Hearth and Home Technologies 36-EBU Manual de usuario

Installation Guide for the

36-EBU and 42-EBU Electric Fireplace

LISTINGS AND CODE APPROVALS

The EBU series fireplaces have been tested in accordance with the UL 2021 and CSA C22.2 No. 46 standards for fixed

and location-dedicated electric room heaters.

MODEL SPECIFICATIONS

Model

Number Description Voltage Volts Rated Power

Watts Remote

Control Wall

Thermostat Mesh

Screen AMPS

120Volt AMPS

208Volt AMPS

240Volt

36-EBU 36” Standard 120/208/240 1650/2340/3025 Included Included Included 13.75 11.25 12.6

42-EBU 42” Standard 120/208/240 1650/2340/3025 Included Included Included 13.75 11.25 12.6

NOTE: Power ratings shown include the light bulbs and motor (275 watts)

STEP-BY-STEP INSTALLATION (Note: Please read all instructions before installing)

1. Rough in framing opening following the recommended dimensions (Section A: Framing).

2. Allow 8” of service cable for connecting to the junction box on the fireplace. Remove the outer jacket and strip

the individual conductors ½” from the end.

3. Loosen the screw securing junction box cover and remove the cover.

4. Remove knockouts if necessary or use the provided cable clamp.

5. Place unit in position in the opening, level with shims if necessary and attach unit to frame using nailing flanges

provided.

6. Unit is factory wired for 208/240 volt power supply. If 120 volt operation is required, slide the switch and

reconfigure the wiring as covered in section C wiring. Wires L1, L2, N & G are attached to the rear of the

junction box cable clamp for easy access.

7. Wire a dedicated, properly fused circuit with a 20amp rating for the appropriate voltage (120, 208/240).

8. Make wall mounted thermostat connections as outlined in Section C: Wiring.

9. Place all connectors inside the unit and replace the junction box cover, ensuring that the cable clamp grips only

the jacket of service or thermostat.

266-950 5/03

7205240100REV00

SECTION A: FRAMING

EBU Dimensions

Rough-in framing dimensions EBU dimensions Rough-in corner framing dimensions

This fireplace is a zero clearance design. Combustibles may be installed to the edge of the unit. A drywall lip at the top

of the unit and four nailing flanges on the sides of the unit are provided on each unit to facilitate installation. Insulation

and vapor barrier can be placed a minimum of 2 inches from the unit.

SECTION B: RECOMMENDED POWER SUPPLY WIRE SPECIFICATIONS

For 120 volt installations use two conductors, non-metallic sheath cable with ground wire for the incoming power supply

on EBU fireplace inserts. Use the appropriate wire to meet local and national electrical codes for rated power

consumption.

For 208 / 240 volt installations use three conductors, non-metallic sheath cable with ground wire for the incoming power

supply on EBU fireplaces. Use the appropriate wire to meet local and national electrical codes for rated power

consumption.

Two conductors, non-metallic sheath cable with ground wire is recommended for installation of a wall mounted

thermostat on EBU fireplaces. Use appropriate wire to meet local and national electrical codes for rated power

consumption. Thermostat switch wire gauge must match the recommended wire sizes shown below.

RECOMMENDED WIRE AND FUSING REQUIREMENTS

VOLTS WIRE GAUGE FUSE RATING

120 VOLT 12 GAUGE 20 AMP

208 VOLT 14 GAUGE 15 AMP

240 VOLT 12 GAUGE 20 AMP

MODEL A B C D E F

36-EBU 35.5” 38.7” 54.0” 38.0” 38.0” 40.0”

42-EBU 41.5” 44.7” 60.0” 42.0” 42.0” 46.0”

SECTION C: WIRING

NOTE: The unit is factory configured for 208/240 volt operation

NOTE: All wiring must be completed prior to installing the unit.

NOTE: Ensure that the power conversion switch is in the proper position for the required supply voltage prior to

connecting the unit to power supply.

240 VOLT INSTALLATIONS

1. Locate the switch on the top corner of the unit.

2. Ensure that the switch is in the 230 volt position.

3. Loosen the screw securing the junction box cover and remove the cover.

4. Remove the knockouts (if necessary) or use the provided cable clamp.

5. Pull out the four wires marked L1, L2, N, and G.

6. Connect the black L1 wire from the unit to the L1 from the power supply. Connect the red L2 wire from the unit

to the L2 from the power supply. Connect the white N wire from the unit to the neutral from the power supply.

