Invacare Quick Release Caster Manual de usuario

OVER

SAFETY SUMMARY

The following recommendations are made for the safe

use of the Quick-Release Caster:

WARNING

Checkthequick-releasecasterforshippingdam-

agebeforeusing.Incaseofdamage,DONOTuse.

Contact the dealer/carrier for further instructions.

Makecertainallscrewsandnutsaretightatalltimes.

Pullonquickreleasecasters eachtimeBEFOREus-

ing the wheelchair to make sure they are securely

locked onto the chair frame.

Makesurethedetentpinofthequickreleasecaster

head tube cap is fully released BEFORE operating

the wheelchair.

Thereareseveralconfigurationsofthequickrelease

caster. If caster fork stem DOES NOT look like the

drawing in FIGURE 2 when installed, DO NOT USE.

Contact Customer Service, 1-(800)-333-6900.

TOOLS REQUIRED:

Two (2) Open Head Wrenches

One (1) Socket Head Wrench

A NOTE ABOUT QUICK-RELEASE

CASTERS

Quick-release casters are an option that allow for quick

and easy removal of the casters from the wheelchair so

the wheelchair can be stored and transported conve-

niently. When using the quick-release caster option, a

spring loaded caster head tube cap will be used instead

of a stem nut to secure the front caster to the chair frame.

Unlike the stem nut, the caster head tube cap is not ad-

justable and thus caster flutter will be more evident with

the quick-release caster option than it would be with the

standard caster attaching hardware.

REMOVING THE EXISTING

CASTER FORK (FIGURE 1)

1. Remove the bolt and locknut that secure the front

caster and the two (2) spacers to the fork.

2. Remove the dust cover on the top of the head

tube.

3. While holding the fork and using a socket head

wrench, remove the locknut that secures the

fork, and washer in the head tube of the chair.

NOTE: The dust cover and locknut are not used with

the quick release casters. Keep them for future use.

4. Remove the existing fork from the head tube of

the chair.

Caster Head

Tube

Locknut

Plastic Washer

Black Dust

Cover

Caster Fork

Bolt

NOTE: Frame Shown

For Reference Only

INSTALLING THE QUICK

RELEASE CASTER (FIGURE 2)

WARNING

Pull on quick release casters each time BEFORE

using the wheelchair to make sure they are se-

curely locked onto the chair frame.

Make sure the detent pin of the quick release

caster head tube cap is fully released BEFORE

operating the wheelchair.

Thereareseveralconfigurationsofthequickrelease

caster. If caster fork stem DOES NOT look like the

drawing in FIGURE 2 when installed, DO NOT USE.

Contact Customer Service, 1-(800)-333-6900.

1. Install the quick release caster fork through the head

tube of the chair making sure the caster fork stem is

apporoximately 1/4-inch above the caster head tube.

FIGURE 1 - REMOFIGURE 1 - REMO

FIGURE 1 - REMOVINGVING

VINGVING

VING THE EXISTINGTHE EXISTING

THE EXISTINGTHE EXISTING

THE EXISTING

CASTER FORKASTER FORK

ASTER FORKASTER FORK

ASTER FORK

QUICK RELEASE CASTER

Assembly, Installation, and Operating Instructions

2. Depress the detent pin of the quick release caster

head tube cap and install over the top of the quick

release caster fork stem.

3. Release the detent pin of the quick release caster

head tube cap and pull on the caster fork to make

sure the fork is securely attached to the chair.

4. Reinstall and securely tighten the bolt and locknut

that secure the two (2) spacers and caster onto the

quick release caster fork.

5. Repeat this procedure for the opposite side.

WARNING

There are several configurations of the quick

release caster. If caster fork stem DOES NOT

look like the drawing in FIGURE 2 when in-

stalled, DO NOT USE. Contact Customer Ser-

vice, 1-(800)-333-6900.

