Alliance Laundry Systems D677I_SVG Instrucciones de funcionamiento originales

Installation/Operation

Clothes Dryer

Nonmetered and metered

Electric and Gas Models

D677I_SVG

Original Instructions

Keep These Instructions for Future Reference.

(If this machine changes ownership, this manual must accompany machine.)

www.alliancelaundry.com Part No. 512680R10

November 2014

Front Matter

WARNING

FOR YOUR SAFETY, the information in this manual

must be followed to minimize the risk of fire or ex-

plosion or to prevent property damage, personal in-

jury or death.

W033

WARNING

• Do not store or use gasoline or other flammable

vapors and liquids in the vicinity of this or any

other appliance.

• WHAT TO DO IF YOU SMELL GAS:

• Do not try to light any appliance.

• Do not touch any electrical switch; do not use

any phone in your building.

• Clear the room, building or area of all occu-

pants.

• Immediately call your gas supplier from a

neighbor’s phone. Follow the gas supplier’s in-

structions.

• If you cannot reach your gas supplier, call the

fire department.

• Installation and service must be performed by a

qualified installer, service agency or the gas sup-

plier.

W052

IMPORTANT: Purchaser must consult the local gas

supplier for suggested instructions to be followed if

the dryer user smells gas. The gas utility instructions

plus the SAFETY and WARNING note directly above

must be posted in a prominent location near the dryer

for customer use.

WARNING

• Installation of unit must be performed by a quali-

fied installer.

• Install clothes dryer according to manufacturer’s

instructions and local codes.

• DO NOT install a clothes dryer with flexible plas-

tic venting materials. If flexible metal (foil type)

duct is installed, it must be of a specific type

identified by the appliance manufacturer as suita-

ble for use with clothes dryers. Refer to section

on connecting exhaust system. Flexible venting

materials are known to collapse, be easily crush-

ed, and trap lint. These conditions will obstruct

clothes dryer airflow and increase the risk of fire.

W729R1

WARNING

FOR YOUR SAFETY

Do not store or use gasoline or other flammable vapors and

liquids in the vicinity of this or any other appliance.

W053

The following information applies to the state of Massachusetts,

USA.

• This appliance can only be installed by a Massachusetts li-

censed plumber or gas fitter.

• This appliance must be installed with a 36 inch [910 mm]

long flexible gas connector.

• A “T-Handle” type gas shut-off valve must be installed in the

gas supply line to this appliance.

• This appliance must not be installed in a bedroom or bath-

room.

Front Matter

Part No. 512680R10 © Copyright, Alliance Laundry Systems LLC - DO NOT COPY or TRANSMIT 3

Table of Contents

Front Matter.......................................................................................... 3

Safety Information..................................................................................7

Explanation of Safety Messages....................................................................... 7

Important Safety Instructions........................................................................... 7

Dimensions............................................................................................. 9

Installation........................................................................................... 14

Before You Start...........................................................................................14

Tools........................................................................................................14

Card Reader Models.................................................................................. 14

Order of Installation Steps..........................................................................14

Position and Level the Dryer..........................................................................14

Connect Dryer Exhaust System...................................................................... 17

Exhaust Direction......................................................................................19

Exhaust System.........................................................................................19

Multi-Dryer Installation Exhaust Requirements............................................19

Gas Dryers - Connect Gas Supply Pipe........................................................... 22

Electric Dryer Only - Connect Electrical Plug..................................................24

Earth/Ground Information.......................................................................... 24

Connecting Power Cord with Three-Wire Plug.............................................25

Connecting Power Cord with Four-Wire Plug.............................................. 27

Reverse Door, if Desired............................................................................... 28

Wipe Out Inside of Dryer.............................................................................. 30

Plug In the Dryer.......................................................................................... 30

Electric Dryer........................................................................................... 30

Gas Dryer................................................................................................. 30

Grounding Information.............................................................................. 31

Recheck Steps.............................................................................................. 31

Check Heat Source........................................................................................31

Electric Dryers.......................................................................................... 31

Gas Dryers................................................................................................31

Vending....................................................................................................... 32

Meter Case............................................................................................... 32

Coin Slide Control.....................................................................................33

Setting Dry Time Dipswitches.................................................................... 33

Dipswitch Settings.....................................................................................35

Test Setting...............................................................................................37

Slide Extension Assembly – Models through Serial No. 1211........................37

Slide Extension Assembly – Models Starting Serial No. 1211........................39

Additional Dryer Security.......................................................................... 41

written consent of the publisher.

