Ohlins DU 569 Manual de usuario

Shock absorber for Ducati Panigale V2/959/899

DU 569

Mounting Instructions

Note!1

Please note that there can be small differences

between your product and the images in

these instructions.

Note!1

Please note that during storage and transport,

especially at high ambient temperature, some

of the oil and grease used for assembly may

leak and stain the packaging. This will not

cause damage to the product, wipe off the

excessive oil or grease with a cloth.

Note!1

Before you install this product, check the kit

contents. If anything is missing, please contact

an Öhlins dealer.

Warning!⚠

Before you install this product, read the Öhlins

Owner’s manual. This product is an important

part of the vehicle and the vehicle stability.

Kit Contents

Description Part No Pcs

Shock absorber DU 569 1

C-spanner 00710-06 2

Sticker Memo notes 01180-01 1

Sticker set Öhlins 1

Owner’s manual 07242-07 1

Note!1

For Panigale 899: Shorten the shock absorber

5 mm by turning the end eye 5 turns in, before

mounting the shock.

For Panigale 959: Shorten the shock absorber

3 mm by turning the end eye 3 turns in, before

mounting the shock.

Put the motorcycle on a work stand so that the

rear wheel barely touches the ground.

Remove the original shock absorber.

MOUNTING INSTRUCTIONS

Warning!⚠

We strongly recommend to let an Öhlins dealer

install this product.

Warning!⚠

If you work with a lifted vehicle, make sure that it

is safely supported to prevent it from tipping over.

Note!1

When you work with this product, see the

vehicle service manual for vehicle specic

procedures and important data.

Note!1

Before you install this product clean the

vehicle.

Install the Öhlins shock absorber in the same

position as the original shock absorber.

Note!1

Lower the vehicle so that the suspension

is slightly compressed before you tighten

the screws.

Remove the plastic spring cover from the

original shock absorber and install it on the

Öhlins shock absorber.

Remove the seat.

Remove the bracket at the rear end of the tank.

Remove the cover around the ignition lock.

MOUNTING INSTRUCTIONS

Carefully lift the rear end of the tank, note

the grounding wire on the left side and make

sure not to squeeze or stretch any cables.

Disconnect the grounding wire and the electric

cable to get access to the screws for the left

side cover.

Remove the left side cover, see gure.

Separate the left side cover into 2 parts. Install

the rear part.

Connect the grounding wire and the electric

cable, install the cover, bracket and the seat.

Caution!✋

Make sure that you tighten all screws to the

correct torque and that nothing fouls or restricts

movement of the shock absorber/front fork/

steering damper when the suspension is fully

compressed or extended.

Öhlins Racing AB

Box 722

S-194 27 Upplands Väsby, Sweden

Phone +46 8 590 025 00

fax +46 8 590 025 80

reserved. Any reprinting or

unauthorized use without the written

permission of Öhlins Racing AB

is prohibited.

Öhlins products are subject to

continuous improvement and

development, therefore, although

these instructions include the most

up-to-date information available at

the time of printing, minor updates

may occur.

To nd the latest information

contact an Öhlins distributor.

Please contact Öhlins if you have

any questions regarding the

contents in this document.

SETUP DATA

Warning!⚠

Before you ride/drive, always make sure that the

setup is according to the recommended setup

data. Read about adjustments and setting up

in the Öhlins Owner’s Manual before you make

any adjustments. Contact an Öhlins dealer if

you have any questions about setting up.

ADJUSTMENTS

Part no. MI_DU569_0

Issued 2020-03-11

Length 317 +4/-8 mm

Stroke 65 mm

Rebound 19 clicks

Compression 16 clicks

Spring preload 17 mm

Spring 01092-24

Spring rate 80 N/mm

Free spring length 170 mm

Recommended sag and ride height

R1-R3 29 mm

F1-F3 40 mm

Spring

preload

adjuster

Length

adjuster

Rebound

damping

adjuster

Compression

damping

adjuster

Otros manuales de Accesorios para motocicletas de Ohlins

Ohlins

Ohlins KA 590 Manual de usuario

Ohlins

Ohlins TR 807 Manual de usuario

Ohlins

Ohlins DU 907 Manual de usuario

Ohlins

Ohlins McPherson Strut MIR 1G00 Manual de usuario

Ohlins

Ohlins suspension kit HOV 5A000 Manual de usuario

Ohlins

Ohlins prodrive SUR 3A00 Manual de usuario

Ohlins

Ohlins YA 314 Manual de usuario

Ohlins

Ohlins TR 538 Manual de usuario

Ohlins

Ohlins RS 562 Manual de usuario

Ohlins

Ohlins BM 344 Manual de usuario

Ohlins

Ohlins HO 201 Manual de usuario

Ohlins

Ohlins POF6H00 Manual de usuario

Ohlins

Ohlins BM 503 Manual de usuario

Ohlins

Ohlins BM335 Manual de usuario

Ohlins

Ohlins HO 403 Guía del usuario

Ohlins

Ohlins HO 519 Manual de usuario

Ohlins

Ohlins SD 154 Manual de usuario

Ohlins

Ohlins YA812 Manual de usuario

Ohlins

Ohlins KA 464 Manual de usuario

Ohlins

Ohlins SU601 Manual de usuario

Ohlins

Ohlins SD 168 Manual de usuario

Ohlins

Ohlins YA919 Manual de usuario

Ohlins

Ohlins HO 404 Manual de usuario

Ohlins

Ohlins Mechatronics 35007-01 Manual de usuario

Manuales populares de Accesorios para motocicletas de otras marcas

SRC

SRC B-TRK502-01-01-SL Manual de usuario

3M Speedglas 9100 MP Manual de usuario

hepco & becker

hepco & becker 6307520 00 01 Manual de usuario

HOMCOM

HOMCOM AA0-077 Manual de usuario

hepco & becker

hepco & becker 6307558 00 01 Manual de usuario

Wunderkind Custom

Wunderkind Custom 106503-F15 Guía del usuario

Dräger

Dräger HPS 3500 Manual de usuario

M-WAVE

M-WAVE SKI Manual de usuario

Kuryakyn

Kuryakyn 6212 Manual de usuario

hepco & becker

hepco & becker 6507504 00 01 Manual de usuario

Tool it

Tool it PROMAX LCD 9.13G Manual de usuario

Custom Dynamics

Custom Dynamics TruWrapz Manual de usuario

Roof

Roof RO200 CARBON Manual de usuario

Kabuto

Kabuto Japan IBUKI Manual de usuario

PUIG

PUIG 5051 Manual de usuario

rizoma

rizoma ZTH050 Manual de usuario

Joubert

Joubert 10001711 Manual de usuario

Sperian

Sperian Optrel p420 Manual de usuario