Franke HWTE100 Manual de usuario

Installation and operating instructions Montażi instrukcja obsługi

Notice de montage et de mise en service

ZMI_001_2000101341-HWTE100_#SALL_#AQU_#V2.fm / 13.08.15

Franke Aquarotter GmbH, Germany

EA-Nr.: 7612982145933

FAR-Best.-Nr.: 2000101341

HWTE100

EA-Nr.: 7612982145964

FAR-Best.-Nr.: 2000105304

EA-Nr.: 7612982226816

FAR-Best.-Nr.: 2030026545

Inhaltsverzeichnis09.fm

...................................................................................3

Please refer to the graphics in the German Installation and

Operating Instructions.

...................................................................................9

Les graphiques sont disponibles dans la notice de montage et

de mise en service allemande.

...................................................................................16

Prosimy przyjąć grafikęz niemieckiej instrukcji montażu i

obsługi.

ZMI_001_2000101341-HWTE100_#SEN_#AQU_#V2.fm

0English

2000101341 ............... Awith soap dispenser and disinfectant dispenser

2000105304

2030026545 ............... Awith soap dispenser and disinfectant dispenser,

with follow-up time 3 s

Please refer to the graphics in the German Installation and Operating Instructions.

0Table of Contents

1. Abbreviations and Units . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

2. Key . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

3. Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

4. Important Notes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

Description of Product

5. Application . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

6. Technical Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

7. Scope of Delivery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

8. Dimensions. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

9. Installation Example . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

Installation, Function and Commissioning

10. Assembly Instructions. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

11. Function . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

12. Adjusting the Flow Duration . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

13. Setting the Range. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

Maintenance

14. Maintenance and Servicing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

15. Replacing the Flow Rate Regulator . . . . . . . . . . . . . . . . . . . . . . . 7

16. Replacing an Aerator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

17. Fault Correction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

18. Replacement Parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

ZMI_001_2000101341-HWTE100_#SEN_#AQU_#V2.fm

1. Abbreviations and Units

2. Key

Warning!

Failure to observe can result in injury or even death.

Caution!

Failure to observe can result in material damage.

☞Important!

Failure to observe can cause the product to malfunction.

☞Useful information for optimally handling the product.

3. Warranty

Liability is accepted according to the General Terms and Conditions of Business and

Supply.

Use original replacement parts only!

4. Important Notes

• Installation, commissioning and maintenance are to be performed only by a

qualified technician according to legal regulations provided.

• All technical connection regulations specified by the local water and electricity

supply utility companies must be complied with.

• The installation is to be performed in compliance with local conditions, relevant

regulations (e.g.: VDE 0100), nationally applicable accident prevention

regulations (e.g.: VBG 4) and the acknowledged rules of technology.

• All work must be carried out in a de-energised state.

DN Nominal diameter in mm

RCD Residual Current Protective Device,

Earth leakage circuit breaker

EA-Nr. European Article Number

FAR-Best.-Nr. Franke Aquarotter Order Number

Conversion 1 mm = 0.03937 inches

1 inch = 25.4 mm

All length specifications in the graphics are in mm.

ZMI_001_2000101341-HWTE100_#SEN_#AQU_#V2.fm

5. Application

Hygiene washing unit for wall-mounting, for connecting to warm water or cold water,

electrical and water connections located at the bottom. Premounted ready-for-

connection, for concealed mounting from the front.

6. Technical Specifications

7. Scope of Delivery

Completely pre-mounted

8. Dimensions

9. Installation Example

10. Assembly Instructions

Warning!

• Secure the electric connection with an earth leakage circuit breaker (RCD) for a

maximum nominal fault current of 30 mA.

Failure to observe can mean risk of death or material damage, e. g. from electric

shock or fire.

☞Important!

Before installing, flush the pipes in compliance with DIN 1988.

☞To protect the tiles, use masking tape when marking and drilling. Drill at low speed.

☞Depending on the composition of the wall, special wall dowels may have to be used

(to be provided by the customer).

10.1

Mark the boreholes for the hook-in strip according to the dimensions.

10.2

Drill according to the markings.

10.3

Insert the dowels.

Minimum flow pressure: 1.0 bar

Recommended flow pressure: 1–5 bar

Maximum operating pressure: 10 bar

Calculation flow rate: 0,07 l/s 0,07 l/s

Supply voltage: 230 V AC

Power consumption: 3 W

Type of protection: Electronic IP 68, solenoid valve IP 40

ZMI_001_2000101341-HWTE100_#SEN_#AQU_#V2.fm

10.4

Screw on the hook-in strip.

10.5

Before mounting the hygiene washbasin, open the inspection opening.

10.6

Hook in the hygiene washbasin.

10.7

Mark the other drill holes.

10.8

Remove the hygiene washbasin.

