Bose FreeSpace 16 Manual de usuario
©2009 Bose Corporation Reference Number 263554-SM Rev. 01
ServiceManual
FreeSpace®Model 16
Loudspeaker
1
CONTENTS
Warranty Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
Product Description . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
Disassembly/Assembly Procedures . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
Test Procedures . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
Figure 1. Free Space®Model 16 Loudspeaker Test Setup Diagram . . . . . . . . . . . . . . . . 4
Main Part List, Free Space Model 16 Loudspeaker . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
Figure 2. Free Space Model 16 Loudspeaker Exploded View . . . . . . . . . . . . . . . . . . . . 5
Packing List, Free Space Model 16 Loudspeaker . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Figure 3. Free Space Model 16 Loudspeaker Packing View . . . . . . . . . . . . . . . . . . . . . 6
CAUTION: The Bose®Free Space Model 16 Loudspeaker
contains no user serviceable parts. To prevent warranty
infractions, refer servicing to warranty service centers or
factory service.
PROPRIETARY INFORMATION
THIS DOCUMENT CONTAINS PROPRIETARY INFORMATION OF
BOSE CORPORATION WHICH IS BEING FURNISHED ONLY
FOR THE PURPOSE OF SERVICING THE IDENTIFIED BOSE
PRODUCT BY AN AUTHORIZED BOSE SERVICING CENTER OR
OWNER OF THE BOSE PRODUCT, AND SHALL NOT BE
REPRODUCED OR USED FOR ANY OTHER PURPOSE.
WARRANTY INFORMATION
The Bose Free Space Model 16 Loudspeaker is covered by a 5-year
transferable limited warranty.
2
SPECIFICATIONS
External Dimensions: 9.5 in. x 6.3 in. (240mm Diameter x 160mm Depth)
Weight: Unpacked System: 5.5 lb. (2.5 kg)
Packed System: 6.6 lb. (3 kg)
Sensitivity: 84 dBSPL, 80Hz ~ 16kHz
(1W, 1m Free Space)
Impedance: 8 ohms nominal, 6.5 ohms minimum
Power Handling: 16 Watts continuous per IEC-268-5, 96 hours.
Recommended amplifier/ Max 16 Watts.
Filter: 24db/oct Butterworth,
Hi-pass 80Hz
Lo-pass 16kHz,
PRODUCT DESCRIPTION
The Bose®Free Space®Model 16 Loudspeaker is a passive flush-mount ceiling speaker
with two variants, Model 16 and Model 16EU. The Model 16 is a world wide, general-pur-
pose use 8Ω/70V/100V speaker that complies with the requirements for Fire/Emergency
warning devices in the US. The Model 16EU is a version that includes accessories allowing
the loudspeaker to be used as a Fire/Emergency warning device in the UK.
3
DISASSEMBLY / ASSEMBLY PROCEDURES
Note: Refer to Figure 2 for the following
procedures.
1. Grille Assembly Removal
1.1 Gently pull the grille assembly (15)
away from the baffle (5). Be careful
not to mark the surface of the grille or
the baffle.
2. Grille Assembly Replacement
2.1 Gently press the grille assembly
(15) down into the baffle (5). Make
sure the grille assembly is fully seated
into the baffle.
3. Transformer, Driver & Rotary Switch
Assembly Removal
3.1 Perform procedure 1.
3.2 Using a cross-head screwdriver,
remove the six screws (1) that secure
the baffle (5) to the enclosure (10).
3.3 Make a note of the wiring configu-
ration and unplug the three wires from
the input terminals (2).
3.4 Using a sleeve barrel driver,
remove the nut that secures the rotary
switch (13) to the baffle (5).
3.5 Using a cross-head screwdriver,
remove the six screws (1) that secure
the driver (7) & transformer (11) to the
baffle.
4. Transformer, Driver & Rotary Switch
Assembly Replacement
4.1 Place the transformer (11), driver (7)
& rotary switch (13) into the baffle (5).
4.2 Secure the driver & transformer in
place using the six screws (1)
removed in procedure 3.5.
4.3 Secure the rotary switch into the
baffle using the nut removed in proce-
dure 3.4.
Note: Be sure the rotary switch is fac-
ing the right direction & make sure the
lock washer is at "7" position when
you replace the rotary switch onto the
baffle.
4.4 Respectively plug the three cable
wires onto the input terminals.Yellow
for "70/100V", white for "COM", &
blue for "8 Ω".
4.5 Secure the enclosure to the baffle
using the six screws removed in
procedure 3.2.
4.6 Perform procedure 2.
4
TEST PROCEDURES
Figure 1. Free Space®Model 16 Loudspeaker
Test Setup Diagram
1. Phase Test
1.1 Turn the rotary switch to the "8Ω"
position and apply a 6-10V DC signal
to the input terminals with the posi-
tive signal applied to the "8Ω" terminal
and negative signal applied to the
"COM" terminal.
1.2 The driver should move outward
when the DC voltage is applied.
2. Air Leak, Rub and Tick Test
2.1 Set up the system as shown in
Figure 1.
2.2 For the air leak, rub and tick, and
power sweep tests, all listening will be
done at a distance not to exceed 1
foot if the ambient noise is greater
than 65 db. An air leak is considered
to exist when audible while facing the
baffle of the speaker assembly.
2.3 Apply a 6 Vrms, 20Hz signal to the
8 ohm input with the rotary switch set
at 8 ohm to the terminals of the
loudspeaker.
Reject any speakers with air leaks.
Except for air leaks resulting from
defective driver or gaskets. Replace
any driver that has a rubbing or ticking
noise.