Part No. 512680R10 © Copyright, Alliance Laundry Systems LLC - DO NOT COPY or TRANSMIT 4

Operation............................................................................................. 42

Operation Instructions for Nonmetered and Coin Slide Dryers.......................... 42

Clean Lint Filter........................................................................................42

Load Laundry........................................................................................... 42

Close Loading Door...................................................................................42

Set Fabric Selector.....................................................................................42

Start Dryer................................................................................................43

Operation Instructions for Electronic Display Control Dryers............................43

Clean Lint Filter........................................................................................43

Load Laundry........................................................................................... 44

Close Loading Door...................................................................................44

Set Fabric Selector.....................................................................................44

Insert Coins or Card...................................................................................44

Start Dryer................................................................................................45

Indicator Lights.........................................................................................45

Operation Instructions for MDC Dryers.......................................................... 45

Clean Lint Filter........................................................................................46

Load Laundry........................................................................................... 46

Close Loading Door...................................................................................46

Set Fabric Selector.....................................................................................46

Insert Coins or Card...................................................................................46

Start Dryer................................................................................................47

Indicator Lights.........................................................................................47

Operation Instructions for NetMaster Dryers................................................... 47

Clean Lint Filter........................................................................................47

Load Laundry........................................................................................... 48

Close Loading Door...................................................................................48

Set Fabric Selector.....................................................................................48

Insert Coins or Card...................................................................................48

Start Dryer................................................................................................49

Indicator Lights.........................................................................................49

Maintenance......................................................................................... 50

Lubrication...................................................................................................50

Care of Your Dryer....................................................................................... 50

Dryer Interior............................................................................................50

Cabinet.....................................................................................................50

Control Panel............................................................................................ 50

Exhaust System.........................................................................................50

Lint Filter.....................................................................................................50

Motor Overload Protector.............................................................................. 51

For Energy Conservation............................................................................... 51

Troubleshooting....................................................................................52

Contact Information............................................................................. 54

Part No. 512680R10 © Copyright, Alliance Laundry Systems LLC - DO NOT COPY or TRANSMIT 5

Installer Checklist.................................................................................55

6 © Copyright, Alliance Laundry Systems LLC - DO NOT COPY or TRANSMIT Part No. 512680R10

Safety Information

Explanation of Safety Messages

Precautionary statements (“DANGER,” “WARNING,” and

“CAUTION”), followed by specific instructions, are found in this

manual and on machine decals. These precautions are intended

for the personal safety of the operator, user, servicer, and those

maintaining the machine.

DANGER

Indicates an imminently hazardous situation that, if

not avoided, will cause severe personal injury or

death.

WARNING

Indicates a hazardous situation that, if not avoided,

could cause severe personal injury or death.

CAUTION

Indicates a hazardous situation that, if not avoided,

may cause minor or moderate personal injury or

property damage.

Additional precautionary statements (“IMPORTANT” and

“NOTE”) are followed by specific instructions.

IMPORTANT: The word “IMPORTANT” is used to in-

form the reader of specific procedures where minor

machine damage will occur if the procedure is not fol-

lowed.

NOTE: The word “NOTE” is used to communicate in-

stallation, operation, maintenance or servicing informa-

tion that is important but not hazard related.

Important Safety Instructions

Save These Instructions

WARNING

To reduce the risk of fire, electric shock, or injury to

persons when using your dryer, follow these basic

precautions:

W034

• Read all instructions before using the dryer.

• Install this dryer according to the INSTALLATION IN-

STRUCTIONS. Refer to the EARTH/GROUND INSTRUC-

TIONS in the INSTALLATION manual for the proper earth/

ground connection of the dryer. All connections for electrical

power, earth/ground and gas supply must comply with local

codes and be made by licensed personnel when required. Do

not do it yourself.

• Do not install or store the dryer where it will be exposed to

water and/or weather.

• Do not dry articles that have been previously cleaned in,

washed in, soaked in, or spotted with gasoline or machine

oils, vegetable or cooking oils, cleaning waxes or chemicals,

dry-cleaning solvents, thinner, anything containing chemicals

such as in mops and cleaning cloths, or other flammable or

explosive substances as they give off vapors that could ignite,

explode or cause fabric to catch on fire by itself.

