - July 2023

Figure 2.4 shows the minimum clearance between the top

of the plenum opening and the ceiling. This applies to all

models.

Figure 2.5 shows the minimum height of plenum framing

from the top nishing edge of the replace. This applies to

the Nordik 36 DV

Nordik 36 DV

Figure 2.5 - Nordik 36 DV Plenum Framing

Figure 2.4 - Minimum Clearance to Ceiling

KZK-036 10 Rev. 1 - July 2023

Figure 2.6 - Nordik 36 DV Wall Enclosure Rough Opening

Nordik 36 DV

Tabla de contenidos

Otros manuales de Accesorios para chimeneas de kozy heat

kozy heat

kozy heat LCK-NK41-S Manual de usuario

kozy heat

kozy heat KZK-052 Manual de usuario

kozy heat

kozy heat KOMFORT 8K Instrucciones de montaje

kozy heat

kozy heat NCK-OP18L-S30 Manual de usuario

kozy heat

kozy heat KZK-038 Manual de usuario

kozy heat

kozy heat NCK-SF36-D Manual de usuario

kozy heat

kozy heat NCK-C39-D Manual de usuario

kozy heat

kozy heat KZK-1510A Manual de usuario

kozy heat

kozy heat KZK-054 Manual de usuario

kozy heat

kozy heat NCK-NK29-S Manual de usuario

kozy heat

kozy heat KPV Manual de usuario

kozy heat

kozy heat NCK-SL42-SPB Manual de usuario

kozy heat

kozy heat CHASKA 34 GLA Manual de usuario

kozy heat

kozy heat NCK-LX22L-S30 Manual de usuario

kozy heat

kozy heat CW50-501 Manual de usuario

kozy heat

kozy heat NCK-SP34L-D Manual de usuario

kozy heat

kozy heat KZK-1510A Manual de usuario

kozy heat

kozy heat NCK-SP41L-D Manual de usuario

kozy heat

kozy heat OCK-S50A Manual de usuario

kozy heat

kozy heat KOMFORT ZONE KIT Manual de usuario

kozy heat

kozy heat OCK-S35A Manual de usuario

kozy heat

kozy heat LCK-C46-D Manual de usuario

kozy heat

kozy heat BAY-41-MV Manual de usuario

kozy heat

kozy heat NCK-SL42-D Manual de usuario

Manuales populares de Accesorios para chimeneas de otras marcas

Valor

Valor L2 1700K Manual de usuario

Exodraft

Exodraft Xzense Manual de usuario

Whalen

Whalen Ruso MNFP62BF23-6 Manual de usuario

Lopi

Lopi Hearthview 864 Manual de usuario

Woodstock Soapstone

Woodstock Soapstone Fireview 201 Manual de usuario

EdilKamin

EdilKamin SERBATOIO 250 Guía de inicio rápido

Bronpi

Bronpi KIT-1 Manual de usuario

Town & Country Fireplaces

Town & Country Fireplaces 22150051 Manual de usuario

Travis Industries

Travis Industries 33 DVI Manual de usuario

Superior

Superior ASD3628-TI Manual de usuario

pleasant hearth

pleasant hearth OFP28WG Manual de usuario

IHP

IHP Astria Series Manual de usuario

Firegear

Firegear FG-H-2110SS Manual de usuario

Nibe

Nibe Contura C i31 Manual de usuario

SimpliFire

SimpliFire SF-WM36 Manual de usuario

Bluegrass Living

Bluegrass Living BC18NR Guía de inicio rápido

pleasant hearth

pleasant hearth IRIS SCROLL Manual de usuario

Cooke

Cooke Glass Wind Guard Manual de usuario

kozy heat KZK-036 Manual de usuario

Manuales populares de Accesorios para chimeneas de otras marcas