Dundalk LeisureCraft CTC22LU Manual de usuario

ph: 519-923-9813 | info@dundalkleisurecraft.com| web: www.dundalkleisurecraft.com

Dundalk LeisureCraft Luna Sauna Assembly

Instructions

Please read and understand the complete instructions prior to assembly and use of your sauna. Customer agrees not to hold

Dundalk LeisureCraft Inc. and any of its authorized dealers liable for improper installation, maintenance and repair of this product

Requirements:

View the assembly process on

* 2 People (recommended)

* Step or Extension Ladder

* Cordless Drill (we supply the bit)

* Tape Measure

* Staple Gun

* Utility Knife

* Hacksaw

* 3/16” Drill bit

* 1 ½” or less staples or nails to fasten bevel siding

Ver. 2.7

ph: 519-923-9813 | info@dundalkleisurecraft.com| web: www.dundalkleisurecraft.com

Index

Sauna Base Preparation (Standard) – Page 3

Luna Sauna Assembly (Standard) – Page 4 to 19

Standard Bench Installation (Standard) – Page 20 to 24

Lounge Bench Installation (Option) – Page 25 & 26

Electric Heater Installation (Option) – Page 27 to 29

Wood Heater Installation (Option) – Page 30 & 31

Harvia Wood Heater Installation (Option) – Page 32 to 36

Sauna Vent Kit (Option) – Page 37 to 39

Sauna Light (Option) – Page 40 & 41

Completion/Maintenance/Warranty – Page 42 to 44

Dundalk LeisureCraft Luna Sauna

Assembly Instructions

Sauna Base Preperation

ph: 519-923-9813 | info@dundalkleisurecraft.com| web: www.dundalkleisurecraft.com

Concrete Pad

Sauna Base Preparation

A solid base for your sauna is recommended and can be made from any of the following.

Wooden Deck

Crushed Gravel Patio Stones/Paver Blocks

(Refer to the below chart for minimum base requirements)

It is recommended to build a base larger than required to provide

a sitting area for cooling off during your sauna session.

* All measurements in above chart are “width x lengths”

Sauna Size 8'x6' (244x182) 8'x7' (244x214) 8'x8' (244x244)

Minimum Base Size 96"x72" 96"x84" 96"x96"

(244x182cm) (244x214cm) (244x244cm)

Options

Porch Add 24" (60cm) to total length.

Changeroom Add 48" (120cm) to total length.

Dundalk LeisureCraft

Luna Sauna

Assembly Instructions

Luna Sauna Assembly (Standard)

ph: 519-923-9813 | info@dundalkleisurecraft.com| web: www.dundalkleisurecraft.com

Make sure you have a solid base for your Luna sauna

and lay out the cradle pieces.

Gather up your pieces for the back wall.

This should consist of 15 straight pcs and 4 pcs with

rounded corners of 2x6x80”(5cm x 15cm x 203cm)

* 2 of each with rounded corners will have dado

grooves on the opposite side of the curves, 2 will be

for the right side and 2 for left side of back wall.

Lay out the pieces as shown, including the rounded

corner pieces.

To make the next steps easier, line up the back wall

staves as best you can.

Dundalk LeisureCraft

Luna Sauna

Assembly Instructions

Luna Sauna Assembly (Standard)

ph: 519-923-9813 | info@dundalkleisurecraft.com| web: www.dundalkleisurecraft.com

Make sure staves are tight together.

Place a washer and nut on each end of the threaded rod

for each hole.

Tighten up all the nuts with a wrench, socket or impact

driver.

Slide one of the threaded rods through the top holes.

Repeat for the bottom holes.

* This will take some finessing

* If the Dundalk wood stove is chosen there will be an

extra threaded rod in the middle of the back wall.

Dundalk LeisureCraft

Luna Sauna

Assembly Instructions

Luna Sauna Assembly (Standard)

ph: 519-923-9813 | info@dundalkleisurecraft.com| web: www.dundalkleisurecraft.com

Using the assembled back wall as a guide, start the

assembly of the front wall with one of the side rounded

staves.

Slide one of the threaded rods through the top hole and

add 5 short staves onto the threaded rod.

Repeat process for the bottom set of holes.

Carefully insert the first window in between the short

staves. The groove of the window should sit over the

edge of the blocks.

Cut off any excess threaded rod with a hacksaw.

Dundalk LeisureCraft

Luna Sauna

Assembly Instructions

Luna Sauna Assembly (Standard)

ph: 519-923-9813 | info@dundalkleisurecraft.com| web: www.dundalkleisurecraft.com

Thread one small stave on each threaded rod.

Carefully insert the door between the 2 small staves.

Add 4 more small staves on each threaded rod to

support the door.

Next, Thread on a full size stave.

Again this stave should sit inside the groove of the

window.

Dundalk LeisureCraft

Luna Sauna

Assembly Instructions

Luna Sauna Assembly (Standard)

ph: 519-923-9813 | info@dundalkleisurecraft.com| web: www.dundalkleisurecraft.com

Finish the front wall by adding the corner stave.

Tighten the nuts again in the same manner as the back

wall. Cut off excess with a hacksaw.