• Items that have been soiled with substances such as cooking

oil, acetone, alcohol, petrol, kerosene, spot removers, turpen-

tine, waxes and wax removers, should be washed in hot water

with an extra amount of detergent before being dried in the

tumble dryer.

• To reduce the risk of fire, DO NOT DRY plastics or articles

containing foam or latex rubber or similarly textured rubber-

like materials, such as shower caps, water proof textiles, rub-

ber-backed articles, and clothes or pillows filled with foam

rubber pads.

• Do not tumble fiberglass curtains and draperies unless the la-

bel says it can be done. If they are dried, wipe out the cylinder

with a damp cloth to remove particles of fiberglass.

• Do not allow children to play on or in the dryer. Close super-

vision of children is necessary when the dryer is used near

children. This appliance is not intended for use by persons

(including children) with reduced physical, sensory or mental

capabilities, or lack of experience and knowledge, unless they

have been given supervision or instruction concerning the use

of the appliance by a person responsible for their safety. This

is a safety rule for all appliances.

• Do not reach into the dryer if the cylinder is revolving.

• Use the dryer only for its intended purpose, drying clothes.

ALWAYS follow the fabric care instructions supplied by the

garment manufacturer and only use the dryer drum to dry tex-

tiles that have been washed in water.

Safety Information

Part No. 512680R10 © Copyright, Alliance Laundry Systems LLC - DO NOT COPY or TRANSMIT 7

• Always read and follow manufacturer’s instructions on pack-

ages of laundry and cleaning aids. Heed all warnings or pre-

cautions. To reduce the risk of poisoning or chemical burns,

keep them out of reach of children at all times (preferably in a

locked cabinet).

• Remove laundry immediately after the dryer stops.

• DO NOT operate the dryer if it is smoking, grinding or has

missing or broken parts or removed guards and/or panels. DO

NOT tamper with the controls or bypass any safety devices.

• Dryer will not operate with the loading door open. DO NOT

bypass the door safety switch by permitting the dryer to oper-

ate with the door open. The dryer will stop tumbling when the

door is opened. Do not use the dryer if it does not stop tum-

bling when the door is opened or starts tumbling without

pressing the START mechanism. Remove the dryer from use

and call the service person.

• ALWAYS clean the lint filter after every load. A layer of lint

in the filter reduces drying efficiency and prolongs drying

time. Keep area around the exhaust opening and adjacent sur-

rounding area free from the accumulation of lint, dust and

dirt. The interior of the dryer and the exhaust duct should be

cleaned periodically by qualified service personnel.

• Do not repair or replace any part of the dryer, or attempt any

servicing unless specifically recommended in the user-main-

tenance instructions or in published user-repair instructions

that you understand and have the skills to carry out. AL-

WAYS disconnect the electrical power to the dryer before at-

tempting service. Disconnect the power cord by grasping the

plug, not the cord.

• If supply cord is damaged, it must be replaced by a special

cord or assembly available from the manufacturer or its serv-

ice agent.

• Before the dryer is removed from service or discarded, re-

move the door to the drying compartment.

• Failure to install, maintain, and/or operate this machine ac-

cording to the manufacturer’s instructions may result in con-

ditions which can produce bodily injury and/or property dam-

age.

NOTE: The WARNING and IMPORTANT SAFETY IN-

STRUCTIONS appearing in this manual are not meant

to cover all possible conditions and situations that may

occur. Observe and be aware of other labels and pre-

cautions that are located on the machine. They are in-

tended to provide instruction for safe use of the ma-

chine. Common sense, caution and care must be exer-

cised when installing, maintaining, or operating the

dryer.

Always contact your dealer, distributor, service agent or the man-

ufacturer about any problems or conditions you do not under-

stand.

Safety Information

8 © Copyright, Alliance Laundry Systems LLC - DO NOT COPY or TRANSMIT Part No. 512680R10

Dimensions

Nonmetered Models

Electric Models

DRY2471N_SVG

KJI

A 21.56 in. [548 mm]

B *4.5 in. [114 mm]

C *36 in. [914 mm]

D *40.19 in. [1020 mm]

E *15.44 in. [392 mm]

F *43 in. [1092 mm]

G 4.0 in. [102 mm]

H 15.4 in. [391 mm]

I 26.875 in. [683 mm]

J 0.4 in. [10 mm]

K 8 in. [203 mm]

L 28 in. [711 mm]

M 23.5 in. [597 mm]

NOTE: Exhaust openings are 4 inch [102 mm] metal

ducting.

