Blodgett CB36G-6-6K Manual de usuario

Project

Item No.

Quantity

Model CB36G-6-6K (two 6 gallon direct steam kettles on a 36” gas boiler

base)

KETTLES

Water resistant, 304 stainless steel construction

316 stainless steel interior cooking surface for corrosion resistance

2/3 jacketed, hemispherical design on bottom for superior heat circulation

Tilt mechanism permits kettle to tilt forward past 90° to empty

Tubular stainless steel legs containing steam control valve and conden-

sate return pipes

Reversible operating handle with heat proof knob

GAS BOILER BASE

Gas operated steam boiler rated at 15 PSI (103 kPa) operating on

115VAC, 1 phase, 60 Hz rated at 140,000 BTU

Full perimeter painted angle iron frame

Reinforced counter and boiler mountings

Stainless steel exterior

Hinged door(s) with magnetic latch

6” (152 mm) stainless steel legs with adjustable bullet feet on front and

adjustable flanged feet on rear

Thermostatically controlled drain box

All piping is confined within cabinet

Automatic water level control

Automatic boiler blowdown

Pressure gauge

Water gauge glass

Pressure control with pressure safety control

Safety relief valve

Cathodic protector

On/Off switch with indicator light

Electronic ignition

Split water lines

CSD-1 secondary low water cut off

STANDARD FEATURES

Deck mount hot and cold faucet with riser

3"(76mm) deep sinks with splash guards and grates

Startup inspection service by factory autorized service agent

One year parts and labor warranty*

* For all international markets, contact your local distributor

BLODGETT

www.blodgett.com

44 Lakeside Avenue, Burlington, VT 05401 Toll Free: (800) 331-5842 • Phone: (802) 860-3700

Fax: (802) 864-0183

OPTIONS AND ACCESSORIES

(AT ADDITIONAL CHARGE)

Power Increase

200,000 BTU boiler

250,000 BTU boiler

300,000 BTU boiler

Etched kettle markings

Gallon markings

Litre markings

Front flanged feet

Correctional package

Stainless steel back panel

208-240 VAC specify voltage

One year extended warranty

CB36G-6-6K

Two Direct Steam Kettles

on a 36” Gas Boiler Base

CB36G-6-6K GAS BOILER BASE WITH KETTLES

BLODGETT

www.blodgett.com

44 Lakeside Avenue, Burlington, VT 05401 • Toll Free: (800) 331-5842 • Phone: (802) 860-3700 • Fax: (802) 864-0183

CB36G-6-6K

SHORT FORM SPECIFICATIONS

Provide Blodgett model CB36G-6-6K (6 pan) two 6 gallon direct steam kettles on a 140,000 BTU gas boiler base base.

The kettles shall have a double wall interior to form a steam jacket around the lower 2/3 of the kettle. The bottom of the kettle shall be of hemispherical design for superior heat circula-

tion. Steam control valve mounted in leg. The tubular stainless steel mounting legs shall have the steam supply and condensate return pipes completely concealed within the leg meme-

bers. The sealed stainless steel tilt mechanism bearings shall permit the kettle to tilt forward 90° for complete emptying. A removeable operating handle with heat proof knob shall be

mounted on the left or right. Unit shall have a single support leg with nylon insert. Construction shall be all welded satin finish 304 stainless steel with a 316 stainless steel liner.

The boiler shall be suitable for operation at any pressure from 5-11 PSI (34-76 kPa) and operate on 115 VAC. Boiler shall be mounted in cabinet base. Polished stainless steel cabinet

base shall be of modular design to match other Blodgett steam equipment. Unit shall have 6” (152mm) stainless steel legs and adjustable bullet feet, reinforced stainless steel counter top

and hinged doors with magnetic latches. All piping shall be confined within the cabinet. Unit shall be automatically filled with water and brought to pressure when power switch is turned

on. Cold water condenser shall automatically condense exhausted steam in water before releasing it to drain. Boiler controls shall include automatic water level, pressure gauge, water

gauge glass, pressure control with pressure safety control, safety relief valve, cathodic protector and CSD-1 secondary low water cut off.

Unit shall have a hot and cold water faucet with control valves, 5" (152 mm) deep sink with drain and two splash guards.

Kettles and boiler shall be ASME code stamped and National Board registered. Provide options and accessories as indicated.

Printed in U.S.A. NOTE: FOR COMMERCIAL USE ONLY

NOTE: The company reserves the right to make substitutions of components without prior notice.

NOTE: SPLASH GUARD NOT SHOWN ON FRONT VIEW

DIMENSIONS ARE IN INCHES [MM]

REAR FLANGED

FOOT DETAIL

7/16" [11mm] HOLES

ON 2.5 [63] B.C.

2 EQUALLY SPACED

ELECTRICAL CONNECTION: ½”conduit connection

to controls. 120 volts, single phase with grounding

wire required unless otherwise specified..

GAS CONNECTION: 3/4” IPS supply line required.

STEAM TAKE-OFF CONNECTION: 3/4” IPS

optional to operate adjacent equipment.

