Honeywell MCV2000AA Instrucciones de instalación

ENS5001R2 KO06 2005

MCV2000 SERIES

2-WAY HYDRONIC VALVES

PRODUCT SPECIFICATION SHEET

APPLICATION

The MCV2000 series are designed for residential

hydronic heating and cooling control applications.

The MCV2000 series 2-position hydronic valves are

used in residential and small commercial applications

to control the flow of hot and/or cold water. They

consist of actuator and valve.

FEATURES

Control by a low or line voltage SPST or SPDT

controller

100~130 VAC or 200~240VAC actuators available

Minimal actuator power consumption

Pressure differential up to 3.5bar

Versatile valve(1/2” ~ 1 1/4”) selection

1~90 °C fluid temperature

0~65 °C ambient temperature

Contents

Application

………………………………………………… 1

Features …………………………………………………… 1

Specification ……………………………………………... 1~3

Dimensions ………………………………………………… 3

Installation …………………………………………………. 4

Wiring Diagram ……………………………………………… 4

Pipe connection : PT

Maximum pressure : 10bar max.

Electrical termination : with integral 1000mm lead-wire cable

Ambient Temperature :0 ~ 65 °C

Ambient Humidity :10 ~ 95%RH (no condensing)

Storage temperature :-25 ~ 65 °C

Storage Humidity : 10 ~ 95%RH (no condensing)

Voltage : AC110/220V±10%, 50/60Hz

Colour-coded

label : Green, Black, White

Control

Performance : SPST/SPDT control

Power

consumption

: 6W at nominal voltages

(during valve position change only)

Operational life : Greater than 60,000 cycles (all loads) for

motor and valve contacts at 110/220V

Timing : 7.5sec (20sec in case 1 1/4” valve)

SPECIFICATION

MCV2000 SERIES HYDRONIC VALVE

ENS5001R2 KO06 2005

Table 2. Model Assembly Guide

Model

(Assembly) Model(Motor) Model(Valve) Model

(Assembly) Model(Motor) Model(Valve)

MCV2000AA MV2000AA MCV2010AA MV2000AA

MCV2000AH MV2000AH MCV2010AH MV2000AH

MCV2000AP

MC2000E

MV2000AP MCV2010AP

MC2010E

MV2000AP

MCV2000AV MC2000HE MV2000AV MCV2010AV MC2010HE MV2000AV

MCV2001AA MV2000AA MCV2011AA MV2000AA

MCV2001AH MV2000AH MCV2011AH MV2000AH

MCV2001AP

MC2001E

MV2000AP MCV2011AP

MC2011E

MV2000AP

MCV2001AV MC2001HE MV2000AV MCV2011AV MC2011HE MV2000AV

* Product Examples

-MC20xxE/HE : Actuator only, Egg crate with 15 actuators

-MV20xxAA/AH/AP/AV : Valve only, Egg crate with 40 valves(1/2”), 30 valves(3/4”), 21 valves(1”), 10 valves(1 1/4”)

* MC20 : Actuator family identifier

MCV2001AH

* xx00 : AC220V, SPST

* xx01 : AC220V, SPDT

* xx10 : AC110V, SPST

* xx11 : AC110V, SPDT

* E : 0.8Nm motor

* HE : 1.5Nm motor

* MV2000 : Valve family identifier

Table 3. Kv & Differential Pressure

Valve size Kv Max. operating differential pressure

1/2” 1.7 3.5 bar

3/4” 1.9 3.5 bar

1” 2.1 3.5 bar

1 1/4” 5.5 2.8 bar

Table 1. Model Selection Guide

* A : 1/2” valve

* H : 3/4” valve

* P : 1” valve

* V : 1 1/4” valve

with Int.(inlet) / Ext.(outlet) thread

* A : 2-way valve

* M : 3-way valve

MC20 01 E + MV2000 A H

* MCV2001AH = MC2001E + MV2000AH : AC220V, SPDT, 0.8Nm, 3/4

”

, 2

way valve

(with int.(inlet) / Ext.(outlet) thread & PT fitting)

MCV2000 SERIES HYDRONIC VALVE

ENS5001R2 KO06 2005

< 1/2” valve >

< 1” valve >

< 3/4” valve >

< 1 1/4 ” valve >

Fig. 1 Valve Pressure Loss Characteristic for 2-way Valves

Fig. 2 MCV Valve Dimensions (in mm)

    

  

  !

" 

"  

" #$

DIMENSIONS

MCV2000 SERIES HYDRONIC VALVE



Honeywell Co., Ltd.

