IHP 900935-00 Manual de usuario

GAS LOG SETS

P/N 900935-00

Rev. NC, 10/2018

HEARTH PRODUCTS

KITS AND ACCESSORIES

KIT CONTENTS

1 ea. Log Set

1 ea. Instruction Sheet

GAS LOG PLACEMENT GUIDE FOR INSTALLING GAS LOG SETS

[For Use With Aries35, DRT2035, Bellevue 32, and DRI2032 Series Direct-Vent Gas Fireplaces/Inserts]

GENERAL INFORMATION

This log placement guide has been preparedto present detailed log placement

illustrations and provide instruction to assist in the setup of replacement

logs and after the annual cleaning and inspection cycles. The information

provided here is to be used in conjunction with the Installation and Operation

Instructions provided with the appliance.

If you encounter any problems, need clariﬁcation of these instructions or are

not qualiﬁed to properly install this kit, contact your local distributor or dealer.

Read this instruction sheet in its entirety before beginning the installation.

DO NOT attempt to install the logs until the appliance installation has been

completed, the gas line connected and tested for leaks and the initial burner

operation has been checked out.

The logs have notches/tabs/pins to assist proper positioning. Proper log

placement is critical to prevent sooting. Place the logs in the gaps between

ﬂame peaks, so they do not impinge the ﬂames. Follow the log placement

instructions precisely.

ALL WARNINGS AND PRECAUTIONS IN THE INSTALLATION AND OPERA-

TION MANUAL PROVIDED WITH THE APPLIANCE APPLY TO THESE

INSTRUCTIONS.

SHUT DOWN THE APPLIANCE AND ALLOW IT TO COMPLETELY COOL

BEFORE PROCEEDING.

Log Set

I.D.# Description

1Left Rear Log

2Left Front Bottom Log

3Right Front Bottom Log

4Right Rear Log

5Twig Log

TOOLS NEEDED

None

INSTALLATION INSTRUCTIONS

Pre-installation Instructions:

1. Allow the ﬁreplace to cool completely before proceeding.

2. Remove the barrier and door (see instructions in the Installation and

Operation Manual provided with the appliance).

3. Remove the old logs that need replacing. Discard old logs.

Install new logs per the following instructions:

1. Locate the placement tabs (Figure 2).

2. Bend up the log placement tabs (Figure 2).

3. Install the rear left log (1) (Figure 3).

Figure 2 - Locate the log placement tabs

Figure 1 - Log Set

Tabs for

Log #1

Tabs for

Log #2

Tabs for

Log #4

Tabs for

Log #3

Figure 3 - Place left rear log (1)

Front View Bottom View

Slots ﬁt over Tabs shown in Figure 2

fire-parts.com

2NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE.

4. Install left front bottom log (2) on two tabs (Figure 4).

5. Install right front bottom log (3) on two tabs (Figure 5).

Figure 4 - Place left front bottom log (2)

Top

View

Bottom

View

Slots ﬁt over Tabs

shown in Figure 2

Figure 5 - Place right front bottom log (3)

Top

View Bottom

View

Slots ﬁt over Tabs

shown in Figure 2

6. Install right rear log (4) (Figure 6). This log should be placed as far

to the right as the slot allows.

7. Install the twig log (5) (Figure 7). This log rests on the left rear log

and the grate.

Figure 6 - Place right rear log (4)

Slot ﬁt over Tab

shown in Figure 2

Top View Bottom View

Figure 7 - Place twig log (5)

Bottom View

Top View

For Fireplace Models

For Insert models

For Fireplace ModelsFor Insert models

fire-parts.com

NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE.

8. Tear the glowing embers into dime size pieces. Place glowing embers as shown in Figure 8.

9. Reinstall glass door and barrier per instructions in the Installation and Operation Manual provided with the appliance.

Figure 8 - Place glowing embers (rockwool)

Do NOT place embers on or close to large

ports or the pilot area as seen here (circled).

