Haier HDBC100AFS Manual de usuario
18” Built-In Dishwasher
Lave-Vaisselle Incorpere 18”
Lavavajillas Empotrado 18”
Installation Instructions
Instructions d’installation
Instrucciones de instalación
HDBC100AFS
1
TABLE OF CONTENTS
DISHWASHER SAFETY........................................................................................2
INSTALLATION REQUIREMENTS......................................................................... 4
Tools and Parts...............................................................................................................4
Location Requirements................................................................................................. 5
Product Dimensions...................................................................................................... 6
Drain Requirements.......................................................................................................7
Water Supply Requirements .........................................................................................8
Electrical Requirements ................................................................................................ 8
INSTALLATION INSTRUCTIONS..........................................................................9
Prepare Cabinet Opening Using Existing Utility Hookups...........................................9
Install the Drain Hose ..................................................................................................10
Prepare Cabinet Opening Where There Are No Existing Utility Hookups ................12
Prepare Dishwasher.....................................................................................................15
Check Door Spring Tension.........................................................................................17
Move Dishwasher Into Cabinet Opening....................................................................17
Level the Dishwasher ..................................................................................................18
Make Electrical Connection ........................................................................................19
Connect To Water Supply............................................................................................22
Connect To Drain .........................................................................................................23
Securing Dishwasher To Countertop..........................................................................24
Complete Installation..................................................................................................25
2
DISHWASHER SAFETY
Your safety and the safety of others are very important.
We have provided many important safety messages in this manual and
on your appliance. Always read and obey all safety messages.
DANGER
WARNING
CAUTION
This is the safety alert symbol.
This symbol alerts you to potential hazards that can
kill or hurt you and others. All safety messages will
follow the safety alert symbol and either the word
“DANGER,” “WARNING” or “CAUTION.”
These words mean:
An imminently hazardous situation. You
could be killed or seriously injured if you
don’t immediately follow instructions.
A potentially hazardous situation
which, if not avoided, could result in
death or serious bodily injury.
A potentially hazardous situation
which, if not avoided, may result in
moderate or minor injury.
All safety messages will tell you what the potential hazard is, tell you
how to reduce the chance of injury, and tell you what can happen if the
instructions are not followed.
In the State of Massachusetts, the following installation instructions
apply:
• Installations and repairs must be performed by a qualied or
licensed contractor, plumber, or gastter qualied or licensed by the
State of Massachusetts.
• If using a ball valve, it shall be a T-handle type.
• A exible gas connector, when used, must not exceed 3 feet.
3
WARNING
Tip Over Hazard
Do not use dishwasher until completely installed.
Do not push down on open door.
Failure to follow these instructions can result in serious injury or cuts.
YOU NEED TO:
• Slowly open dishwasher door while someone grasps the rear of the
dishwasher. Remove shipping materials, drain hose and lower rack.
Close dishwasher door until latched.
• Observe all governing codes and ordinances
• Install this dishwasher as specied in these instructions.
• Installation should be performed by a qualied service technician. The
dishwasher must be installed to meet all electrical and plumbing national
and local codes and ordinances.
4
INSTALLATION REQUIREMENTS
TOOLS AND PARTS
Gather the required tools and parts before starting installation.
ALL INSTALLATIONS
Tools Needed:
• Phillips screwdriver
• Flat-blade screwdriver
• Measuring tape or ruler
• 6” adjustable wrench
• Small level
• Flashlight
• Shallow pan
Parts Needed:
• 90° elbow with ” N.P.T. external
threads on one end. (The other end
must t your water supply line.)
• Plumbers tape
• 3 UL listed wire nuts
• One 1½” - 2” screw type clamp
IN ADDITION, FOR NEW INSTALLATIONS
Tools Needed:
• Electric drill with ½”, ¾”and 1½”
hole saw bits
• Small tubing center
Parts Needed:
• Copper tubing (” recommended)
• Clamp connector (strain relief) to ts
” (22.2 cm) diameter hole.
• One 1½” - 2” screw type clamp if
connecting to waste-tee
PARTS SUPPLIED:
a 2 - #8 x ” Phillips at head wood screws
b 2 - Phillips head, color matched toekick screws
Make sure these parts are included.
See separate parts list for accessories available for your dishwasher.
a
b
5
LOCATION REQUIREMENTS
Do not run drain lines, water lines or electrical wiring where they can interfere with
or contact dishwasher motors or legs.
The location where the dishwasher will be installed must provide clearance between
motors and ooring. Motors should not touch the oor.
Do not install dishwasher over carpeted ooring
Protect dishwasher and water lines leading to dishwasher against freezing. Damage
from freezing is not covered by the warranty.
Check location where dishwasher will be installed. The location must provide:
• Easy access to water, electricity and drain
• Convenient access for loading and unloading dishes. Corner locations require a
2” (5.1 cm) minimum clearance between the side of the dishwasher door and the
wall or cabinet.
• Minimum of 25” (65.1 cm) in front of dishwasher to allow door to fully open.
Countertop
Dishwasher
25-5/8"
( 65.1 cm)
2" ( 5.1 cm)
clearance for door
opening min.
• An area, fully enclosed on both sides, back and top.
