Generac Power Systems Mobile Power MMG45FHK Manual de usuario

Manufactured by Magnum Power Products LLC., a wholly owned subsidiary of Generac Power Systems, Inc.

Phone: 800-926-9768 Fax: 920-361-2214 www.m-p-llc.com Page 1 of 5 4/12

Mobile Generator – MMG45FHK Specifications

ENGINE

Kubota®V3600-T-E3BG - turbocharged, diesel engine

oPrime - 53 hp @ 1800 rpm

oStandby - 58 hp @ 1800 rpm

o4 cylinder

o3.6 L displacement

oInterim Tier IV approved

Steel, single wall fuel tank

o106 gal. capacity

o31 hr. run time – full load

oFuel tank built into skid of generator set

Fuel consumption at prime:

o100% - 3.0 gph (11.4 Lph)

o75% - 2.3 gph (8.7 Lph)

o50% - 1.5 gph (5.7 Lph)

Cooling system capable of operating at 120°F ambient

Low coolant shutdown

Radiator and oil drains plumbed to exterior

Rubber vibration dampers isolate engine/generator from frame

Disposable air filter - paper element

Air filter restriction indicator mounted on control panel

60 Hz engine/generator

Electronic isochronous governing

GENERATOR

Marathon Electric®

oBrushless

o4 pole

oClass H insulation

Voltage regulation +/- 1% with Marathon SE350 Voltage Regulator

SYSTEM OUTPUT

3 position selector switch

oSingle phase – 120 / 240V Zig Zag

oThree phase – 120 / 208V Low Wye

oThree phase – 277 / 480V High Wye

33 kW / 33 kVA – standby, single phase

30 kW / 30 kVA – prime, single phase

35 kW / 44 kVA – standby, three phase

33 kW / 41 kVA – prime, three phase

SYSTEM CONTROLS

Microprocessor-based controller

oBacklit, 128x64 pixel resolution display

o-40°F to 185°F operating temperature range

oThermostatically controlled LCD heater

www m-p-llc com

Trailer Sold Separately

MG45FHK Generac Specifications Continued:

Manufactured by Magnum Power ProductsLLC., a wholly owned subsidiary of Generac Power Systems, Inc.

Phone: 800-926-9768 Fax: 920-361-2214 www.m-p-llc.com Page 2 of 5

4/12

oSix LED indicators w/ lamp test

Alarm / Fault (Red)

Ready / Manual (Red)

Running (Green)

Warning (Yellow)

Ready / Auto (Green)

Supplying Load (Green)

Push buttons for easy operation

oManual or Auto Start

oEngine Start or Stop

oAlarm Cancel & Fault Reset

oScrolling Arrows for Diagnostic Information

System kW output display

Line output & frequency display

Engine diagnostic display

Oil pressure

Engine temperature

Fuel level

Battery

System hours

Running hours

kW hours

Time to service

oAlarm list – warnings / shutdowns are date & time stamped

Fuel level: warning – 15%; shutdown – 5%

Overspeed protection: shutdown – 115%

Oil pressure: warning – 25 psi; shutdown – 20 psi

Coolant temperature: warning – 220°F; shutdown – 230°F

Battery voltage: over – 15VDC; under – 11VDC

Generator over voltage: warning – 110%; shutdown – 111%

Generator under voltage: warning – 87%; shutdown – 86%

Generator over frequency: warning – 105%; shutdown – 110%

Generator under frequency: warning – 95%; shutdown – 90%

Over current shutdown

ELECTRICAL CONTROLS

Remote start / stop contacts located next to lug box

Lockable control box door with diagnostics window

Lockable lug box with safety switch

oTrips main breaker when lug door is opened

oDisables voltage regulator

Cable entry guides to the lug box

oRestricts access of foreign objects

Output ground connection lug inside lug box

200A main breaker with shunt trip

Convenience receptacles with individual breakers (restricted use in high wye mode)

o(2) 120V 20 Amp GFCI duplex outlets (Nema 5-20R type)

o(2) 125 / 250V 50 Amp, 3 pole, 4 wire twistlock (Non-Nema 6369)

Panel mounted rheostat for voltage adjustment - +/- 10%

MG45FHK Generac Specifications Continued:

Manufactured by Magnum Power ProductsLLC., a wholly owned subsidiary of Generac Power Systems, Inc.

Phone: 800-926-9768 Fax: 920-361-2214 www.m-p-llc.com Page 3 of 5

4/12

720 CCA wet cell battery

ENCLOSURE

Generac Mobile Power decals

“Flip-Hood” Patented design - aluminum, sound attenuated enclosure

oEasy access for daily maintenance

oCentralized location for all electrical connections/wiring

oUV & fade resistant, high temperature cured, white polyester powder paint

oInsulated and baffled

o68 dB(A) at 23 feet – prime power

Fully lockable enclosure including doors and fuel fill

Stainless steel hinges on doors

Emergency stop switch located on outside of enclosure

Central lifting point

Multi-lingual operating/safety decals

Document holder with operating manual including AC/DC wiring diagrams

TRAILER

“Flip-Tongue” design

DOT approved tail, side, brake, and directional lights

oRecessed rear lights

Transportation tie downs

Safety chains with spring loaded safety hooks

2” ball hitch

5000 lb. axle with surge brakes

3000 lb. tongue jack with footplate

P205/75R15 tubeless tires – 8 ply

WEIGHTS & DIMENSIONS

Skid mounted

Dry weight: 2329 lbs (1056 kg)

Operating weight: 3082 lbs (1398 kg)

95 x 35 x 52 in

(2.41 x 0.89 x 1.32 m)

Trailer mounted

Dry weight: 2853 lbs

(1294 kg)

Operating weight: 3606 lbs

(1636 kg)

150 x 57 x 67 in

(3.81 x 1.45 x 1.70 m)

WARRANTY

Engine and generator covered under OEM warranty – consult factory for details.

