Extech Instruments IR260 Manual de usuario

USERGUIDE

MiniInfraRedThermometer

WithLaserPointerandHigh‐LowAlarms

ModelIR260

99 Washington Street

Melrose, MA 02176

Phone 781-665-1400

Toll Free 1-800-517-8431

Visit us at www.TestEquipmentDepot.com

EXTECHINSTRUMENTS

2 IR260‐en‐GB_V1.21/16

Introduction

CongratulationsonyourpurchaseoftheIR260IRThermometer.Thisthermometermakesnon‐

contact(infrared)temperaturemeasurementsatthetouchofabutton.Thebuilt‐inlaserpointer

increasestargetaccuracywhilethebacklitLCDandhandypushbuttonscombineforconvenient,

ergonomicoperation.Thisdeviceisshippedfullytestedandcalibratedand,withproperuse,will

provideyearsofreliableservice.

Features

Measuresnon‐contactsurfacetemperatureupto400°C(752°F)

12:1DistancetoSpotRatio(FieldofView)

Single‐pointlasertargeting

AutomaticDataHoldwhentriggerisreleased

DisplayBacklight

Maximum‐Minimumtemperaturefunction

Selectabletemperatureunits(°F/°C)

Dynamicbatterystatusindication

Adjustableemissivity

AudibleandvisiblealarmindicationforHighandLowTemperatureAlarm

Safety

InternationalSafetySymbols

Thissymbol,adjacenttoanothersymbolorterminal,indicatestheusermustrefertothemanualfor

furtherinformation

Warnings

oDonotdirectlyorindirectlypointthelaserattheeyesofapersonorananimal

oInspectfordamageorforanyshortageofpartsoraccessoriesbeforeuse

oReplacethebatteriesimmediatelyafterthebatteryindicatorflashes

oDonotusethethermometernearexplosivegases,steam,ordust

oNotethatanobjectwithhighreflectivitywillnormallycausethe

measuredtemperaturevaluetoreadmuchlowerthantheactual

temperature

oUsethedeviceonlyasdescribedinthisUserGuide

Cautions

Toavoidthermometerdamage,pleaseavoidthefollowinghazards:

oEMFfromweldingequipmentorelectro‐inductionheaters

oStaticelectricity

oThermalshockcausedbylargeorabruptenvironmentaltemperaturechanges;wait30minutesto

allowthethermometertostabilizetonewenvironmentalconditions

oDonotusethisdeviceinexcessivelyhightemperatureenvironments

<1mW Output at 650nm

EXTECHINSTRUMENTS

3IR260‐en‐GB_V1.21/16

Description



MeterDescription

1. LCDDisplay

2. MAX‐MIN/DownButton

3. Backlight‐LaserPointer/UpButton

4. Laserpointerlens

5. IRThermometerlens

6. SETButton

7. MeasurementScanTrigger

8. BatteryCompartment

DisplayDescription

Emissivityvalueindication

Laserpointeractiveicon



Scanmode(activewhilethetriggerispulled;displayed

temperaturetracksthetemperatureofthescannedsurfaces)

Holdmode(displayedtemperaturefreezeswithtriggerrelease)

Maximum/Minimumtemperatureicons

Batterycapacityindicator(flasheswhenbatteryvoltageiscritical)

DisplayBacklighticon

Temperatureunits(°F/°C)

TemperatureAlarmiconsandaudiblealarmdisableicon

EXTECHINSTRUMENTS

4IR260‐en‐GB_V1.21/16

Operation

MeterPower

Themeterispoweredbytwo1.5VAAbatteries.Withfreshbatteriesinstalled,themeter

switchesONwhenthetriggerispulled.Thebatteriesarelocatedinthemeterhandle;pullthe

batterycompartmentlidawayfromthebodyofthemetertoopen.RefertotheMaintenance

sectionformoreBatteryInstallationinstructions.Thebatteryiconprovidesbatterystatus

indication.Replacethebatteriesassoonasthebatterystatusiconflashes.

SurfaceTemperatureMeasurements

1. HoldthemeterbyitsHandleGripandpointittowardthesurfacetobemeasured.Readthe

FieldofViewsectionbelowfordistancetotarget(spot)ratioinformation.

2. PullandholdtheTriggertoturnthemeteronandbegintestinginScanmode.Thedisplay

willlightifthetwo1.5Vbatteriesaregood.Replacethebatteriesifthedisplaydoesnotlight.

3. ReleasetheTrigger;thereadingwillholdforapproximately9seconds,afterwhichthemeter

willautomaticallyshutoff.