10.9

Drill according to the markings.

10.10

Insert the dowels.

10.11

Pull the protective film off from the housing.

10.12

Seal the housing with e.g. Chromol (not included, see chapter 18., accessories).

10.13

Hook in the hygiene washbasin.

10.14

Screw on the hygiene washbasin.

10.15

Close the inspection opening.

10.16

Install the connection hoses (to be provided by the client).

10.17

Install the odour trap (to be provided by the client).

10.18

Connect the power supply to 230 V AC.

10.19

Check the water connections for leaks.

11. Function

11.1

Allow your hand to approach sensor (b) on the washbasin.

• Water flows out of the outlet (a).

11.2

Allow your hand to approach the sensor (b) on the washbasin.

• Water flow stops automatically after 3 s.

11.3

Press the elbow lever (c) downwards.

• Soap flows.

• Soap flow stops automatically.

11.4

Press the elbow lever (d) downwards.

• Disinfectant flows.

• Disinfectant flow stops automatically.

12. Adjusting the Flow Duration

Flow duration can be adjusted only with a ECC2 function controller via the Web

application

ZMI_001_2000101341-HWTE100_#SEN_#AQU_#V2.fm

13. Setting the Range

Flow range can be adjusted only with an ECC2 function controller via the Web

application.

14. Maintenance and Servicing

Depending on the quality of the water, the local conditions and the rules and

regulations applicable on site, the fitting must be maintained and serviced at regular

intervals.

Properly use suitable cleaning agents that are not harmful to the fittings and rinse

with water after use. High-pressure cleaners must not be used for cleaning.

Follow the cleaning instructions for stainless steel.

15. Replacing the Flow Rate Regulator

15.1

Loosen the grub screw in the outlet using an Allen key.

15.2

Pull the wall arm with the head piece from the connection spigot.

15.3

Remove the safety ring with the appropriate pliers for the inner safety rings.

15.4

Pull out the flow rate controller with flat nose pliers.

☞Important!

Ensure correct installation orientation of the flow rate regulator. The brace must face

in the direction of the outlet.

15.5

Insert the flow rate regulator and secure with the circlip.

a: Brace

b: Flow direction

15.6

Slide the wall arm with the head piece onto the connection spigot.

15.7

Tighten the grub screw using a hollow hexagon wrench.

16. Replacing an Aerator

16.1

Use the special tool (e) to loosen the complete aerator.

16.2

Remove the complete aerator from the head piece (a).

16.3

Remove the seal (b).

16.4

Remove the sleeve (c).

16.5

Replace the aerator (d).

16.6

Reassemble in the reverse order.

ZMI_001_2000101341-HWTE100_#SEN_#AQU_#V2.fm

17. Fault Correction

If you are unable to correct a fault or if the fault is not described in the fault correction

section, please inform our customer service department!

18. Replacement Parts

Fault Cause Remedy

Water does not flow – Voltage supply interrupted ➯Restore it

– Water supply closed ➯Open it

– Sensor module faulty ➯Replace it

Flow duration too

short or too long

– Flow duration setting incorrect ➯Adjust it

Water flow too weak – Water inflow not fully opened ➯Open it

– Grit filter is clogged ➯Clean it

– Supply pressure too low ➯Check it

Water is too cold – Hot water is turned off ➯Open it

– Grit filter is clogged ➯Replace it

– Hot water supply pressure too low ➯Check it

– Hot water temperature too low ➯Increase it

Designation Order No.

1 Solenoid valve 24V . . . . . . . . . . . . 2000101328

2 Aerator with special tool. . . . . . . . . 2000105959

3 Head piece, complete

with aerator. . . . . . . . . . . . . . . . 2000105485

4 Shower bracket 165 mm . . . . . . . . 2000109150

5 Flow rate regulator (VPE 10 St.)

0,10 l/s . . . . . . . . . . . . . . . . . . . 2000104701

6 Installation kit comprising:

O-rings

Grub screws . . . . . . . . . . . . . . .2000104797

7 Sensor module 2

without mount . . . . . . . . . . . . . . 85-100-17.116

Accessories Order No.

8 Power supply (12 W) . . . . . . . . . . .2000100375

CHROMOL 0.5 l stainless steel

polish . . . . . . . . . . . . . . . . . . . .2000105091

Complete stainless steel care set

CHROMOL 0.5 l

Abrasive sponge, coarse

Abrasive sponge, fine . . . . . . . .2000109019

*) When placing an order, please specify the fittings-ID!

The fittings-ID is located on the side of the electronic

module.

ZMI_001_2000101341-HWTE100_#SFR_#AQU_#V2.fm

0Français

2000101341 ............... avec un savon désinfectant et distributeur

2000105304

2030026545 ............... avec un savon désinfectant et distributeur,

avec la période de suivi de 3 s

Les graphiques sont disponibles dans la notice de montage et de mise en service

allemande.

