Honeywell 04230-A-1001 Nota de versión

Searchline Excel

Infrared Gas Detectors

Technical Handbook

MAN0530 Issue 15 - 07/17 Searchline Excel

2104M0506

Ensure that you read and understand these instructions BEFORE operating the equipment.

Please pay particular attention to the Safety Warnings.

WARNINGS

1. TheSearchlineExcelgasdetectoriscertiedforandintendedforuseinpotentially

hazardous areas. Install and use the Searchline Excel gas detector in accordance

with the latest regulations.

2. For installations in the UK, the Code of Practice SELECTION, INSTALLATION

AND MAINTENANCE OF ELECTRICAL APPARATUS FOR USE IN

POTENTIALLY EXPLOSIVE ATMOSPHERES should be strictly observed. General

recommendations are given in BS EN 60079-14 & IEC 60079-14. Refer to BS

EN 60079-29-2 & IEC 60079-29-2 in the UK or the appropriate local or national

regulations.

3. For installations in North America, the national Electrical Code (NFPA 70) or later

issues should be strictly observed.

4. Elsewhere, the appropriate local or national regulations should be used.

5. The Searchline Excel gas detector must be properly earthed to protect against

electrical shock and minimise electrical interference. For electrical installation design

considerations refer to Section 3.

6. Operators must be fully aware of the action to be taken if the gas concentration

exceeds an alarm level.

7. Dismantling or repair of equipment should be carried out in the safe area only.

8. Test gases may be toxic and/or combustible. Refer to Material Safety Sheets for

appropriate warnings.

9. Do not drill holes in any housing as this will invalidate the explosion protection.

10. In order to maintain electrical safety, the unit must not be operated in atmospheres

with more than 21% oxygen.

11. Ensurethattheboltswhichsecureameproofenclosuresarefullytightened.The

securingboltsusedaremadefromaspecialcertiedgradeofsteel.Onlybolts

suppliedbyHoneywellAnalyticsshouldbettedforthispurpose.

12. Do not open the enclosure in the presence of an explosive atmosphere.

13. The transmitter unit contains high voltages when operational. These are discharged

when the unit is removed from its enclosure.

14. TheconduitandcableglandsttedtoSearchlineExcelshouldnotbemodied.If,

however,itbecomesnecessarytomakemodicationstheymustcomplywiththe

relevant national Codes of Practice.

15. The irradiance and power emitted by the Searchline Excel transmitters is less than

5 mW/mm2and 15 mW/mm2respectively.

SAFETY

MAN0530 Issue 15 - 07/17 Searchline Excel

2104M0506

CAUTIONS

1. Use only approved parts and accessories with the Searchline Excel gas detector.

2. To maintain safety standards, commissioning and regular maintenance of the Searchline

Excelgasdetectorshouldonlybeperformedbyqualiedpersonnel.

IMPORTANT NOTICES

1. Honeywell Analytics Limited can take no responsibility for installation and/or use of its

equipment if this is not done in accordance with the appropriate issue and/or amendment

of the manual.

2. The user of this manual should ensure that it is appropriate in all details to the exact

equipment to be installed and/or operated. If in doubt, the user should contact Honeywell

Analytics Limited for advice.

3. Effect of explosive atmosphere on materials.

Searchline Excel is made from materials which exhibit good resistance to corrosive and

solvative substances. The Exd enclosures are made from 316 stainless steel and the

explosion protected windows are made from toughened soda lime glass. Honeywell

Analyticsarenotawareofanysignicanteffectsofexplosiveatmospheresuponthese

materials.ContactHoneywellAnalyticsoroneoftheiragentsforspecicqueries.

Honeywell Analytics Limited reserve the right to change or revise the information supplied in

this document without notice and without obligation to notify any person or organisation of such

revision or change.

If further details are required that do not appear in this manual, contact Honeywell Analytics

Limited or one of their agents.