Environmental Controls

18F, Kukje Center Building 191, Hangangro-2ga,

Yongsan-gu, Seoul, 140-702, Korea

Tel. 82-2-799-6170/6194

Fax. 82-2-799-6188

ENS5001R2 KO06 2005

INSTALLATION

1. The valve may be plumbed in any angle but

preferably not with the actuator head below the

horizontal level of the valve body. Make sure there is

enough room around the actuator head for servicing

or replacement.

2. The valve body can be mounted directly onto the

inlet pipe. Mount the metal flange inserted in socket

to outlet pipe. And then tighten the socket enough to

make a seal. See Figure 2 for the detail dimension.

3. Mount the valve directly in the tube or pipe. Do not

grip actuator head while making and tightening

plumbing connections. Either hold valve body in your

hand or attach adjustable spanner across the

hexagonal or flat faces on the valve body.

WIRING DIAGRAM



Fig. 3 Diagram with 3-wire Actuator for SPST Controller

Fig. 4 Diagram with 3-wire Actuator for SPDT Controller

CAUTION

Disconnect Power Supply before making electrical

connections to prevent electrical shock and equipment

damage.

WARNING

Take care that installer is a trained experienced service

person.

When installing this product:

Read these instructions carefully.

Failure to follow them could damage the product or

cause a hazardous condition.

Check the ratings given in the instructions and on the

product to make sure it is suitable for your application.

Always conduct a through checkout after installation.

BLACK

SPST Controller

WHITE

RLY

GREEN

MCV2000 Series

(CLOSE)

(OPEN)

SPDT Controller

BLACK

WHITE

GREEN

MCV2000 Series

(CLOSE)

(OPEN)

Este manual sirve para los siguientes modelos

Otros manuales de Unidad de control de Honeywell

Honeywell

Honeywell NOTIFIER M701E Manual de usuario

Honeywell

Honeywell VISTA-ICM Instrucciones de montaje

Honeywell

Honeywell SUPER TRADELINE VR8300A Manual de usuario

Honeywell

Honeywell HON 530-E-WG Guía

Honeywell

Honeywell FV300 Manual de usuario

Honeywell

Honeywell NK295C Manual de usuario

Honeywell

Honeywell Ex-Or CDW12U5 Manual de instalación y operación

Honeywell

Honeywell V5011N Manual de usuario

Honeywell

Honeywell SUPER TRADELINE VR8300A Manual de usuario

Honeywell

Honeywell SLATE Manual de usuario

Honeywell

Honeywell 7800 SERIES Manual de usuario

Honeywell

Honeywell TS131 Manual de usuario

Honeywell

Honeywell VSxF-2 Manual de usuario

Honeywell

Honeywell THP9045 Manual de usuario

Honeywell

Honeywell PM7600B Manual de usuario

Honeywell

Honeywell RM7824A Manual de operación

Honeywell

Honeywell MI-DCMOE Manual de instrucciones

Honeywell

Honeywell 7800 SERIES Manual de operación

Honeywell

Honeywell Kromschroder TC 1 Manual de usuario

Honeywell

Honeywell RK-MCU Hoja de instrucciones

Honeywell

Honeywell D06F Manual de usuario

Honeywell

Honeywell Ex-Or CDH8U5 Manual de instalación y operación

Honeywell

Honeywell S89C Manual de usuario

Honeywell

Honeywell SM152 Series Manual de usuario

Manuales populares de Unidad de control de otras marcas

Festo

Festo Compact Performance CP-FB6-E Manual de lista de piezas

Elo TouchSystems

Elo TouchSystems DMS-SA19P-EXTME Manual de usuario

JS Automation

JS Automation MPC3034A Manual de usuario

JAUDT

JAUDT SW GII 6406 Series Guía rápida

Spektrum

Spektrum Air Module System Manual de usuario

BOC Edwards

BOC Edwards Q Series Manual de usuario

KHADAS

KHADAS BT Magic Manual de usuario

Etherma

Etherma eNEXHO-IL Manual de usuario

PMFoundations

PMFoundations Attenuverter Manual de usuario

GEA

GEA VARIVENT Manual de usuario

Walther Systemtechnik

Walther Systemtechnik VMS-05 Manual de usuario

Altronix

Altronix LINQ8PD Instrucciones de montaje

Eaton

Eaton Powerware Series Manual de usuario

WAGO

WAGO 750-407/040-000 Manual de usuario

Sony

Sony CCU-590 Manual de usuario

Graco

Graco 25D614 Manual de usuario

Task Force Tips

Task Force Tips YE-RF-900 Manual de programación

Shini

Shini SPV-U Series Manual de usuario