Figure 9 - Glass Door

Latch

Glass

Door

NOTE: When installing the glass door, ensure the spacing on both sides is even and equal.

INSPECT GASKET AND ADJUST IF NECESSARY (see pictures above)

(1) Ensure the gasket is properly positioned, and area to keep clear, is as shown.

(2) Inspect gasket after installation to ensure it appears as shown above.

Inside view

of glass door

showing

proper gasket

positioning With door installed,

ensure gasket is posi-

tioned as shown.

Gasket

SEE WARNING BELOW

WARNING

Reinstall any barrier removed before operating the ﬁreplace. The barrier is designed to reduce the risk of

burns from hot glass. Do not operate the ﬁreplace without the barrier installed.

NOTE: All models must have a barrier installed prior to operation.

Glass Door

Area to

keep clear

Gasket

fire-parts.com

P/N 900935-00 Rev. NC 10/2018

Innovative Hearth Products (IHP) reserves the right to make changes at any time, without

notice, in design, materials, speciﬁcations, prices and also to discontinue colors, styles and

products. Consult your local distributor for ﬁreplace code information.

1769 East Lawrence Street • Russellville, AL 35654

fire-parts.com

Otros manuales de Accesorios para chimeneas de IHP

IHP

IHP SV4.5-TWSK Manual de usuario

IHP

IHP SG-01 Manual de usuario

IHP

IHP BWBK Manual de usuario

IHP

IHP SECURE FLEX SF-12 Manual de usuario

IHP

IHP CHAROAK35 Manual de usuario

IHP

IHP PCBE-42 Manual de usuario

IHP

IHP H0776 Manual de usuario

IHP

IHP Snap-Pak Manual de usuario

IHP

IHP HeatFlo Kit Manual de usuario

IHP

IHP RIVROCK-25PK Manual de usuario

IHP

IHP PCBE-324 Manual de usuario

IHP

IHP SV4.5HTKCT Manual de usuario

IHP

IHP GCKSMS557051NP Manual de usuario

IHP

IHP H5861 Manual de usuario

IHP

IHP EPIC-TRIM-B Manual de usuario

IHP

IHP FP6820-4S-DVFP Manual de usuario

IHP

IHP SF-HTSS Series Manual de usuario

IHP

IHP RDV-BRK-STD Manual de usuario

IHP

IHP BLB36SF Series Manual de usuario

IHP

IHP 36LBFOD-BS Manual de usuario

IHP

IHP DEL SOL Manual de usuario

IHP

IHP HeatFlo Kit HTFLO-LIN60 Manual de usuario

IHP

IHP WINSLOW PS40 Manual de usuario

IHP

IHP F2460 Manual de usuario

Manuales populares de Accesorios para chimeneas de otras marcas

Valor

Valor L2 1700K Manual de usuario

Exodraft

Exodraft Xzense Manual de usuario

Whalen

Whalen Ruso MNFP62BF23-6 Manual de usuario

Lopi

Lopi Hearthview 864 Manual de usuario

Woodstock Soapstone

Woodstock Soapstone Fireview 201 Manual de usuario

EdilKamin

EdilKamin SERBATOIO 250 Guía de inicio rápido

Bronpi

Bronpi KIT-1 Manual de usuario

Town & Country Fireplaces

Town & Country Fireplaces 22150051 Manual de usuario

Travis Industries

Travis Industries 33 DVI Manual de usuario

Superior

Superior ASD3628-TI Manual de usuario

pleasant hearth

pleasant hearth OFP28WG Manual de usuario

Firegear

Firegear FG-H-2110SS Manual de usuario

Nibe

Nibe Contura C i31 Manual de usuario

kozy heat

kozy heat KZK-052 Manual de usuario

SimpliFire

SimpliFire SF-WM36 Manual de usuario

Bluegrass Living

Bluegrass Living BC18NR Guía de inicio rápido

pleasant hearth

pleasant hearth IRIS SCROLL Manual de usuario

Cooke

Cooke Glass Wind Guard Manual de usuario