Generac Power Systems Mobile Power MMG465 Manual de usuario

Manufactured by Magnum Power Products LLC., a wholly owned subsidiary of Generac Power Systems, Inc.

Phone: 800-926-9768 Fax: 920-361-2214 www.m-p-llc.com Page 1 of 4

4/12

Mobile Generator – MMG465 Specifications

ENGINE

John Deere®RG6135HF485 - turbocharged, diesel engine

oStandby - 617 hp @ 1800 rpm

oPrime – 561 hp @ 1800 RPM

o6 cylinder

o13.5 L displacement

oTier III approved

Steel, single wall fuel tank

o616 gal. capacity

o29 hr. run time – full load

oFuel tank built into skid of generator set

Fuel consumption at prime:

o100% - 26.3 gph (99.6 Lph)

o75% - 19.5 gph (73.8 Lph)

o50% - 13.5 gph (51.1 Lph)

Cooling system capable of operating at 120°F ambient

Low coolant shutdown

Radiator and oil drains plumbed to exterior

Rubber vibration dampers isolate engine/generator from frame

In-line engine block heater

Disposable air filter - paper element

Air filter restriction indicator mounted on control panel

60 Hz engine/generator

Electronic isochronous governing

GENERATOR

Marathon Electric®

oBrushless

oPMG Generator - critical grade power quality

o4 pole

oClass H insulation

Voltage regulation +/- 1% with Marathon PM300 Voltage Regulator

SYSTEM OUTPUT

Link / Reconnect Board:

oThree phase – 120 / 208V Low Wye

oThree phase – 277 / 480V High Wye

408 kW / 510 kVA – standby, three phase

373 kW / 466 kVA – prime, three phase

MMG465 Generac Specifications Continued:

Manufactured by Magnum Power Products LLC., a wholly owned subsidiary of Generac Power Systems, Inc.

Phone: 800-926-9768 Fax: 920-361-2214 www.m-p-llc.com Page 2 of 4

4/12

SYSTEM CONTROLS

Microprocessor-based controller

oBacklit, 128x64 pixel resolution display

o-40°F to 185°F operating temperature range

oThermostatically controlled LCD heater

oSix LED indicators w/ lamp test

Alarm / Fault (Red)

Ready / Manual (Red)

Running (Green)

Warning (Yellow)

Ready / Auto (Green)

Supplying Load (Green)

Push buttons for easy operation

oManual or Auto Start

oEngine Start or Stop

oAlarm Cancel & Fault Reset

oScrolling Arrows for Diagnostic Information

System kW output display

Line output & frequency display

Engine diagnostic display

Oil pressure

Engine temperature

Fuel level

Battery

System hours

Running hours

kW hours

Time to service

oAlarm list – warnings / shutdowns are date & time stamped

Fuel level: warning – 15%; shutdown – 5%

Overspeed protection: shutdown – 115%

Oil pressure: warning – 25 psi; shutdown – 20 psi

Coolant temperature: warning – 220°F; shutdown – 230°F

Battery voltage: over – 15VDC; under – 11VDC

Generator over voltage: warning – 110%; shutdown – 111%

Generator under voltage: warning – 87%; shutdown – 86%

Generator over frequency: warning – 105%; shutdown – 110%

Generator under frequency: warning – 95%; shutdown – 90%

Over current shutdown

ELECTRICAL CONTROLS

Remote start / stop contacts located next to lug box

Lockable control box door with diagnostics window

Lockable lug box with safety switch

oTrips main breaker when lug door is opened

oDisables voltage regulator

Cable entry guides to the lug box

oRestricts access of foreign objects

Output ground connection lug inside lug box

1600A main breaker with shunt trip

Convenience receptacles with individual breakers (restricted use in high wye mode)

MMG465 Generac Specifications Continued:

Manufactured by Magnum Power Products LLC., a wholly owned subsidiary of Generac Power Systems, Inc.

Phone: 800-926-9768 Fax: 920-361-2214 www.m-p-llc.com Page 3 of 4

4/12

o(2) 120V 20 Amp GFCI duplex outlets (Nema 5-20R type)

o(3) 125 / 250V 50 Amp, 3 pole, 4 wire twistlock (Non-Nema 6369)

oBuck Transformer kit – Provides 120V at GFCI outlets when in 277/480V

Panel mounted rheostat for voltage adjustment - +/- 10%

(2) 1000 CCA wet cell batteries

oBattery disconnect switch

o2A trickle battery charger

ENCLOSURE

Generac Mobile Power decals

Aluminum, sound attenuated enclosure

oUV & fade resistant, high temperature cured, white polyester powder paint

oInsulated and baffled; 120 % containment

o68 dB(A) at 23 feet – prime power

Fully lockable enclosure including doors and fuel fill

Stainless steel hinges on doors

Emergency stop switch located on outside of enclosure

Central lifting point

Multi-lingual operating/safety decals

Document holder with operating manual including AC/DC wiring diagrams

TRAILER

DOT approved tail, side, brake, and directional lights

oRecessed rear lights

Transportation tie downs

Safety chains with spring loaded safety hooks

3” lunette ring hitch

(3) 8000 lb. axles with electric brakes

15000 lb. tongue jack with footplate

ST215/75R17.5 tubeless tires – 16 ply

WEIGHTS & DIMENSIONS

Skid mounted

Dry weight: 12750 lbs (5783 kg)