Connect the green ground wire from the unit to the ground from the power supply.

7. When the unit has been configured for the appropriate power supply voltage, ensure that all connections are

tight. Insert all the wiring into the unit and secure with a cable clamp.

TO RECONFIGURE FROM 240 VOLT TO 120 VOLT

1. Locate the switch on the top corner of the unit.

2. Flip the switch from 230 volt to 115 volt configuration.

3. Loosen the screw securing the junction box cover and remove the cover.

4. Remove the knockouts (if necessary) or use the provided cable clamp.

5. Pull out the four wires marked L1, L2, N, and G.

6. Connect the black L1 wire from the unit to the L1 from the power supply. Connect the red L2 and white N wires

to the neutral from the power supply. Connect the green ground wire from the unit to the ground from the power

supply.

7. When the unit has been configured for the appropriate power supply voltage, ensure that all connections are

tight. Insert all the wiring into the unit and secure with a cable clamp.

TOP OF FIREPLACE 230 VOLT/115 VOLT SWITCH

WALL MOUNTED THERMOSTAT WIRING

NOTE: Wiring of the thermostat must be completed prior to installing the unit.

NOTE: The following installation instructions are for a single pole thermostat included with the unit.

120 / 240VOLT INSTALLATIONS

The wall mounted thermostat is connected to the fireplace by running a 2 conductor wire with a ground from the junction

box on the back of the unit to the thermostat.

1. Locate the switch on the top corner of the unit and ensure that the power conversion switch is in the proper

position for the required supply voltage.

2. Loosen the screw securing the junction box and remove the cover. Pull out the wire nut that contains wires

marked 1 & 2.

3. Remove the wire nut and separate the wires marked 1 & 2.

4. Connect one of the wires from the thermostat to the wire marked 1 and the other wire to the wire marked 2.

5. Connect the ground wire from the thermostat to the ground wire grouping from the power supply.

6. Ensure that all connections are tight. Insert all the wiring into the unit and secure with a cable clamp.

WIRING DIAGRAM WITH REMOTE CONTROL

Service Parts 36-EBU, 42-EBU

(NG, LP) Exploded Part Diagram Beginning Manufacturing Date: 6-01

(GN, PL) Vue éclatée des pièces Ending Manufacturing Date: ______

36-EBU, 42-EBU Electric Fireplace Service Parts List

MODEL >

36-EBU 42-EBU

MOD. LEVEL >

None None

ITEM REPLACEMENT PART PART NUMBER

1 LOG SET 0438200300RP 0438200300RP

1 30" LOG SET 0438440100RP 0438440100RP

2 MIRROR ASSEMBLY 5900160100RP 5900160200RP

3 POWER ON/OFF SWITCH 2800070400RP 2800070400RP

4 AUXILARYCONTROL SWITCH 2800070500RP 2800070500RP

5 MESH CURTAIN 8800240103RP 8800240203RP

6 LOWER LIGHT HARNESS 2500130100RP 2500130100RP

7 AC MOTOR 6900360100RP 6900360100RP

8 REFLECTOR ROTISSERIE 6900190500RP 6900190500RP

9 BLOWER ASSEMBLY 5300110300RP 5300110300RP

10 REMOTE CONTROL ASSEMBLY 3000200300RP 3000200300RP

11 ELEMENT 2200460100RP 2200460100RP

12 TEMPERATURE LIMITING SWITCH 2300200200RP 2300200200RP

HIGH LIMIT CUTOUT 2300200100RP 2300200100RP

WALL MOUNTED THERMOSTAT TS901W TS901W

REMOTE CONTROL TRANSMITTER 3000200600RP 3000200600RP

CIRCUIT BOARD 3000200700RP 3000200700RP

MIRROR CHANNEL 0438290100RP 0438290100RP

MESH SCREEN ROD 8800250100RP 8800250200RP

VOLTAGE SELECTOR SWITCH WITH WIRES 2500180100RP 2500180100RP

Use Sylvania light bulbs item #SL13460 that can be ordered via the website www.lite-house.com or by call 1-800-838-

0977. You can also buy replacement bulbs at most hardware stores and home centers: clear chandelier Candelabra

bulbs with E-12 (small) socket base, 60 watts rating. Ex. GE 60BC or Phillips 60CTC.