4. Themeterdefaultstotheprogrammedconditionsinusewhenthemeterwaslastswitched

OFF.Forexample,ifthelaserissettoONandthetemperatureunitsaresettooFatthetime

theunitisswitchedOFF,theunitwillswitchONandusethesamesettings.

Laser–ON/OFF

Pull the trigger and release.

PushandHOLDthe buttonforabout3secondstoswitchthelaserpointerONorOFF.

TheLasericonwillflashwhenthestatehaschanged.WhenthelaserisON,thelasericon will

appearontheLCD.Aimtheredlaserbeamapproximatelyahalfinchbelowthepointoftest

(pressingtheLaserbuttonagainturnsthelaseroff).

MAX‐MINMode

Pressthetriggerandrelease.

PresstheMAX‐MINbuttontoviewthemaximumtemperaturereading(MAX),pressagainto

viewthelowestreading(MIN).PressandholdtheMAX‐MINbuttontoswitchtheMAX‐MIN

modeoff.

DisplayBacklight

Pressthetriggerandrelease.

Pressthebacklightbutton momentarilytoswitchthebacklightONorOFF.

Over‐rangeIndicators(OLand‐OL)

Ifthetemperaturemeasurementexceeds779°F(415°C),thethermometerwilldisplayOLin

placeofatemperaturereading.Ifthetemperaturemeasurementisbelow‐25°C(‐13°F),the

thermometerwilldisplay‐OLinplaceofatemperaturereading.



EXTECHINSTRUMENTS

5IR260‐en‐GB_V1.21/16

SettingMode

ReleasethetriggerandpresstheSETbuttontoaccesstheSettingMode.UsetheSETbuttonto

navigatethroughtheSettingModefieldsanduse(UP)andtheMAX‐MIN(DOWN)

buttonstomakechanges.Theavailableparametersarelistedbelow:

Emissivitysetting

°C/°Ftemperatureunitsselection

TemperatureAlarmAudibleBeeperEnable/Disable

HighTemperatureAlarmLimitsetting

LowTemperatureAlarmLimitsetting

Thecorrespondingparametericonwillflashwhenselected.ToexittheSettingMode,press

andholdtheSETbuttonfortwoseconds.

EmissivitySetting

The iconwillflashwhenselected.UsetheupandMAX‐MINdownbuttonsto

increaseordecreasetheemissivity(in0.01steps).Theemissivityrangeis0.10to1.00.Hold

theupordownbuttontorapidlyincreaseordecreasetheemissivityvalue.PresstheSET

buttontoconfirmandtosteptothenextoption.

SelectingtheTemperatureUnitofMeasure(°C/°F)

Usethe upandMAX‐MINdownbuttonstoselect°Cor°F.PresstheSETbuttonto

confirmandtosteptothenextoption.

Enable/DisableAudibleTemperatureAlarm

Thisparameterisusedtoenable/disabletheaudibletemperaturealarm.Theiconwillflash

inthismode.

UsetheupandMAX‐MINdownbuttonstotogglethesetting.Whentheaudible

alarmisdisabled,thedisplaywillshow‘HIGHLOW’.Whentheaudiblealarmisenabled,the

displaywillshow.Whentheaudiblealarmisenabled,thebeeperisallowedto

soundwheneverthemeasuredtemperaturegoesbeyondthehighorlowtemperaturelimit

values.PresstheSETbuttontoconfirmandtosteptothenextoption.

HIGHTemperatureAlarmLimitSetting

UsetheupandMAX‐MINdownbuttonstoincreaseordecreasetheHighAlarm

TemperatureLimit(in0.1stepsfor°Cor0.2stepsfor°F).Holdingtheupordownbuttonwill

rapidlyincreaseordecreasetheHIGHlimitvalue.AbeepwillsoundiftheHIGHtemperature

valuereachestheLOWtemperaturevaluewhileprogramming.PresstheSETbuttonto

confirmandtosteptothenextoption.

LOWTemperatureAlarmLimitSetting

UsetheupandMAX‐MINdownbuttonstoincreaseordecreasetheLowAlarm

TemperatureLimit(in0.1stepsfor°Cor0.2stepsfor°F).Holdingdowntheupordown

buttonwillrapidlyincreaseordecreasetheLOWlimitvalue.AbeepwillsoundiftheLOW

temperaturevaluereachestheHIGHtemperaturevaluewhileprogramming.PresstheSET

buttontoconfirmandtosteptothenextoption.