SAFETY

Revision History

Revision Comment Date

Issue 14 A03864 Nov 2016

Issue 15 A05004 July 2017

MAN0530 Issue 15 - 07/17 Searchline Excel

2104M0506

CONTENTS

SAFETY 2

1. INTRODUCTION 6

2. OVERVIEW 8

2.1 Introduction 8

2.2 Transmitter 9

2.3 Receiver 10

2.4 Adjustable Mountings 12

3. INSTALLATION AND OPERATION 13

3.1 Introduction 13

3.2 Siting and Mounting 14

3.3 Electrical connections 18

3.4 Power supply 25

3.5 Unpacking 28

3.6 Installation procedure 30

3.7 Alignment and commissioning 36

3.8 System Controller calibration 51

3.9 Installation Checks/Tests 52

4. MAINTENANCE 58

4.1 Inspection and Cleaning 58

4.2 Searchline Excel: Plastic Functional Test Filters – Open

Path 58

4.3 Calibration Check using the Gassing Cell 59

4.4 Display Gas Reading 61

4.5 Alignment Telescope 62

4.6 Operational Maintenance (FM) 62

5. PROBLEM SOLVING 63

6. SPECIFICATIONS 68

6.1 System 68

7. CERTIFICATION 70

7.1 General 70

7.2 ATEX & IECEx 71

7.3 UL 77

7.4 CSA/FM 80

7.5 RoHS - Restriction of Hazardous Substances 85

MAN0530 Issue 15 - 07/17 Searchline Excel

2104M0506

CONTENTS

APPENDIX A - HANDHELD INTERROGATOR 86

A.1 Introduction 86

A.2 Overview 86

A.3 Connection to System 87

A.4 Basic User Tasks 88

A.5 Menus 89

A.6 Problem Solving 103

A.7 specication 104

APPENDIX B - GLOSSARY 106

B.1 Terminology 106

B.2 Measurement Units 106

B.3 Abbreviations 107

APPENDIX C - ACCESSORIES & SPARE PARTS 109

C.1 System Units 109

APPENDIX D - MARINE BRACKET 115

D.1 OVERVIEW 115

D.2 INSTALLATION AND OPERATION 116

MAN0530 Issue 15 - 07/17 Searchline Excel

2104M0506

Searchline Excel is a hydrocarbon gas detection system that is available in two versions:

• Searchline Excel Open-Path Gas Detector

• Searchline Excel Cross-Duct Gas Detector

For information regarding the Cross-Duct Excel please refer to the Searchline Excel Cross-Duct

Technical Handbook, part number 2104M0520.

Searchline Excel Open-Path Gas Detector (OPGD) consists of aTransmitter unit that sends an

infraredbeamtoaReceiverunitupto200metresaway,andcanbelocatedwhereaammable

hydrocarbon gas cloud is likely to occur.

Thedetectoroperatesontheprincipleofinfrared(IR)absorption.Gasesabsorblightatspecic

wavelengths depending on their molecular composition. Hydrocarbon gases absorb in the

infrared region of the spectrum. If a cloud of hydrocarbon gas is present, part of the infrared

light is absorbed by the gas, causing a reduction in the signal received that is proportional to

the amount of gas in the beam.

The Searchline Excel Transmitter unit produces the infrared light, and the Receiver unit features

optical detectors and signal processing electronics. Each unit is housed in a robust stainless

steel housing. The Receiver produces a 4 - 20mA analogue output equivalent to 0 - 5 LEL.m

(Lower Explosive Limit metres) of gas.

NOTE: THE INFRARED BEAM IS INVISIBLE AND EYE SAFE

Searchline Excel is designed for use in the most demanding environments/applications and

provides a sensitive, fast and reliable response. The sophisticated open-path technology

provides immunity to sunlight and minimises the effects of environmental factors such as rain,

fog, ice, snow and condensation.

The Transmitter and Receiver units incorporate heated optics designed to minimise the build

up of humidity, condensation, snow or ice on the glass windows, that could obscure the optics

in extreme conditions.

The system is microprocessor controlled with integral self-diagnostics and fault nding

facilities.

Local communication between an operator/technician and the gas detector system is made

via an associated Handheld Interrogator that uses the Receiver’s inbuilt RS485 serial link.

The interrogator provides the user with a menu-style interface to select and invoke commands

for commissioning and configuring the system, and for viewing the system state and

measurements.

The interrogator is connected to the Receiver via one of Honeywell Analytics' DX100 (M) series

types of Termination Unit, or via other types of junction box (including the Honeywell OELD

smart junction box) using the optional SHC Protection Device. The DX100(M) Termination Units

feature an active digital interface that allows a remotely located control centre to monitor the

gas detector's signal output and perform basic commands using the Modbus Remote Terminal

Unit (RTU) protocol over an RS485 link.