CERTIFICATIONS

CSA certified

MG45FHK Generac Specifications Continued:

Manufactured by Magnum Power ProductsLLC., a wholly owned subsidiary of Generac Power Systems, Inc.

Phone: 800-926-9768 Fax: 920-361-2214 www.m-p-llc.com Page 4 of 5

4/12

MMG45FHK Options

ENGINE OPTIONS

In-line engine block heater (Kim Hotstart)

Fuel transfer pump

ELECTRICAL CONTROLS OPTIONS

720 CCA gel cell battery

Battery disconnect

Battery charger – 2A trickle

GENERATOR OPTIONS

PMG Generator - critical grade power quality

Super Start Generator - motor starting applications

VOLTAGE OUTPUT OPTIONS

4 position phase switch

Single phase – 120 / 240V High Wye

Three phase – 120 / 208V Low Wye

Three phase – 277 / 480V Zig Zag

Three phase – 120 / 240V Delta

Dedicated voltage configurations

Buck Transformer kit – Provides 120V at GFCI outlets when in 277/480V

Cam locks

SYSTEM CONTROLS OPTIONS

Analog gauges

Auxiliary strobe/audible indication for soft & hard alarm conditions

COOLANT OPTIONS

60/40 Coolant - cold weather applications

ENCLOSURE OPTIONS

Fire extinguisher

Interior cabinet light

Control panel light

FUEL TANK OPTIONS

36 hr. single wall fuel tank (requires tandem axle trailer)

29 hr. double wall fuel tank

120% Containment

MG45FHK Generac Specifications Continued:

Manufactured by Magnum Power ProductsLLC., a wholly owned subsidiary of Generac Power Systems, Inc.

Phone: 800-926-9768 Fax: 920-361-2214 www.m-p-llc.com Page 5 of 5

4/12

TRAILER OPTIONS

Single axle trailer w/ electric brakes

Tandem axle trailer w/ surge brakes

Tandem axle trailer w/ electric brakes

6 pin or 7 spade electrical connectors

Spare tire/wheel kit

HITCH OPTIONS

3” lunette ring

2 5/16” ball

Adjustable height options:

2” ball

2 5/16” ball

Tabla de contenidos

Otros manuales de Generador portátil de Generac Power Systems

Generac Power Systems

Generac Power Systems 04389-0 Instrucciones de instalación

Generac Power Systems

Generac Power Systems GUARDIAN 04079-2 Manual de instalación

Generac Power Systems

Generac Power Systems D2.5L G2 Extended Tank Hoja de instrucciones

Generac Power Systems

Generac Power Systems 005796-0 (XG6500) Manual de usuario

Generac Power Systems

Generac Power Systems GP1800 Manual de usuario

Generac Power Systems

Generac Power Systems SG400 Manual de usuario

Generac Power Systems

Generac Power Systems IX 800 Manual de usuario

Generac Power Systems

Generac Power Systems NP Series Manual de usuario

Generac Power Systems

Generac Power Systems PowerDial RS8000E Manual de usuario

Generac Power Systems

Generac Power Systems 7 kW NG Hoja de instrucciones

Generac Power Systems

Generac Power Systems QT Series Manual de usuario

Generac Power Systems

Generac Power Systems 7000exl Manual de usuario

Generac Power Systems

Generac Power Systems 005778-0 Manual de usuario

Generac Power Systems

Generac Power Systems 7 kW NG Hoja de instrucciones

Generac Power Systems

Generac Power Systems XP Series Manual de usuario

Generac Power Systems

Generac Power Systems GP Series Manual de usuario

Generac Power Systems

Generac Power Systems ecoGen G0061030 Hoja de instrucciones

Generac Power Systems

Generac Power Systems IX1600 Manual de usuario

Generac Power Systems

Generac Power Systems Guardian 00907-2 Manual de usuario

Generac Power Systems

Generac Power Systems 9801-7 Manual de usuario

Generac Power Systems

Generac Power Systems G0059395 Manual de usuario

Generac Power Systems

Generac Power Systems Guardian ULTRA SOURCE 004583-0 Manual de usuario

Generac Power Systems

Generac Power Systems 8 - 20kW Air-cooled Automatic Standby... Manual de usuario

Generac Power Systems

Generac Power Systems 4451 & 4986 Instrucciones de funcionamiento

Manuales populares de Generador portátil de otras marcas

Kohler

Kohler 20EORZ Manual de instrucciones

Powerhorse

Powerhorse 83171 Manual de usuario

HURST

HURST ML-630-SI Manual de usuario

ETQ

ETQ TG4000 Manual de usuario

Briggs & Stratton

Briggs & Stratton 40265 Guía de configuración

ConMed

ConMed 7550 Manual de usuario

Owon

Owon Waveform Generator Manual de usuario

evertz

evertz 7700 Series Manual de usuario

Power Stroke

Power Stroke PS906025 Manual de usuario

Firefly

Firefly Cygnus CYG2400/460/24 Manual de usuario

Draper

Draper PG950S Actualización de firmware

PowerBoss

PowerBoss PowerBoss Manual de usuario

SDMO

SDMO SH 4000 Manual de usuario

EINHELL

EINHELL STE 5500 Manual de usuario

Wanco

Wanco WI3000P Manual de usuario

Full Boar

Full Boar FBT-3300 Manual de usuario

Dwyer Instruments

Dwyer Instruments ASG Manual de usuario

Westinghouse

Westinghouse WH1000i Series Manual de usuario