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Chimenea de interior de Hearth and Home Technologies

Hearth and Home Technologies

Hearth and Home Technologies QV32E (120V) Manual de usuario

Hearth and Home Technologies

Hearth and Home Technologies PVK-80 Manual de usuario

Hearth and Home Technologies

Hearth and Home Technologies SFE-CDLB3530PP Instrucciones de montaje

Hearth and Home Technologies

Hearth and Home Technologies GO35MTCH Manual de usuario

Hearth and Home Technologies

Hearth and Home Technologies Grand-XT Manual de usuario

Hearth and Home Technologies

Hearth and Home Technologies AZTEC Manual de usuario

Hearth and Home Technologies

Hearth and Home Technologies Crescent II Door Manual de usuario

Hearth and Home Technologies

Hearth and Home Technologies DV3732 Manual de usuario

Hearth and Home Technologies

Hearth and Home Technologies BC36C Manual

Hearth and Home Technologies

Hearth and Home Technologies Heat & Glo EM-415 Manual de usuario

Hearth and Home Technologies

Hearth and Home Technologies BE-32 Manual de usuario

Hearth and Home Technologies

Hearth and Home Technologies Simplifyre SFE-35 Instrucciones de instalación

Hearth and Home Technologies

Hearth and Home Technologies outdoor lifestyles LUM-OD-NM Instrucciones de funcionamiento

Hearth and Home Technologies

Hearth and Home Technologies 350TRSI-AUF Manual de usuario

Hearth and Home Technologies

Hearth and Home Technologies Simplifyre SFE-35 Instrucciones de montaje

Hearth and Home Technologies

Hearth and Home Technologies Simplifyre SFE-35 Instrucciones de montaje

Hearth and Home Technologies

Hearth and Home Technologies Quadra-Fire EXPEDITIONII-AU Manual de usuario

Hearth and Home Technologies

Hearth and Home Technologies Outdoor Lifestyles ODPLAZA-L24S-B Manual de usuario

Hearth and Home Technologies

Hearth and Home Technologies outdoor lifestyle ODCTGWD-36 Manual de usuario

Hearth and Home Technologies

Hearth and Home Technologies DV3732SBIL Manual de usuario

Hearth and Home Technologies

Hearth and Home Technologies outdoor lifestyles Dakota 42-CE Instrucciones de montaje

Hearth and Home Technologies

Hearth and Home Technologies B36S-AU Manual de usuario

Hearth and Home Technologies

Hearth and Home Technologies 6000BE Manual de usuario

Hearth and Home Technologies

Hearth and Home Technologies Accelerator 4 14-1/8 Manual de usuario

Manuales populares de Chimenea de interior de otras marcas

Brigantia

Brigantia 35-DVRS31N-2 Manual del propietario

Nordpeis

Nordpeis Bergen Manual de usuario

Superior

Superior BCT2536TMN Manual de usuario

Quadra-Fire

Quadra-Fire 5100I-GD-B Manual de usuario

Renaissance

Renaissance RUMFORD 1000 Manual de usuario

Lacunza

Lacunza IV-800 Manual de usuario

Baxi

Baxi 940 Instrucciones de uso

Dru

Dru Maestro 60/2 Tall RCH Manual de usuario

Diamond Fireglass

Diamond Fireglass SS-O22 Manual de usuario

HearthStone

HearthStone Windsor Bay 8830 Manual de programación

Napoleon

Napoleon ASCENT B42 Manual de usuario

Enviro

Enviro E33GI Manual de usuario

Smeg

Smeg L30 FABE Instrucciones de montaje

KEDDY

KEDDY K700 Manual de usuario

Godin

Godin 3451 Manual de usuario

Jøtul

Jøtul Jotul GI 535 DV IPI New Harbor Manual de usuario

Austro Flamm

Austro Flamm Heidi Back 2.0 945048 Manual de usuario

Desa

Desa CCFPDFT Manual de operación