0Table des matières

1. Abréviations et unités . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10

2. Explication des symboles . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10

3. Garantie . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10

4. Remarques importantes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11

Description du produit

5. Application . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11

6. Données techniques. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11

7. Contenu de la livraison . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11

8. Dimensions. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11

9. Exemple d’installation. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12

Montage, fonctionnement et mise en service

10. Montage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12

11. Fonctionnement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13

12. Réglage de la durée d’écoulement. . . . . . . . . . . . . . . . . . . . . . . . 13

13. Réglage de la portée . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13

Entretien

14. Maintenance et entretien . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13

15. Remplacement du régulateur de débit . . . . . . . . . . . . . . . . . . . . . 14

16. Remplacement de l’embout d’arrosage . . . . . . . . . . . . . . . . . . . . 14

17. Élimination de pannes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15

18. Pièces de rechange . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15

ZMI_001_2000101341-HWTE100_#SFR_#AQU_#V2.fm

1. Abréviations et unités

2. Explication des symboles

Avertissement!

Le non-respect des consignes est susceptible d'induire un danger de mort ou de

provoquer des blessures corporelles.

Attention!

Le non-respect des consignes est susceptible de provoquer des dommages

matériels.

☞Important!

Le non-respect des consignes est susceptible de provoquer des

dysfonctionnements du produit.

☞Informations utiles pour une utilisation optimale du produit.

3. Garantie

La responsabilité est assumée conformément aux conditions générales de vente et

de livraison.

Utiliser uniquement des pièces de rechange d’origine!

DN Diamètre nominal en mm

RCD Residual Current Protective Device,

Interrupteur de protection contre les courants de

court-circuit

EA-Nr. Numéro d’article européen

FAR-Best.-Nr. Numéro de commande Franke Aquarotter

Conversion 1 mm = 0,03937 pouce

1 pouce = 25,4 mm

Dans les graphiques, toutes les longueurs sont indiquées en mm.

Otros manuales para HWTE100

Este manual sirve para los siguientes modelos

Tabla de contenidos

Idiomas:

Otros manuales de Producto de plomería de Franke

Franke

Franke F5LT2018 Manual de usuario

Franke

Franke PF-1000 Series Manual de usuario

Franke

Franke EXOS616EX Manual de usuario

Franke

Franke AQUA 555 Manual de usuario

Franke

Franke AQUA741 Manual de usuario

Franke

Franke AT3O0051 Manual de usuario

Franke

Franke CMPX532WF Manual de usuario

Franke

Franke MIRANIT F5ET2026 Manual de usuario

Franke

Franke F5LT2021 2030066510 Manual de usuario

Franke

Franke RODX627H Manual de usuario

Franke

Franke F3 Series Guía del usuario

Franke

Franke SIRIUS SIRW771 Manual de usuario

Franke

Franke 2000108750 Manual de usuario

Franke

Franke KEP ACSL Series Manual de usuario

Franke

Franke HWF05 Manual de usuario

Franke

Franke HDTX0013 Manual de usuario

Franke

Franke F5 Series Manual de usuario

Franke

Franke F5EV1013 Manual de usuario

Franke

Franke F5SV1001 Manual de usuario

Franke

Franke CHILLOUT FF4900 Manual de usuario

Franke

Franke 2030027995 Manual de usuario

Franke

Franke AQMXS0003 Manual de usuario

Franke

Franke FFP 1100 Series Manual de usuario

Franke

Franke F5SM1011 Manual de usuario

Manuales populares de Producto de plomería de otras marcas

Weka

Weka 506.2020.00E Instrucciones de funcionamiento

Kohler

Kohler K-6228 Instrucciones de montaje

UBERHAUS DESIGN

UBERHAUS DESIGN 75175017 Manual de usuario

American Standard

American Standard DetectLink 6072121 Manual de usuario

Uponor

Uponor Contec TS Manual de usuario

Pfister

Pfister Selia 49-SL Manual de usuario

Fortis

Fortis VITRINA 6068700 Manual de usuario

Fortis

Fortis MILANO 78211JS Manual de usuario

Kohler

Kohler K-12183 Instrucciones de montaje

Maxxus

Maxxus MX-M206-01 Manual de usuario

Moen

Moen 5922 Series Manual de usuario

Viega

Viega Prevista Pure 8512 Manual de usuario

Kohler

Kohler Centerset K-15240 Instrucciones de montaje

Viega

Viega Prevista Dry 8522.33 Manual de usuario

Sanela

Sanela Lema SLP 59RB Manual de usuario

Elkay

Elkay EDF15AC Manual de instalación

Hans Grohe

Hans Grohe AXOR Citterio E 36702000 Manual

baliv

baliv WT-140 Manual de usuario