Small (quiet) ticks are acceptable if
they cannot be heard at a distance of
1 foot.
Note: There is a normal suspension
noise. To distinguish between a rub or
tick and suspension noise, displace
the cone slightly with your finger. If
the rubbing can be made to go away
or gets worse, then it is a rub or tick. If
the noise stays the same, it is a
suspension noise.
3. System Sweep Test
3.1 Set the rotary switch to the 8 ohm
position.
3.2 Apply a 6 Vrms, 80Hz signal to the
input terminal of the loudspeaker.
Change the oscillator frequency slowly
from 80Hz to 16kHz. Listen carefully for
buzzes, rattles, or other extraneous
noises from the driver or from the
internal parts. The whooshing noise
from the port around 80 Hz is accept-
able.
4. Transformer Tap Select Check
Apply a 70 Vrms, 100Hz signal to the
input of the loudspeaker under test.
Slowly change the tap selection, on
the unit under test, from the high
position (16W) to the 1W position. A
decrease in level should be heard for
each descending tap.
Power Amplifier
INPUT OUTPUT
Audio Signal
Generator
MAIN PART LIST
Free Space®Model 16 Loudspeaker
Figure 2. Free Space Model 16 Loudspeaker Exploded View
5
Item
Number
Description
Bose
®
®®
®
Part
Number
Vendor Part
Number
Qty.
Note
1 Screw, M4 x 12mm N/A 2910-4012-3000 16
2 Terminal 259279 4135-2381-0 3
3 Gasket for transformer N/A 4149-0111-0 1
4 Anchor, FS Model 16, White
Anchor, FS Model 16, Black 259259-002
259259-001 4154-4981-0
4154-4982-0 3
5 Baffle, White
Baffle, Black N/A
N/A 4154-5061-1
4154-5062-1 1
6 Screw N/A 2910-3575-3000 3
7 2.5” Driver, FS Model 16 296713 WF-BS021C 1
8 Cover, Junction Box 259278 1404-2801-0 1
9 Screw, Wire Clamp N/A 8901-4520-0 6
10 Enclosure, White
Enclosure, Black N/A
N/A 4154-5051-1
4154-5052-1 1
11 Transformer (DOM before 2270)
Transformer (DOM 2270 and later) 259297
263817 1806-3573-0
1806-3573-1 1 1
12 Capacitor, 10uF N/A 1571-106K-1-Y$N 1
13 Rotary Switch N/A 5200-4829-0 1
14 Clip, Retaining N/A 4135-2391-0 1
15 Grille, White
Grille, Black 296712
296711 4135-2263+1
4135-2262+1 1
16 Logo, FS Model 16 176142-1B3
4154-4991-0 1
17 Black Label N/A 3005-0514-0 1
Notes:
1. For units built before 9/27/02, use part number 259297. For units built after 9/27/02,
use part number 263817. The four underlined digits in the unit serial number located on
the product label are the date of manufacture (DOM) in Julian date format. For example,
9/27/02 would be 2270, which is the 270th day of 2002. These transformers are NOT
interchangeable.
PACKING LIST
Free Space®Model 16 Loudspeaker
Figure 3. Free Space Model 16 Loudspeaker Packing View
6
Item
Number
Description
Bose
®
®®
®
Part
Number
Vendor Part
Number
Qty.
Note
1 Carton 263622 1436-0201-1-2 1
2 Carton Sheet 263804 1450-6200-0 1
3 Inner Card, Bottom 263803 4149-6190-0 1
4 Grille, White
Grille, Black N/A
N/A 8901-4540-0
8901-4541-0 1
5 Inner Card, Middle 263802 1450-6180-0 1
6 Inner Card 1 263870 1450-6340-0 1
7 Inner Card, Top 263801 1450-6170-0 1
8 FS Model 16, White
FS Model 16, Black N/A
N/A SS-bs020c
SS-bs021c 1
9 Owner’s Manual 263556 4301-7010-2 1
SPECIFICATIONS AND FEATURES SUBJECT TO CHANGE WITHOUT NOTICE
Bose Corporation
TheMountain
Framingham Massachusetts USA 01701
P/N:263554-SMRev. 013/2009(P)FORTECHNICALASSISTANCEOR PARTORDERS,CALL1-800-233-4408
http://serviceops.bose.com
Otros manuales para FreeSpace 16
1
Tabla de contenidos
Otros manuales de Oradores de Bose
Bose
Bose DesignMax DM2C-LP Manual de usuario
Bose
Bose Companion 3 Series II Manual de usuario
Bose
Bose 131 Manual de usuario
Bose
Bose L1 Compact Manual de usuario
Bose
Bose SoundTouch 30 Series III Manual de usuario
Bose
Bose FreeSpace 32SE Instrucciones de montaje
Bose
Bose Panaray MA12 Manual de usuario
Bose
Bose SoundLink Colour Manual de usuario
Bose
Bose 301 Series IV Manual de usuario
Bose
Bose 301 Sonata Manual de usuario
Bose
Bose Home Speaker 300 Manual de usuario
Bose
Bose 301 Series III Manual de usuario
Bose
Bose SOUNDLINK REVOLVE Manual de usuario
Bose
Bose SoundLink Bluetooth Mobile Speaker II Guía de instalación
Bose
Bose Wireless Computer Speaker Manual de usuario
Bose
Bose SoundTouch20 Wi-Fi S Manual de usuario
Bose
Bose RoomMatch Utility RMU208 Manual de instrucciones
Bose
Bose FreeSpace DS 40F Manual de instrucciones
Bose
Bose SOUNDLINK FLEX Manual de usuario
Bose
Bose DesignMax DM8S Manual de usuario
