Desa C36TO Manual de instrucciones
If any wood pieces are missing or damaged, contact the
dealer where you purchased this mantel for replacement. If
hardware is missing or damaged, contact DESAHeating, LLC
at 1-866-672-6040 for referral information. You can also visit
DESA Heating, LLC’s web site at www.desatech.com.
IMPORTANT: If you are staining an unnished mantel (C36TU
only), remove any sawdust, dirt or oils. This will prevent blem-
ishes from appearing under the stain. Stain mantel before
assembling according to manufacturer’s instructions. Apply
sanding sealer.
IMPORTANT: If you are painting an unnished mantel (C36TU
only), assemble mantel before painting. Follow directions
listed on paint for wood products. Apply base coat and top
coat following directions listed on product.
Note: Gather all mantel pieces together before assembling
mantel.
/4
are used for this purpose.
C36TU and C36TO
Corner Mantel and Base
ASSEMBLY AND INSTALLATION INSTRUCTIONS
IMPORTANT:
-
This mantel kit contains the following:
• Mantel pieces - unassembled and numbered as follows:
#1 Base
#2 Right Side Assembly
#3 Left Side Assembly
#4 Header
#5 Top
#6 Top Triangle
#7 Top Left Support
#8 Top Right Support
#9 Top Center Support
#10 Base Support
#11 Vertical Support
Right Top Trim Strip
Left Top Trim Strip
• Hardware Package
36 - 1 1/4" Wood Screws 114325-01
8 - 1" Finishing Nails 114295-04
4 - 2" Wood Screws 122447-01
* Extra hardware may be included
Tools required:
• Power Screwdriver with #2 Phillips Bit
• Hammer
• Nail Set
www.desatech.com
123680-01A
2www.desatech.com
Header #4
Header
Assembly
Block
Figure 1 - Installing Base Support
Figure 2 - Installing Header
Base #1
11/4" Screws
Base Support #10
11/4"
Screws
Left Leg
Assembly #3
Right Leg
Assembly #2
Figure 3 - Installing Mantel Base
11/4"
Screws
IMPORTANT:
Use the following illustrations to assemble mantel. Use only
screws provided.
IMPORTANT: Align mantel left to right on base before install-
ing. Corner of mantel legs must be ush with back of mantel
base before installation (see Figure 4). Use a tape measure
to insure accuracy.
Right Leg
Assembly
#2
Left Leg
Assembly #3
Base #1
Figure 4 - Mantel Top Assembly
Top Center
Support #9
Mantel Top #5
Top Left
Support #8
2" Screws
11/4" Screws
Top Triangle #6 Top Right
Support #8
IMPORTANT: Use 2" screws only on top center support. Using
2" screws in any other location will damage mantel.
Header into
Groove on
Legs
www.desatech.com
123680-01A 3
Fireplace Installation
1. Fireplace should be fully assembled. See Assembling
Fireplace in replace owner’s manual.
2. Mantel must be installed ush with two walls. Remove
baseboard along walls where mantel is to be installed.
Baseboard will prevent proper installation of mantel and
base.
3. Place mantel base close to installation location. See re-
place owner’s manual for installation clearances. Leave
enough room to insert replace from back of mantel.
4. If installing gas replace, install gas line. See Connecting
to Gas Supply in replace owner’s manual. Remember to
leave access to gas shutoff valve somewhere on mantel
base or where it is accessible to user. Check for leaks. See
Checking Gas Connections in replace owner’s manual.
5. Position replace inside mantel through back opening
(see Figure 6). Carefully position gas lines if applicable.
IMPORTANT: Use caution when positioning replace on
base. Base may scratch easily. Make sure replace is in
proper position within mantel opening before continuing
with installation.
6. Lower bottom louver
door. Use two screws provided in replace hardware kit
and attach replace to wooden base. Close louver door.
Before installing logs
or burner assembly (see owner’s manual) remove screws
securing oor to assembly. Lift oor for access to bot-
tom of replace. Use two screws provided in replace
hardware kit and attach replace base to wooden base.
Reinstall oor with screws removed previously.
Figure 6 - Installing Gas Fireplace
Mantel Top
Assembly
Assembly
Blocks
Assembly
Blocks
11/4"
Screws
Mantel
Legs Flush
with Mantel
Base
Figure 5 - Installing Mantel Top
Corner
of Mantel
Legs Must
be Flush
with Edge
of Mantel
Top
IMPORTANT: Align mantel top left to right before installing.
Back corner of mantel leg must be ush with edge of mantel
top before installation.
IMPORTANT: If installing a gas replace, vertical support
will be installed to mantel assembly after gas replace has
been installed. If installing electric replace, rst install verti-
cal support and install replace from front of mantel. Do not
put any weight on mantel top until vertical support has been
installed.
This mantel can be used with DESA Heating, LLC electric
replaces. Electric replaces install from the front of mantel.
To install electric replace see replace instruction manual.
Install vertical support (see Figure 7).
Figure 8 - Installing Mantel Trim
Finishing Nails
Trim Strips
123680-01
Rev. A
04/08
Figure 7 - Installing Vertical Support
Vertical
Support
#11
1 1/4" Screws
1 1/4" Screws
Base Support #10
Top
Center
Support
1. Carefully push mantel and base into position in corner
and ush against both walls. Check operation of replace
before proceeding.
2. Place right trim strip on right side of top and left trim on left
side of top. Align both pieces so any gaps between mantel
and wall are covered as well as possible and front of trim
strips are ush with side of top. With one person holding
trim strips in place, nail each strip to mantle using nishing
nails included in hardware kit and nail set.
123680 01
NOT A UPC
DESA Heating, LLC
2701 Industrial Drive
Bowling Green, KY 42101
www.desatech.com
1-866-672-6040
Este manual sirve para los siguientes modelos
1
Tabla de contenidos
Otros manuales de Accesorios para chimeneas de Desa
Desa
Desa Wall Mantel and Base W26LC Manual de instrucciones
Desa
Desa Wall Mantel and Base W32LS2 Manual de instrucciones
Desa
Desa DS37 Manual de usuario
Desa
Desa W32TO Manual de instrucciones
Desa
Desa Wall Mantel with Base and Trim WD26CP Manual de instrucciones
Desa
Desa GB38 Manual de usuario
Desa
Desa W32CO Manual de instrucciones
Desa
Desa Mantel and Base W21TO Manual de instrucciones
Desa
Desa BDMO48E Manual de usuario
Desa
Desa W23OT Manual de instrucciones
Desa
Desa C26TO Manual de instrucciones
Desa
Desa Wall Mantel and Base W32MF Manual de instrucciones
Desa
Desa Proflame 584 Manual de usuario
Desa
Desa W23FT Manual de instrucciones
Desa
Desa Wall Mantel and Base with Trim W32WP Manual de instrucciones
Desa
Desa Comfort Glow GA3750 Manual de usuario
Desa
Desa BK3 Manual de usuario
Desa
Desa Wall Mantel and Base with Trim W32KCSA Manual de instrucciones
Desa
Desa Wall Mantel and Base W26LT Manual de instrucciones
Desa
Desa C32CO Manual de instrucciones
Manuales populares de Accesorios para chimeneas de otras marcas
Bronpi
Bronpi KIT-1 Manual de usuario
Town & Country Fireplaces
Town & Country Fireplaces 22150051 Manual de usuario
Travis Industries
Travis Industries 33 DVI Manual de usuario
Superior
Superior ASD3628-TI Manual de usuario
pleasant hearth
pleasant hearth OFP28WG Manual de usuario
IHP
IHP Astria Series Manual de usuario