1. INTRODUCTION

MAN0530 Issue 15 - 07/17 Searchline Excel

2104M0506

This handbook consists of the following parts:

• Chapter 1 Introduction

• Chapter 2 System Description

• Chapter 3 Installation And Operation

• Chapter 4 Maintenance

• Chapter 5 Problem Solving

 • Chapter6  Specications

 • Chapter7  Certication

• Appendix A Handheld Interrogator

• Appendix B Glossary

• Appendix C Accessories & Spare Parts

• Appendix D Marine Bracket

Information notices

The types of information notices used throughout this handbook are as follows:

WARNING

Indicates hazardous or unsafe practice that could result in severe injury

or death to personnel.

Caution: Indicates hazardous or unsafe practice which could result in minor injury to

personnel, or product or property damage.

Note: Provides useful/helpful/additional information.

If more information beyond the scope of this technical handbook is required please contact

Honeywell Analytics.

Associated Documents

Searchline Excel Open-Path Infrared Gas Detector

Basic Installation Guide Part No: 2104M0510

DX100 Series Termination Units Technical Handbook Part No: 2104M0701

OELD Operating Instructions Part No: 3011M5001

1. INTRODUCTION

MAN0530 Issue 15 - 07/17 Searchline Excel

2104M0506

2.1 INTRODUCTION

Each type of Searchline Excel gas detector consists of two units, a Transmitter and a Receiver.

ThisseparateTransmitter/Receivercongurationprovidesthemostreliablebasisforopenpath

gasdetection.ForMarineCertiedversionsandtoensurecompliancewiththisapproval,please

refer to Appendix D for details of the maritime mounting brackets and associated hardware.

2. OVERVIEW

OELD or DX100(M) (or other

junction box)

Mounting plate

Mounting bracket

Pivot block

Receiver

Flexible conduit

Monitored

path

5 - 200 m

Honeywell Analytics

Junction Box

00780-A-0100 (or

other junction box)

Transmitter

MAN0530 Issue 15 - 07/17 Searchline Excel

2104M0506

There are three ranges of Searchline Excel gas detector. These are:

Open-Path Short Range 5 – 40m (15ft – 130ft)

Medium Range 40 – 120m (130ft – 390ft)

Long Range 120 – 200m (390ft – 650ft)

When designing an installation for Searchline Excel it is important that the correct range of the

gasdetectorforeachpathtobemonitoredisselectedandspecied.

The Transmitter and Receiver are each mounted upon robust, adjustable mounting brackets.

These brackets bolt to a mounting plate, which is designed to accommodate a variety of junction

boxes,accessoriesandmechanicalmountingcongurations.Thesmallsizeandexibilityof

Searchline Excel and its mounting arrangements are intended to make correct installation

design as simple as possible. Installation details are given in Chapter 3.

2.2 TRANSMITTER

The Searchline Excel Transmitter produces an intense, collimated infrared beam which is

producedbyaXenonarcashlamp.

Theashlamp’sinfraredoutputiscollimatedusingmirrorswhichenablesamoreuniformbeam

(no chromatic aberrations) to be produced and hence reduces alignment sensitivity. In order

topreventannoyingvisibleashes,thevisibleemissionsfromtheashlampareblockedbya

lter.

TheTransmitter’sashlampispulsedatprecisely4Hz,eachpulselastingforapproximately

one microsecond. The precise timing and extremely short duration of these pulses give the

Transmitter a very distinctive signature. This distinctive signature makes it easy for the Receiver

todistinguishSearchlineExcelTransmitterpulsesfrombothnaturalandarticialsourcesof

infrared radiation.

NOTE: THE INFRARED BEAM IS INVISIBLE AND EYE SAFE.

ThemediumandlongrangeTransmitterscontainahigherpowerashlampandlargeroptics

than the standard short range unit. The resulting infrared beam is many times brighter which

allows for a considerable increase in operating range.

2. OVERVIEW

MAN0530 Issue 15 - 07/17 Searchline Excel

2104M0506

The Transmitter window is heated to minimise condensation, frosting and the build up of snow.

