FlowLine 52 Series Manual de usuario

IOM Manual

Series 52

Proximity Reed Switch

IOM Manual

www.flowlinevalves.com

Flow Line Valve and Controls, L.L.C.

110 Main Project Road Schriever, LA 70395

P.O. Box 677 Schriever, LA 70395

Phone 985-414-6004 * Toll Free 800-815-9226 * Fax 985-414-6072

www.flowlinevalves.com

Installation and Operations Manual Series 52

Installation

1. Attach proper mounting bracket to the switchbox housing

2. Engage switch box shaft to top of actuator shaft.

3. Attach bracket to actuator (finger tight only).

4. Cycle the actuator; switchbox and actuator will self-align.

5. Tighten bracket to actuator.

Adjusting the switches

Figure 1 CLOCKWISE (VALVE CLOSED)

1. Disconnect power prior to opening lid.

2. Loosen switchbox cover screws and remove cover.

3. Rotate actuator to full clockwise position.

4. Push down top cam and turn it clockwise until switch is activated. Release the cam and it will engage on the splined

retainer. The spring will maintain cam engagement.

Figure 2 COUNTER (VALVE OPEN)

1. Rotate actuator to full counter-clockwise position.

2. Pull up bottom cam and turn it counter-clockwise until switch is activated. Release the cam and it will engage on the

splined retainer. The spring will maintain cam engagement.

3. Cycle actuator several times to verify adjustment.

4. Place the cover on switch box and tighten in cross pattern. Note: ensure that the cover’s o-ring seal is seated in the

o-ring groove.

Doc # 52PRSIOM21715

Electrical Wiring

1. Remove switch box cover.

2. Remove protection plug(s) from conduit entries and install conduit or other approved connection means.

3. Engage wires in terminal strip using a small screwdriver (1/2” blade). Note: terminals 1, 2, & 3 are for the top

switch and terminals 4, 5, & 6 are for the bottom switch. Wiring Diagram is on the inside of the switchbox cover.

Warning:

To maintain IP67 weather protection, any unused conduit entry must be closed with

appropriate conduit plug. Conduit plugs supplied with the switch box are for transit purposes

only.

3-D Visual Indicator Setting

1. Rotate actuator to closed.

2. Loosen the four screws securing the plastic indicator dome and rotate it to show ‘CLOSED’. Note: the dome and

rotor can be removed and rotated ¼ turn for OPEN-CLOSE visual indication from the end switchbox.

SPST Proximity Switch Specifications

•Type: Dry contact reed switch

•Contacts: Form-A

•Maximum switching power: 2.0 A

•Maximum switching current: 3.0 A

•Maximum switching voltage: 400 VDC / 400 VAC

•Initial contact resistance: 0.080 Ohms

•Maximum operating time: 2.5 msec

•Operating temperature range: -40C to +125C

•Approvals: UL and CSA Recognized Component

SPDT Proximity Switch Specifications

•Type: Dry contact reed switch

•Contacts: Form-C

•Maximum switching power: 20W

•Maximum switching current: 1.0 A

•Maximum carrying current: 2.0 A

•Maximum switching voltage: 150 VDC / 150 VAC

•Initial contact resistance: 0.100 Ohms

•Maximum operating time: 2.0 msec

•Operating temperature range: -40C to +125C

•Approvals: UL and CSA Recognized Component

CAUTION:

Reed Proximity switches sense magnetic fields and may accidentally trip if magnets are within 1/2” from

the sensing surface.

Page 2 of 2

Doc # 52PRSIOM21715

Tabla de contenidos

Otros manuales de Cambiar de FlowLine

FlowLine

FlowLine Switch-Tek LZ12 Series Manual de usuario

FlowLine

FlowLine LV42 Series Instrucciones de instalación y funcionamiento

FlowLine

FlowLine Thermo-Flo FT10 Manual de usuario

FlowLine

FlowLine EchoSwitch LU74 Series Manual de usuario

FlowLine

FlowLine EchoSwitch LU74-5004 Manual de usuario

FlowLine

FlowLine Switch-Tek LV20-1201 Manual de usuario

FlowLine

FlowLine Switch-Tek LV10-1301 Manual de usuario

FlowLine

FlowLine Switch-Tek LZ12 Series Manual de usuario

FlowLine

FlowLine EchoSwitch LU77 Series Manual de usuario

FlowLine

FlowLine 53 Series Manual de usuario

FlowLine

FlowLine EchoSwitch LU78 Series Manual de usuario

FlowLine

FlowLine LP10 Series Manual de usuario

FlowLine

FlowLine EchoSwitch LU71 Manual de usuario

FlowLine

FlowLine Thermo-Flow FT10-1305 Manual de usuario

FlowLine

FlowLine LV10 Series Manual de usuario

FlowLine

FlowLine LP50 Series Manual de usuario

FlowLine

FlowLine Switch-Tek LV30 Series Manual de usuario

FlowLine

FlowLine Switch-Tek LV41 Series Manual de usuario

FlowLine

FlowLine Switch-Pro AU18 Series Manual de usuario

FlowLine

FlowLine EchoPod DL10 Series Manual de usuario

FlowLine

FlowLine Smart Trak AU18-4343 Manual de usuario

Manuales populares de Cambiar de otras marcas

URC

URC Total Control MFS-8 Manual de usuario

Azbil

Azbil HPQ-D11 Manual de usuario

Sony

Sony DFS-900M Manual de usuario

SICK

SICK i17S Manual de usuario

F&F

F&F SZR-277 Manual de usuario

Shure

Shure UAMS/BK Manual de usuario

Dräger

Dräger X-zone Switch Off Manual de usuario

Asco

Asco Joucomatic 349 Series Manual de usuario

BT Mini Hub Manual de usuario

D-Link

D-Link DES-1226G Manual de usuario

Johnson Controls

Johnson Controls FS80-C Manual de usuario

Alcatel-Lucent

Alcatel-Lucent 7450 ESS-12 Manual de usuario

MicroNet

MicroNet SP1200A Manual de usuario

Ruijie

Ruijie RG-PF2920 Series Manual de instalación y funcionamiento

Altinex

Altinex DA1914SX Manual de usuario

MiLAN

MiLAN MIL-SM2401M Manual de usuario

RJM

RJM MASTERMIND PBC/6X Manual de usuario

Atlas

Atlas MMK-KVM8 Manual de usuario