• Square opening for proper operation and appearance.
• Cabinet front perpendicular to oor.
• Level oor. (If oor at front of opening is not level with oor at rear of opening,
shims may be needed to level dishwasher.)
NOTE: To prevent shifting during dishwasher operation, shims must be securely
attached to the oor.
If dishwasher will be left unused for a period of time or in a location where it may be
subject to freezing, have it winterized by authorized service personnel.
Make sure pipes, wires and drain hose are within the shaded area shown in the
“Cutout Dimensions” section.
6
PRODUCT DIMENSIONS
* to front of door frame
22" (59cm)*
18" (45.7 cm)
32-1/2"
(82.5 cm) min.
35" (88.9 cm)
max
SIDE VIEW
REAR VIEW
17-1/2" (44.5 cm) min.
18" (45.7 cm) max.
7
CUTOUT DIMENSIONS
6"
(15.2 cm)
4"
(10.2 cm)
24"
(61 cm)
min.
All surfaces must be free
from intrusions
34" to 35"
(86.4 cm to
88.9 cm)*
17-5/8" (44.8 cm) min.
18" (45.7 cm) max.
*Underside of countertop to oor.
Cut holes in the shaded area of the cabinet walls or oor for plumbing and electrical service.
NOTE: ADA installation, 32” (82.5) cm beneath 34” (86.4 cm) high countertops
may be accomplished by adjusting the toekick and leveling legs.
DRAIN REQUIREMENTS
• Use the new drain hose supplied with your dishwasher. If this is not long enough,
use a new drain hose with a maximum length of 10 ft (3.05 m) that meets all
current AHAM/IAPMO test standards, is resistant to heat and detergent, use
”(1.58 cm) or ”(2.2 cm) inside diameter (I.D.) hose and a coupler to connect
the two hose ends. Secure the connection with two clamps
• Connect drain hose to waste T or disposer inlet above drain trap in house
plumbing and 32” (81.3 cm) minimum above the oor. It is recommended that
the drain hose either be looped up and securely fastened to the underside of the
counter, or be connected to an air gap.
• Use an air gap if the drain hose is connected to house plumbing lower than 20”
(50.8 cm) above the oor.
air gap
• Use ” minimum I.D. drain line ttings.
8
• Do not connect drain lines from other devices to the dishwasher drain hose.
WATER SUPPLY REQUIREMENTS
• A hot water line with 20-120 psi (138-862 kPa) water pressure.
• 120°F (49°C) water at dishwasher.
• ” outside diameter (O.D.) copper tubing with compression tting or exible
stainless steel braided ll line (” minimum plastic tubing is not recommended).
• A 90° elbow with ” N.P.T. external pipe threads on one end.
ELECTRICAL REQUIREMENTS
Contact a qualied electrician. Be sure that the electrical connection and wire size
are adequate and in conformance with the National Electrical Code, ANSI/ NFPA No.
7-latest edition and all local codes and ordinances.
A copy of the above code standards can be obtained from:
National Fire Protection Association
One Batterymarch Park
Quincy, MA 02269
You must have:
• 120 volt, 60 Hz, AC-only, 15 or 20 amp., fused electrical supply
• Wiring must be 2 wire with ground.
We recommend:
• A time-delay fuse or circuit breaker.
• A separate circuit.
If direct wiring dishwasher:
• Use exible, armored or non-metallic sheathed, copper wire with grounding
wire that meets the wiring requirements for your home and local codes and
ordinances.
Electrical Connection to Dishwasher
Electrical connection is on the right front of dishwasher.
• For cable direct connections the cable must be routed as shown. Cable must
extend a minimum of 24” from the rear wall.
• For power cord connections, have a qualied electrician install a 3 prong
grounding type receptacle. The power-supply receptacle for the appliance shall
be installed in a cabinet or on a wall adjacent to the under counter space in which
the appliance is to be installed.
Otros manuales para HDBC100AFS
1
Tabla de contenidos
Idiomas:
Otros manuales de Lavavajillas de Haier
Haier
Haier DW9-AFM ME Manual de usuario
Haier
Haier ESD100 Manual de usuario
Haier
Haier HDW201SS Manual de usuario
Haier
Haier HDBL655AFS Manual de usuario
Haier
Haier HDP18PA Manual de usuario
Haier
Haier DW12-EFMSS Manual de usuario
Haier
Haier 120505609 Manual de usuario
Haier
Haier DW12-TFE1 series Manual de usuario
Haier
Haier HDW6WH Manual de usuario
Haier
Haier WQP4-1A Manual de usuario
Haier
Haier DW12-TFE3-F Manual de usuario
Haier
Haier HDW9SS Manual de usuario
Haier
Haier proline IDW12P-E Instrucciones de construcción
Haier
Haier HDW700BI Manual de usuario
Haier
Haier HDBL865ATS Manual de usuario
Haier
Haier HDC2406TW Instrucciones de montaje
Haier
Haier DWL3525DBBB Manual de usuario
Haier
Haier DW12-EFMME Manual de usuario
Haier
Haier HDB18EB Manual de usuario
Haier
Haier DW15-PFE2 series Manual de usuario