EXTECHINSTRUMENTS

6IR260‐en‐GB_V1.21/16

LocatingHotorColdSpots

Todetectahotorcoldspot,aimthethermometerataregionbeyondthetargetandthenscan

theentireregioninaslow,up/downmotion.



DistancetoSpotRatio(FieldofView)

Themeter’sfieldofviewis12:1(distancetospotratio).Forexample,ifthemeteris24inches

fromthetarget(spot),thediameterofthetargetmustbeatleast2inches.Otherdistancesare

shownbelowinthefieldofviewdiagram.

Notethatmeasurementsshouldnormallybemadecloserthan2feetfromthetarget.Themeter

canmeasurefromfurtherdistancesbutthemeasurementmaybeaffectedbyexternalsources

oflight.Inaddition,thespotsizemaybesolargethatitencompassessurfaceareasnotintended

tobemeasured.



Itisnecessarytoensurethatthesizeofthetargetislargerthanthespotsize.Thesmallerthe

target,thecloserthedistanceshouldbe.Seetheaccompanyingdiagram.



Emissivity

Emissivityrepresentstheenergyreflectivityofamaterial.Mostorganicmaterialsandpainted

oroxidizedsurfaceshaveanemissivityofapproximately0.95.Ifpossible,maskingtapeorflat

blackpaintshouldbeappliedtocoverthemeasuredsurface.

Waitaperiodoftimetoallowthetapeorpainttoreachthermalequilibriumwiththesurface

ofthecoveredobject.Measurethetemperatureofthesurfacecoveredwithtapeorpaintonly

afterequilibriumhasbeenachieved.

EXTECHINSTRUMENTS

7IR260‐en‐GB_V1.21/16

MeasurementNotes

1. Theobjectundertestshouldbelargerthanthespot(target)sizecalculatedbythefieldof

viewdiagram.

2. Ifthesurfaceoftheobjectundertestiscoveredwithfrost,oil,grime,etc.,cleanbefore

takingmeasurements.

3. Ifanobject'ssurfaceishighlyreflectiveapplymaskingtapeorflatblackpainttothesurface

beforemeasuring.

4. Themetermaynotmakeaccuratemeasurementsthroughtransparentsurfacessuchas

glass.

5. Steam,dust,smoke,etc.canobscuremeasurements.

6. Themetercompensatesfordeviationsinambienttemperature.Itcan,however,takeupto

30minutesforthemetertoadjusttoextremelywideambienttemperaturechanges.

7. Tofindahotspot,aimthemeteroutsidetheareaofinterestthenscanacross(inanupand

downmotion)untilthehotspotislocated.

Maintenance

Cleaning

Tocleanthelensesusecompressedairtocleardustandotherparticles,thencarefullyclean

withawetcottonswab.Thecottonswabshouldbemoistenedwithcleanwater.

Tocleanthemeterhousing,wipewithadamp,softcloth.Donotusesolventsorabrasives.Do

notimmersetheIR260inwaterorotherliquid.

Troubleshooting

SymptomProblemAction

OLdisplayTargettemperatureexceedsrangeSelectatargetwithinrange

‐OLdisplayTargettemperatureunder‐rangeSelectatargetwithinrange

BatteryiconflashesLowBatterypowerReplaceBatteries

BlankdisplayscreenLowbatterypowerCheckand/orreplacebatteries

NoLaserpointerLowbatteryorenvironmental

temperaturehigherthan40°C(104°F)

Replacethebatteries ormovethe

IR260toanareawithalower

ambienttemperature

EXTECHINSTRUMENTS

8IR260‐en‐GB_V1.21/16

ReplacingBatteries

Whenthebatteryiconflashes,orwhenthemeterdoesn’tswitchON,replacethebatteries.

Thebatterycompartmentislocatedinthehandlegrip.Thebatterycompartmentlidislocated

justbelowthetrigger.Prythecompartmentlidofftoreachthecompartment.

Replacethe1.5VAAbatteriesfollowingcorrectpolarityandthenclosethebatterycompartment

lid.

BatterySafetyNotes:Pleasedisposeofbatteriesresponsibly;neverdisposeofbatteriesinafire,

batteriesmayexplodeorleak.Ifthemeterisnottobeusedfor60daysormore,removethe

batteryandstoreseparately.Donotmixbatterytypesorfreshnesslevels;pleaseusebatteries

ofthesametypeandofthesamefreshnesslevel.



Neverdisposeofusedbatteriesorrechargeablebatteriesinhouseholdwaste.

Asconsumers,usersarelegallyrequiredtotakeusedbatteriestoappropriatecollection

sites,theretailstorewherethebatterieswerepurchased,orwhereverbatteriesaresold.



