Generac Power Systems Mobile Power MMG175 Manual de usuario
Manufactured by Magnum Power ProductsLLC., a wholly owned subsidiary of Generac Power Systems, Inc.
Phone: 800-926-9768 Fax: 920-361-2214 www.m-p-llc.com Page 1 of 4
4/12
Mobile Generator – MMG175 Specifications
ENGINE
John Deere®PE6068HFG94 - turbocharged, diesel engine
oPrime - 217 hp @ 1800 rpm
oStandby - 241 hp @ 1800 rpm
o6 cylinder
o6.8 L displacement
oInterim Tier IV emissions
Steel, single wall fuel tank
o342 gal. capacity
o29 hr. run time – full load
oFuel tank built into skid of generator set
Fuel consumption at prime:
o100% - 10.9 gph (41.3 Lph)
o75% - 8.2 gph (31.0 Lph)
o50% - 5.5 gph (20.8 Lph)
Cooling system capable of operating at 120°F ambient
Low coolant shutdown
Radiator and oil drains plumbed to exterior
Rubber vibration dampers isolate engine/generator from frame
Disposable air filter - paper element
Air filter restriction indicator mounted on control panel
60 Hz engine/generator
Electronic isochronous governing
Utilizes DOC / DPF exhaust filter
Variable Geometry Turbocharger (VGT)
GENERATOR
Marathon Electric®
oBrushless
o4 pole
oClass H insulation
Voltage regulation +/- 1% with Marathon SE350 Voltage Regulator
SYSTEM OUTPUT
3 Position voltage selector switch:
oThree phase – 120 / 208V Low Wye
oThree phase – 277 / 480V High Wye
oSingle phase – 120 / 240V Zig Zag
153 kW / 191 kVA – standby, three phase
138 kW / 172 kVA – prime, three phase
125 kW / 125 kVA – standby, single phase
120 kW / 120 kVA – prime, single phase
MMG175 Generac Specifications Continued:
Manufactured by Magnum Power Products LLC., a wholly owned subsidiary of Generac Power Systems, Inc.
Phone: 800-926-9768 Fax: 920-361-2214 www.m-p-llc.com Page 2 of 4
4/12
SYSTEM CONTROLS
Microprocessor-based controller
oBacklit, 128x64 pixel resolution display
o-40°F to 185°F operating temperature range
oThermostatically controlled LCD heater
oSix LED indicators w/ lamp test
Alarm / Fault (Red)
Ready / Manual (Red)
Running (Green)
Warning (Yellow)
Ready / Auto (Green)
Supplying Load (Green)
Push buttons for easy operation
oManual or Auto Start
oEngine Start or Stop
oAlarm Cancel & Fault Reset
oScrolling Arrows for Diagnostic Information
System kW output display
Line output & frequency display
Engine diagnostic display
Oil pressure
Engine temperature
Fuel level
Battery
System hours
Running hours
kW hours
Time to service
oAlarm list – warnings / shutdowns are date & time stamped
Fuel level: warning – 15%; shutdown – 5%
Overspeed protection: shutdown – 115%
Oil pressure: warning – 25 psi; shutdown – 20 psi
Coolant temperature: warning – 220°F; shutdown – 230°F
Battery voltage: over – 15VDC; under – 11VDC
Generator over voltage: warning – 110%; shutdown – 111%
Generator under voltage: warning – 87%; shutdown – 86%
Generator over frequency: warning – 105%; shutdown – 110%
Generator under frequency: warning – 95%; shutdown – 90%
Over current shutdown
ELECTRICAL CONTROLS
Remote start / stop contacts located next to lug box
Lockable control box door with diagnostics window
Lockable lug box with safety switch
oTrips main breaker when lug door is opened
Disables voltage regulator
Cable entry guides to the lug box
oRestricts access of foreign objects
Output ground connection lug inside lug box
700A main breaker with shunt trip
MMG175 Generac Specifications Continued:
Manufactured by Magnum Power Products LLC., a wholly owned subsidiary of Generac Power Systems, Inc.