During particularly cold operating conditions, the heating of the Transmitter window is increased

to turbo levels. The turbo mode can be disabled if not required.

Electrical connections to the Transmitter are made via wires which run through the protective,

exibleconduit.TherearethreeTransmitterwires,red(+24V),black(0V)andgreenIyellow

(GND).

2.3 RECEIVER

The Searchline Excel Receiver collects infrared radiation from the Transmitter and performs

measurements to enable hydrocarbon gases in the beam path to be detected.

Infrared radiation is collected by a single, silicon lens, which is common to both the sample and

reference measurement channels. This radiation is divided by a beamsplitter and fed to two

ltereddetectors,sampleandreference.

Thesampledetectorinputislteredatwavelengthswherestronginfraredabsorptionisexhibited

bythetargetgas.Thereferencedetectorinputislteredatnearbywavelengths,wherestrong

infrared absorption is not exhibited by the target gas. By calculating the ratio of the sample to

reference signal it is possible to measure the quantity of gas in the beam, whilst compensating

for the effects of rain, fog, dirt etc.

2. OVERVIEW

160mm (SR)

211 (MR/LR)

417mm (SR)

433 (MR/LR)

291mm (SR)

353 (MR/LR)

Approximately

300mm

Tabla de contenidos

Otros manuales de Detector de gas de Honeywell

Honeywell

Honeywell Apex Nota de versión

Honeywell

Honeywell Midas-M Manual de usuario

Honeywell

Honeywell Touchpoint 4 Manual de usuario

Honeywell

Honeywell BW IntelliFlash GasAlertMax XT II Manual de usuario

Honeywell

Honeywell SEARCHZONE SONIK SZSK-SMG Series Manual de usuario

Honeywell

Honeywell NOTIFIER VGN Series Manual de usuario

Honeywell

Honeywell MultiRAE Series Manual de usuario

Honeywell

Honeywell BW GasAlertMicroClip XT Manual de usuario

Honeywell

Honeywell Touchpoint Plus Nota de versión

Honeywell

Honeywell SEARCHZONE SONIK Manual de usuario

Honeywell

Honeywell Notifier VGS-EXP Manual de usuario

Honeywell

Honeywell BW Technologies GasAlertMicro 5 Manual de usuario

Honeywell

Honeywell BW Technologies Clip Real Time Manual de usuario

Honeywell

Honeywell HON COCON 13 Manual de usuario

Honeywell

Honeywell BW GasAlertMicro Manual de usuario

Honeywell

Honeywell AreaRAE Plus Manual de usuario

Honeywell

Honeywell BW Icon Manual de usuario

Honeywell

Honeywell Sensepoint XRL Manual de usuario

Honeywell

Honeywell BW Ultra Manual de usuario

Honeywell

Honeywell BW Technologies GasAlert MicroClip XT Manual de usuario

Honeywell

Honeywell GasAlertMicro 5 Series Manual de usuario

Honeywell

Honeywell Signalpoint Pro Manual de usuario

Honeywell

Honeywell MBeacon Manual de usuario

Honeywell

Honeywell Touchpoint Plus Manual de usuario

Manuales populares de Detector de gas de otras marcas

Macurco

Macurco GD-6 Manual de usuario

Evikon

Evikon E2632 Manual de usuario

Critical Environment Technologies

Critical Environment Technologies CGAS-A Series Manual de usuario

MSA

MSA altair 5 Manual de usuario

DOD Technologies

DOD Technologies ChemLogic CL96 Manual de usuario

DEGA

DEGA NS III LCD Series Manual de usuario

RKI Instruments

RKI Instruments 35-3001A-08-01 Manual de usuario

PEMTECH

PEMTECH PT2008 Series Manual de usuario

Coster

Coster RGS 328 Manual de usuario

Sygonix

Sygonix 2483186 Manual de usuario

Perry

Perry 1GA 50917MET/P Manual de usuario

isweek

isweek AS8900 Manual de usuario

Oldham

Oldham OLC 10 Manual de usuario

Wizmart

Wizmart NB983 Manual de usuario

Beacon

Beacon MEGA Manual

RKI

RKI GX-6000 Manual de usuario

Dräger

Dräger PIR 7000 Manual de usuario

GDS

GDS GASMAX EC Manual de usuario