COLD WATER: 3/8” O.D. tubing at 25-50 PSI

(170-345 kPa)

DRAIN: 2” IPS piped to open floor drain. No

solid connection.

SINK DRAIN: 1-1/8” O.D. tubing at 25-50 PSI

(170-345 Kpa)

31 [787]

27 [686]

18 [457]

14.5 [368]

19.33 [491]

32 [813]

6 [152]

7.5

[457]

2.75

[70]

5.75 [146]

Ø12 [305] S

6.75 [171]

8 [203]

3 [76] 2.38 [60]

26.63 [676]

10 [254]

3 [76]

36 [914]

0.63 [16]

4.88 [124]

33 [838]

APPROVAL/STAMP

P/N S00090 Rev C (5/06)

WATER SUPPLY:

Water quality is a major factor affecting the performance of your steamer. If you are

unsure of water quality, consult a local water treatment specialist and have the water

analyzed. Your water supply must be within these general guidelines:

Total dissolved solids: Less than 60 PPM Total alkalinity: Less than 20 PPM

Silica: Less than 13 PPM Chlorine: Less than 1.5 PPM

pH Factor: 7.0 - 8.5

Water which fails to meet these standards should be treated by installation of a water

conditioner. Failure or malfunction of this steamer due to poor water quality is not cov-

ered under warranty.

WATER & DRAIN CONNECTIONS:

Drain 2” (51mm) IPS piped to open floor drain. No solid connection.

24” length before open air opening (no bends or elbows)

Cold Water 3/8” (10mm) tubing at 25-50 PSI (170-345 kPa)

Steam Take Off 3/4” IPS optional to operate adjacent equipment

GAS SUPPLY:

3/4" IPS supply line required

Minimum Inlet Pressure:

Natural 7.0" W.C. static to unit

Propane 11.0" W.C. static to unit

POWER SUPPLY:

Unless otherwise specified, field wire electrical con-

nection to be 120VAC, single phase, 60 Hz with

grounding wire.

PRODUCT CLEARANCE

Right and Left side 3” (76mm)

Rear 6” (152mm)

SHIPPING INFORMATION:

Approx. Weight:

CB36G-6-6K 610 lbs. (277 kg)

Otros manuales de Pava de Blodgett

Blodgett

Blodgett KTT-10DS Manual de instrucciones

Blodgett

Blodgett KLT-20E Instrucciones de funcionamiento y seguridad

Blodgett

Blodgett KLT-12GNAT Manual del propietario

Blodgett

Blodgett KLT-20G Manual de usuario

Blodgett

Blodgett KLT-12G Manual de usuario

Blodgett

Blodgett KTG-10E Manual de instrucciones

Blodgett

Blodgett KPT-20DS Manual de usuario

Blodgett

Blodgett CB42D-10-10K Manual de usuario

Blodgett

Blodgett KTT-10DS Manual de usuario

Blodgett

Blodgett KCH-30DS Manual de usuario

Blodgett

Blodgett KLS-100G Manual de usuario

Blodgett

Blodgett KLT-20G Manual de usuario

Blodgett

Blodgett 40GS-KLS Series Manual del propietario

Blodgett

Blodgett KTG-10E Manual de usuario

Blodgett

Blodgett KLT-40GS Manual del propietario

Blodgett

Blodgett KLS-100DS Manual de usuario

Blodgett

Blodgett 40ES-KLT Series Manual del propietario

Blodgett

Blodgett KCH-30DS Manual del propietario

Blodgett

Blodgett KPS-100DS Manual de usuario

Blodgett

Blodgett KLT-12G Manual de usuario

Blodgett

Blodgett KLS-30E Guía del usuario

Blodgett

Blodgett KLS-100G Manual del propietario

Blodgett

Blodgett KLT-100E Manual del propietario

Blodgett

Blodgett KTT-10DS Manual de usuario

Manuales populares de Pava de otras marcas

IKEA

IKEA UPPHETTA Manual de usuario

Krups

Krups BW500B55 Manual de usuario

Clas Ohlson

Clas Ohlson KE7086-BH Manual de usuario

Brock

Brock WK 0902 GR Manual de usuario

inventum

inventum CBW010 Manual de usuario

Westfalia

Westfalia Retro 81 48 86 Manual de usuario

Ovente

Ovente KS88 Series Dimensiones

HUSLOG

HUSLOG AK-0832 Manual de usuario

Saturn

Saturn ST-EK840 Manual de usuario

Wilfa

Wilfa TK-1200B Manual de usuario

HOME ELEMENT

HOME ELEMENT HE-KT150 Manual de usuario

Breville

Breville Crystal Clear BKE290 Manual de usuario

ECG

ECG RK 1745 Manual de usuario

cecotec

cecotec THERMOSENSE 600 TOUCH BLACK Manual de usuario

Kalorik

Kalorik JK 39825 Manual de usuario

tomado

tomado TM-1971 Manual de usuario

Cosori

Cosori CS108-NK Manual de usuario

Electrolux

Electrolux E7K1-6BP Manual de usuario