NOTE: When removing the quick release casters for

any reason, reinstall the quick release caster head

tube cap onto the fork stem so it can be located eas-

ily for future use.

Caster Fork

Stem

Approximately

1/4-inch

Caster

Head

Tube

Caster Head

Tube Cap

Detent Pin

Caster Head

Tube

Bolt

NOTE: Frame Shown

For Reference Only

FIGURE 2 - INSTFIGURE 2 - INST

FIGURE 2 - INST ALLINGALLING

ALLINGALLING

ALLING THE QUICK-RELEASETHE QUICK-RELEASE

THE QUICK-RELEASETHE QUICK-RELEASE

THE QUICK-RELEASE

CASTERASTER

ASTERASTER

ASTER

Invacare Corporation www.invacare.com

One Invacare Way

Elyria, Ohio USA

4403 -2125

800-333- 900

Technical Support

800-832-4707

Invacare is a registered trademark of Invacare Corporation

Form No. 94-150 P/N 1050205 Rev. A (1) - 11/99

Tabla de contenidos

Otros manuales de Ayuda a la movilidad de Invacare

Invacare

Invacare Dolomite Maxi+ Manual de usuario

Invacare

Invacare 6291E Adult Instrucciones de montaje

Invacare

Invacare 1073913 Instrucciones de montaje

Invacare

Invacare DOLOMITE Legacy Manual de usuario

Invacare

Invacare Top End Transformer Manual de usuario

Invacare

Invacare Esprit Action Manual de usuario

Invacare

Invacare C407A Manual de usuario

Invacare

Invacare 3G Storm Series Manual de instrucciones

Invacare

Invacare OCMK01 Instrucciones de montaje

Invacare

Invacare User guide Manual de usuario

Invacare

Invacare Izzo Manual de usuario

Invacare

Invacare ROZE Manual de usuario

Invacare

Invacare Aquatec 900 Manual de usuario

Invacare

Invacare Silencio P256 Manual de usuario

Invacare

Invacare Dolomite Gloss Manual de usuario

Invacare

Invacare Personal Seat and Cushion Rigidizer Manual de usuario

Invacare

Invacare Thumb Saver 1109379 Manual de usuario

Invacare

Invacare Silhouette 3002801 Manual de usuario

Invacare

Invacare Ulti-Mate Air Back Manual de usuario

Invacare

Invacare 7714P Manual de usuario

Invacare

Invacare P550/2 Actio 2 Manual de usuario

Invacare

Invacare Balnea Manual de usuario

Invacare

Invacare Lima H263 Manual de usuario

Invacare

Invacare Silencio P256 Manual de usuario

Manuales populares de Ayuda a la movilidad de otras marcas

Alber

Alber Scalamobil iQ Manual de usuario

Ferno

Ferno CCT-PX Manual de usuario

HEPRO

HEPRO Gripo Manual de usuario

Otto Bock

Otto Bock Pheon 3R62 Manual de usuario

NRS Healthcare

NRS Healthcare M11090 Manual de usuario

Medline

Medline MDS86835DSHEC Guía de instalación

Guldmann

Guldmann Twin Turner II Manual de usuario

Drive

Drive ROOMBA Manual de usuario

Gate

Gate Balder Manual de usuario

Decon wheel

Decon wheel TNS Notos Manual de usuario

ExoAtlet

ExoAtlet ExoAtlet-II Manual de usuario

Rhythm Healthcare

Rhythm Healthcare B3800F Manual de usuario

AMF-BRUNS

AMF-BRUNS PROTEKTOR Manual de usuario

Drive DeVilbiss Healthcare

Drive DeVilbiss Healthcare OTTER Manual de usuario

Rhythm Healthcare

Rhythm Healthcare C500U Manual de usuario

Lumex

Lumex RJ4200A Manual de usuario

Rebotec

Rebotec Jumbo Manual de usuario

Rehaforum MEDICAL

Rehaforum MEDICAL PR50548 Manual de usuario