Operating weight: 17124 lbs (7767 kg)

175 x 60 x 96 in

(4.45 x 1.52 x 2.44 m)

Trailer mounted

Dry weight: 16000 lbs

(7257 kg)

Operating weight: 20374 lbs (9241 kg)

250 x 102 x 116 in

(6.35 x 2.59 x 2.95 m)

WARRANTY

Engine and generator covered under OEM warranty – consult factory for details.

CERTIFICATIONS

CSA certified

MMG465 Generac Specifications Continued:

Manufactured by Magnum Power Products LLC., a wholly owned subsidiary of Generac Power Systems, Inc.

Phone: 800-926-9768 Fax: 920-361-2214 www.m-p-llc.com Page 4 of 4

4/12

MMG465 Options

VOLTAGE OUTPUT OPTIONS

Dedicated voltage configurations

Cam locks

SYSTEM CONTROLS OPTIONS

Auxiliary strobe/audible indication for soft & hard alarm conditions

COOLANT OPTIONS

60/40 Coolant - cold weather applications

ENCLOSURE OPTIONS

Fire extinguisher

Interior cabinet light

Control panel light

FUEL TANK OPTIONS

Fuel transfer pump

TRAILER OPTIONS

6 pin or 7 spade electrical connectors

Spare tire/wheel kit

HITCH OPTIONS

Adjustable height - 3” lunette ring

Tabla de contenidos

Otros manuales de Generador portátil de Generac Power Systems

Generac Power Systems

Generac Power Systems XP4000 Professional Manual de usuario

Generac Power Systems

Generac Power Systems GP6500 Manual de usuario

Generac Power Systems

Generac Power Systems iX 2000 Manual de usuario

Generac Power Systems

Generac Power Systems 005788-0 XG4000 Manual de usuario

Generac Power Systems

Generac Power Systems Magnum MTT25 Manual de usuario

Generac Power Systems

Generac Power Systems 006000-0 Manual de usuario

Generac Power Systems

Generac Power Systems 005942-0 Manual de usuario

Generac Power Systems

Generac Power Systems XT8000EFI Manual de usuario

Generac Power Systems

Generac Power Systems PWRgenerator 9 kW Manual de usuario

Generac Power Systems

Generac Power Systems 10 kW LP Manual de usuario

Generac Power Systems

Generac Power Systems GH-410 Hoja de instrucciones

Generac Power Systems

Generac Power Systems G0071450 Manual de usuario

Generac Power Systems

Generac Power Systems G1000M Manual de usuario

Generac Power Systems

Generac Power Systems GP5500 Manual de usuario

Generac Power Systems

Generac Power Systems Automatic Standby Generators Manual de usuario

Generac Power Systems

Generac Power Systems 005622-1 Manual de usuario

Generac Power Systems

Generac Power Systems 005796-0 (XG6500) Manual de usuario

Generac Power Systems

Generac Power Systems RS5500 Manual de usuario

Generac Power Systems

Generac Power Systems G0062540 Hoja de instrucciones

Generac Power Systems

Generac Power Systems 009600-4 Manual de usuario

Generac Power Systems

Generac Power Systems 005802-2 XG Professional Series Manual de usuario

Generac Power Systems

Generac Power Systems Portable Generator Manual de servicio

Generac Power Systems

Generac Power Systems GP Series Manual de usuario

Generac Power Systems

Generac Power Systems A4021 Manual de usuario

Manuales populares de Generador portátil de otras marcas

Kohler

Kohler 20EORZ Manual de instrucciones

Powerhorse

Powerhorse 83171 Manual de usuario

HURST

HURST ML-630-SI Manual de usuario

ETQ

ETQ TG4000 Manual de usuario

Briggs & Stratton

Briggs & Stratton 40265 Guía de configuración

ConMed

ConMed 7550 Manual de usuario

Owon

Owon Waveform Generator Manual de usuario

evertz

evertz 7700 Series Manual de usuario

Power Stroke

Power Stroke PS906025 Manual de usuario

Firefly

Firefly Cygnus CYG2400/460/24 Manual de usuario

Draper

Draper PG950S Actualización de firmware

PowerBoss

PowerBoss PowerBoss Manual de usuario

SDMO

SDMO SH 4000 Manual de usuario

EINHELL

EINHELL STE 5500 Manual de usuario

Wanco

Wanco WI3000P Manual de usuario

Full Boar

Full Boar FBT-3300 Manual de usuario

Dwyer Instruments

Dwyer Instruments ASG Manual de usuario

Westinghouse

Westinghouse WH1000i Series Manual de usuario