* Tapping the staves gently with a rubber mallet can

help get them to settle tight to each other.

Carefully remove both front and back walls and place

where they will not get damaged or fall over.

Thread on a full size stave, then 5 short staves then the

other window in the same manner as the opposite side.

Dundalk LeisureCraft

Luna Sauna

Assembly Instructions

Start laying out the bottom staves, there will be 7 staves

on either side of the center stave.

* The staves for the Luna without the porch option are

symmetrical and can be used on the left or right side of

the center stave.

•If the porch option is chosen,

•there will be right and left sides, make sure all dado

grooves line up with each other.

Luna Sauna Assembly (Standard)

ph: 519-923-9813 | info@dundalkleisurecraft.com| web: www.dundalkleisurecraft.com

Measure out the center stave so it is centered on the

first cradle. The cradle should be approx. 7” back from

the end of the stave.

Using 2 ½” (64mm) screws , secure the center stave to

the cradle.

Repeat at other end.

Space out the remaining cradles evenly, measure them

to center and secure center stave to cradles using a 2 ½”

(64mm) screw per cradle.

Lay out the center stave as shown.

* This stave will have convex edges on

both sides as in inset.1.

Inset. 1

Dundalk LeisureCraft

Luna Sauna

Assembly Instructions

Luna Sauna Assembly (Standard)

ph: 519-923-9813 | info@dundalkleisurecraft.com| web: www.dundalkleisurecraft.com

Use a rubber mallet to tap all the staves tight together.

* Secure staves into each cradle using 2 ½ (64mm)

screws.

After laying out the bottom staves, line them up so the

ends are flush.

* All the grooves should be in line with each other.

Insert the back wall in to the groove on the sauna floor.

* You may need to use a rubber mallet to “finesse” the

wall into the groove.

Make sure both sides are sticking out past sauna floor

equally to ensure wall is centered.

Dundalk LeisureCraft

Luna Sauna

Assembly Instructions

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Producto de plomería de Dundalk LeisureCraft

Dundalk LeisureCraft

Dundalk LeisureCraft Cedar Pod Sauna Manual de usuario

Dundalk LeisureCraft

Dundalk LeisureCraft Pure Cube PU550 Manual de usuario

Dundalk LeisureCraft

Dundalk LeisureCraft Luna Manual de usuario

Dundalk LeisureCraft

Dundalk LeisureCraft Cedar Barrel Sauna Manual de usuario

Dundalk LeisureCraft

Dundalk LeisureCraft Indoor Cabin Sauna Manual de usuario

Dundalk LeisureCraft

Dundalk LeisureCraft Eagles Nest Manual de usuario

Dundalk LeisureCraft

Dundalk LeisureCraft Panoramic Barrel Sauna Manual de usuario

Dundalk LeisureCraft

Dundalk LeisureCraft Cedar Manual de usuario

Dundalk LeisureCraft

Dundalk LeisureCraft Indoor Cabin Sauna Manual de usuario

Dundalk LeisureCraft

Dundalk LeisureCraft Cedar Barrel Manual de usuario

Dundalk LeisureCraft

Dundalk LeisureCraft Luna Manual de usuario

Dundalk LeisureCraft

Dundalk LeisureCraft Pure Cube CU550 Manual de usuario

Dundalk LeisureCraft

Dundalk LeisureCraft Kota Sauna Manual de usuario

Dundalk LeisureCraft

Dundalk LeisureCraft Western Red Cedar Indoor Cabin Sauna Manual de usuario

Dundalk LeisureCraft

Dundalk LeisureCraft Mini Pod Manual de usuario

Dundalk LeisureCraft

Dundalk LeisureCraft Cedar Barrel Sauna Manual de usuario

Dundalk LeisureCraft

Dundalk LeisureCraft Outdoor Cedar Cabin Sauna Manual de usuario

Manuales populares de Producto de plomería de otras marcas

Weka

Weka 506.2020.00E Instrucciones de funcionamiento

Kohler

Kohler K-6228 Instrucciones de montaje

UBERHAUS DESIGN

UBERHAUS DESIGN 75175017 Manual de usuario

American Standard

American Standard DetectLink 6072121 Manual de usuario

Uponor

Uponor Contec TS Manual de usuario

Pfister

Pfister Selia 49-SL Manual de usuario

Fortis

Fortis VITRINA 6068700 Manual de usuario

Fortis

Fortis MILANO 78211JS Manual de usuario

Kohler

Kohler K-12183 Instrucciones de montaje

Maxxus

Maxxus MX-M206-01 Manual de usuario

Moen

Moen 5922 Series Manual de usuario

Viega

Viega Prevista Pure 8512 Manual de usuario

Kohler

Kohler Centerset K-15240 Instrucciones de montaje

Viega

Viega Prevista Dry 8522.33 Manual de usuario

Sanela

Sanela Lema SLP 59RB Manual de usuario

Elkay

Elkay EDF15AC Manual de instalación

Hans Grohe

Hans Grohe AXOR Citterio E 36702000 Manual

baliv

baliv WT-140 Manual de usuario