Cornelius 318569000 Manual de usuario

EIMI Cornelius Inc; 1999–2003

February 9, 1999

569000261

Revised: October 9, 2003

IMI CORNELIUS INC gOne Cornelius Place gAnoka, MN 55303-6234

Telephone (800) 238-3600 Facsimile (800) 535-4231

INSTALLATION INSTRUCTIONS

DISPENSING VALVES KEYED LOCK-OUT SWITCH KIT (P/N 569000262)

VANTAGE POST-MIX DISPENSERS

Read and understand these instructions thoroughly before installing this Dispensing Valves Keyed Lock-out

Switch Kit (P/N 569000262) on the Post-Mix Dispensers. The purpose of the Keyed Lock-Out Switch is to shut

off electrical power to the dispensing valves to prevent dispensing of product. Retain these instructions as part

of your equipment manual.

LOOSE-SHIPPED PARTS

Note: Only qualified personnel should install this Kit.

Unpack and inspect kit. Make sure items are present and in good condition.

Table 1. Loose-Shipped Parts

Item

No. Part No. Name Qty

1 560003869 Wiring Harness 1

2 560003870 Template, Hole Drilling 1

3 318948000 Lock Key 1

4 318949000 Hex Nut 1

5 318569000 Key-Lock Switch 1

6 569000261 Installation Instructions 1

KIT INSTALLATION

WARNING: To avoid possible fatal electrical shock or serious injury to Installer, make sure

Dispenser is disconneced from power source before attempting to install this kit.

1. Disconnect electrical power from the Dispenser

2. Remove hood from the Dispenser, then lift hood straight up off the Dispenser for access to the transformer

on the refrigeration deck.

3. Refer to Figure 1 for location of hole to be drilled in the Dispenser hood for installation of the KEY-LOCK

SWITCH (item 5).

4. Place TEMPLATE, HOLE DRILLING (item 2) in position on Dispenser hood as shown in Figure 1.

5. Drill hole in Dispenser hood as indicated on the hole drilling template, then remove template from the hood.

569000261

1.50

TEMPLATE

(ITEM 2)

HOOD

LOCK KEY

(ITEM 3)

KEY-LOCK SWITCH

(ITEM 5)

HEX NUT

(ITEM 4)

FIGURE 1. DISPENSER HOOD

6. Install KEY-LOCK SWITCH (item 5) in the hood as shown in Figure 1 and secure with HEX NUT (item 4).

7. Refering to Wiring Diagram (Figure 2) disconnect black electrical wire, with push-on terminal on it’s end,

from terminal on the transformer outlet.

8. Connect black electrical wire, disconnected from the transformer outlet terminal, to mating electrical wire

terminal on the WIRING HARNESS (item 1).

9. Connect other electrical wire of the wiring harness to output terminal on the transformer where the black

electrical wire was disconnected from in step 7 preceding.

10. Connect other two wiring harness terminals to two terminals on the Key-Lock Switch.

11. Install hood on the Dispenser.

12. Connect electrical power to the Dispenser, then check Dispenser for proper operation.

13. Insert LOCK KEY (item 3) in key-lock switch, then check Dispenser for proper operation.

KEY-LOCK SWITCH

(ITEM 5 )

WHITE

BLACK

MATING

TERMINALS

FIGURE 2. WIRING DIAGRAM

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Dispensador de Cornelius

Cornelius

Cornelius REMCOR OLYMPUS POST-MIX Manual de usuario

Cornelius

Cornelius Millennium II 6000 Manual de usuario

Cornelius

Cornelius FCB OVERCOUNTER POST-MIX DISPENSER Manual de usuario

Cornelius

Cornelius IDC PRO 255 Manual de usuario

Cornelius

Cornelius Quest Bib Option Kit Manual de usuario

Cornelius

Cornelius PearlMini Manual de usuario

Cornelius

Cornelius Millenium II Manual de usuario

Cornelius

Cornelius UF-1 Guía de configuración

Cornelius

Cornelius Quest NT 4000 Manual de usuario

Cornelius

Cornelius SUBWAY PEPSI SPIRE 3.0 Guía de configuración

Cornelius

Cornelius Cascata180 Manual

Cornelius

Cornelius VENTURE Manual de usuario

Cornelius

Cornelius In-N-Out Burger NGF 255 Manual de usuario

Cornelius

Cornelius essense Manual de usuario

Cornelius

Cornelius VIPER Manual de usuario

Cornelius

Cornelius QUEST ELITE QLT 2000 Manual

Cornelius

Cornelius IDC Pro Guía

Cornelius

Cornelius 8027 Manual de usuario

Cornelius

Cornelius Enduro 200 Manual de usuario

Cornelius

Cornelius FRUITISTA 3 Manual de usuario

Cornelius

Cornelius NITROPRO MINI Manual de usuario

Cornelius

Cornelius IDC 255 PROGATE DRIVE THRU UNIT Manual de usuario

Cornelius

Cornelius Ribbon Manual de usuario

Cornelius

Cornelius 2 Flavor Guía de instalación

Manuales populares de Dispensador de otras marcas

Silver King

Silver King Majestic SK12MAJ Guía de inicio rápido

Franke

Franke F3Dn Twin Manual de usuario

STIEBEL ELTRON

STIEBEL ELTRON UltraHot Plus Manual de usuario

DAN DRYER

DAN DRYER 282 Manual de usuario

Essity

Essity Tork 473208 Manual de usuario

CBS

CBS SD300BU-88 Guía de configuración

Sealey

Sealey MK77 Manual de usuario

Fluid Management

Fluid Management Accutinter 1600 Manual de usuario

Franke

Franke DVS SD99-010 Manual de usuario

Graco

Graco Dispensit 1053-10C Guía de solución de problemas

ITALTINTO

ITALTINTO i50 Manual de usuario

Coca-Cola

Coca-Cola FREESTYLE 9000 Manual de usuario

Graco

Graco ProMix 2KE Manual de instrucciones

TECHCON SYSTEMS

TECHCON SYSTEMS TS1251 Manual de usuario

Wayne

Wayne GLOBAL VISTA CNG Manual de usuario

clarsen

clarsen H133 Manual de usuario

PicoBrew

PicoBrew Zymatic Manual de usuario

BOWMAN

BOWMAN BP-007 Manual de usuario