Phone: 800-926-9768 Fax: 920-361-2214 www.m-p-llc.com Page 3 of 4
4/12
Convenience receptacles with individual breakers (restricted use in high wye mode)
o(2) 120V 20 Amp GFCI duplex outlets (Nema 5-20R type)
o(3) 125 / 250V 50 Amp, 3 pole, 4 wire twistlock (Non-Nema 6369)
Panel mounted rheostat for voltage adjustment - +/- 10%
1000 CCA wet cell battery
ENCLOSURE
Generac Mobile Power decals
Aluminum, sound attenuated enclosure
oUV & fade resistant, high temperature cured, white polyester powder paint
oInsulated and baffled
o68 dB(A) at 23 feet – prime power
Fully lockable enclosure including doors and fuel fill
Stainless steel hinges on doors
Emergency stop switch located on outside of enclosure
Central lifting point
Multi-lingual operating/safety decals
Document holder with operating manual including AC/DC wiring diagrams
TRAILER
DOT approved tail, side, brake, and directional lights
oRecessed rear lights
Transportation tie downs
Safety chains with spring loaded safety hooks
3” lunette ring hitch
(2) 7000 lb. axles with surge brakes
5000 lb. tongue jack with footplate
ST235/80R16 tubeless tires – 10 ply
WEIGHTS & DIMENSIONS
Skid mounted
Dry weight: 6604 lbs (2996 kg)
Operating weight: 9032 lbs (4097 kg)
144 x 50 x 77 in
(3.66 x 1.27 x 1.96 m)
Trailer mounted
Dry weight: 8000 lbs
(3629 kg)
Operating weight: 10426 lbs (4730 kg)
210 x 86 x 93 in
(5.33 x 2.18 x 2.36 m)
WARRANTY
Engine and generator covered under OEM warranty – consult factory for details.
CERTIFICATIONS
CSA certified
MMG175 Generac Specifications Continued:
Manufactured by Magnum Power Products LLC., a wholly owned subsidiary of Generac Power Systems, Inc.
Phone: 800-926-9768 Fax: 920-361-2214 www.m-p-llc.com Page 4 of 4
4/12
MMG175 Options
ENGINE OPTIONS
In-line engine block heater (Kim Hotstart)
Fuel transfer pump
ELECTRICAL CONTROLS OPTIONS
Battery disconnect
Battery charger – 2A trickle
GENERATOR OPTIONS
PMG Generator - critical grade power quality
Super Start Generator - motor starting applications
VOLTAGE OUTPUT OPTIONS
4 position phase switch
Single phase – 120 / 240V Zig Zag
Three phase – 120 / 208V Low Wye
Three phase – 277 / 480V High Wye
Three phase – 120 / 240V Delta
Dedicated voltage configurations
Buck Transformer kit - Provides 120V at GFCI outlets when in 277/480V
Cam locks
SYSTEM CONTROLS OPTIONS
Auxiliary strobe/audible indication for soft & hard alarm conditions
COOLANT OPTIONS
60/40 Coolant - cold weather applications
ENCLOSURE OPTIONS
Fire extinguisher
Interior cabinet light
Control panel light
FUEL TANK OPTIONS
120% Containment
TRAILER OPTIONS
Tandem axle trailer w/ electric brakes
6 pin or 7 spade electrical connectors
Spare tire/wheel kit
Tabla de contenidos
Otros manuales de Generador portátil de Generac Power Systems
Generac Power Systems
Generac Power Systems GP3300 Manual de usuario
Generac Power Systems
Generac Power Systems GP7500E-5943-5 Manual de usuario
Generac Power Systems
Generac Power Systems XT8000EFI Manual de usuario
Generac Power Systems
Generac Power Systems 005942-0 Manual de usuario
Generac Power Systems
Generac Power Systems 005724-1 Manual de usuario
Generac Power Systems
Generac Power Systems GP Series Manual de usuario
Generac Power Systems
Generac Power Systems 17,500 WATT Manual de instrucciones
Generac Power Systems
Generac Power Systems 5.6 kVA PowerPact Manual de usuario
Generac Power Systems
Generac Power Systems 005789-0 Manual de usuario
Generac Power Systems
Generac Power Systems XP6500E XP SERIES Manual de usuario
Generac Power Systems
Generac Power Systems GP Series Manual de usuario
Generac Power Systems
Generac Power Systems GP Series Manual de usuario
Generac Power Systems
Generac Power Systems 10000EXL Manual de usuario
Generac Power Systems
Generac Power Systems Mobile Power MMG45FHK Manual de usuario
Generac Power Systems
Generac Power Systems 006000-0 Manual de usuario
Generac Power Systems
Generac Power Systems MLG8 Manual de usuario
Generac Power Systems
Generac Power Systems 9344-2 Manual de usuario
Generac Power Systems
Generac Power Systems MLG15 Manual de usuario
Generac Power Systems
Generac Power Systems Mobile Power MMG205 Manual de usuario
Generac Power Systems
Generac Power Systems MAGNUM MMG75D Manual de usuario