Disposal:Donotdisposeofthisinstrumentinhouseholdwaste.Theuserisobligatedtotake

end‐of‐lifedevicestoadesignatedcollectionpointforthedisposalofelectricalandelectronic

equipment.



EXTECHINSTRUMENTS

9 IR260‐en‐GB_V1.21/16

Specifications

InfraredThermometerSpecifications

Range/Resolution‐20.0to400.0oC(‐4.0to752.0oF)

Accuracy‐20~0oC(‐4~32oF):±5°C(9°F)

0~400oC(32~752oF)±2°C(3.6°F)or2%ofreading(whicheverisgreater)

Note:Accuracyisspecifiedforthefollowingambienttemperaturerange:

21to25°C(70to77°F)

EmissivityAdjustablefrom0.10to1.00

FieldofView12:1DistancetoSpotratio

LaserpowerLessthan1mW

Spectralresponse630to670nm(wavelength)

GeneralSpecifications

Display BacklitLCDdisplaywithfunctionindicators

Displayrate500msapprox.

OperatingTemperature 0°Cto40°C(32°Fto104°F)

OperatingHumidityMax.75%RH

PowerSupplyTwo1.5VAAAlkalinebatteries

AutomaticPowerOffMetershutsoffautomaticallyafter9seconds

Weight 226g(8.0oz.)

Dimensions172x97x46mm(6.8x3.8x1.8”)

Allrightsreservedincludingtherightofreproductioninwholeorinpartinanyform

ISO‐9001Certified

Test Equipment Depot - 800.517.8431 - 99 Washington Street Melrose, MA 02176

TestEquipmentDepot.com

Tabla de contenidos

Otros manuales de Termómetro de Extech Instruments

Extech Instruments

Extech Instruments 42545 Manual de usuario

Extech Instruments

Extech Instruments TM300 Manual de usuario

Extech Instruments

Extech Instruments 4465CF Manual de usuario

Extech Instruments

Extech Instruments 407445 Manual de usuario

Extech Instruments

Extech Instruments RH101 Manual de usuario

Extech Instruments

Extech Instruments 42535 Manual de usuario

Extech Instruments

Extech Instruments 42530 Manual de usuario

Extech Instruments

Extech Instruments EasyView EA20 Manual de usuario

Extech Instruments

Extech Instruments TM100 Manual de usuario

Extech Instruments

Extech Instruments 42515 Manual de usuario

Extech Instruments

Extech Instruments 445580 Manual de usuario

Extech Instruments

Extech Instruments 42512 Manual de usuario

Extech Instruments

Extech Instruments MO295 Manual de usuario

Extech Instruments

Extech Instruments RHT510 Manual de usuario

Extech Instruments

Extech Instruments K.J.E.T. 422324 Manual de usuario

Extech Instruments

Extech Instruments IR320 Manual de usuario

Extech Instruments

Extech Instruments IRT25 Manual de usuario

Extech Instruments

Extech Instruments EA10 Manual de usuario

Extech Instruments

Extech Instruments IR267 Manual de usuario

Extech Instruments

Extech Instruments 421508 Manual de usuario

Extech Instruments

Extech Instruments 39240 Manual de usuario

Extech Instruments

Extech Instruments TM200 Manual de usuario

Extech Instruments

Extech Instruments RH250W Manual de usuario

Extech Instruments

Extech Instruments 421502 Manual de usuario

Manuales populares de Termómetro de otras marcas

Delton

Delton 981A Manual de usuario

Baker

Baker MM2P Manual de usuario

Tarmo

Tarmo 320281 Manual de usuario

Citizen

Citizen CTD 504 Manual de usuario

TFA

TFA 14.1500 Manual de usuario

Vive

Vive DMD1010 Manual de usuario

Gotemp

Gotemp THB4002 Manual de usuario

GREISINGER

GREISINGER G 1202 Manual de usuario

Amprobe

Amprobe TMD-53W Manual de usuario

Trotec

Trotec BP10 Manual de usuario

Radiance instruments

Radiance instruments RT616 Series Manual de usuario

Eurolec

Eurolec IR151 Manual de usuario

Scaneo

Scaneo TS42B Manual de usuario

Sper scientific

Sper scientific 800043 Manual de usuario

Microlife

Microlife NC 200 Manual de instrucciones

Motorola

Motorola MBP69SN Guía de configuración

The MeatStick

The MeatStick The MeatStick Manual de usuario

Hama

Hama TH35-A Manual de usuario