* With leveling legs turned into base.

Dimensions

Part No. 512680R10 © Copyright, Alliance Laundry Systems LLC - DO NOT COPY or TRANSMIT 9

Gas Models

DRY2472N_SVG

ML K

1. 3/8 in. N.P.T. Gas Connection

A 21.56 in. [548 mm]

B *4.5 in. [114 mm]

C *36 in. [914 mm]

D *40.19 in. [1020 mm]

E *15.44 in. [392 mm]

F *43 in. [1092 mm]

G *2.8 in. [70 mm]

H 2.3 in. [60 mm]

I 15.4 in. [391 mm]

J 26.875 in. [683 mm]

K 4 in. [102 mm]

L 0.4 in. [10 mm]

M 8 in. [203 mm]

N 28 in. [711 mm]

O 23.5 in. [597 mm]

NOTE: Exhaust openings are 4 inch [102 mm] metal

ducting.

* With leveling legs turned into base.

Dimensions

Tabla de contenidos

Otros manuales de Secadora de Alliance Laundry Systems

Alliance Laundry Systems

Alliance Laundry Systems 000 BTU Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems AT170FG Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems W800 Guía de solución de problemas

Alliance Laundry Systems

Alliance Laundry Systems CA120L Manual del propietario

Alliance Laundry Systems

Alliance Laundry Systems EE1010 Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems ADE3TFWS431AW01 Instrucciones de funcionamiento

Alliance Laundry Systems

Alliance Laundry Systems Drying Tumblers 175 Pound Capacity Instrucciones de funcionamiento

Alliance Laundry Systems

Alliance Laundry Systems 504522R3 Manual del propietario

Alliance Laundry Systems

Alliance Laundry Systems DRY722C-SVG Guía

Alliance Laundry Systems

Alliance Laundry Systems SFG109*F Guía

Alliance Laundry Systems

Alliance Laundry Systems 25 Series Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems SDE907 Guía

Alliance Laundry Systems

Alliance Laundry Systems Drying Tumblers 50 Pound Capacity 75 Pound Capacity Model Identification Part No.... Manual del propietario

Alliance Laundry Systems

Alliance Laundry Systems Drying Tumbler 110 Pound Capacity Part No.... Manual de instalación y operación

Alliance Laundry Systems

Alliance Laundry Systems CHD25G2 Instrucciones de funcionamiento

Alliance Laundry Systems

Alliance Laundry Systems D677I Guía

Alliance Laundry Systems

Alliance Laundry Systems LES33 Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems 25 Series Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems 120 Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems PD3JGBGS403UG01 Manual del propietario

Alliance Laundry Systems

Alliance Laundry Systems TR3003WN Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems 505828 Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems DR7000WE Manual de usuario

Alliance Laundry Systems

Alliance Laundry Systems DRY725C Manual de usuario

Manuales populares de Secadora de otras marcas

Bosch

Bosch WTA79200GB Manual de usuario

Amana

Amana W10233410A Manual de usuario

Miele

Miele TWH 780 WP Manual de usuario

Asko

Asko T760 Manual de usuario

Bosch

Bosch Logixx 10 WTB76556GB Hoja de especificaciones

STIEBEL ELTRON

STIEBEL ELTRON Ultronic S Manual de instrucciones

Electrolux

Electrolux EW2H328R2 Manual de usuario

Beko

Beko DS8433RX1M Manual de usuario

Dawlance

Dawlance Spinner DS 6000 C Manual de usuario

Electrolux

Electrolux TP5080TW Manual de usuario

AEG

AEG TR838P4OB Manual de usuario

Indesit

Indesit IDV 75 Manual de usuario

Infiniton

Infiniton SD-DG85C Manual de usuario

BOMANN

BOMANN WT 5019 Manual de usuario

Asko

Asko T793C Manual de usuario

Kenmore

Kenmore 8041 - 5.8 cu. Ft. Capacity Electric Dryer Manual de usuario

Frigidaire

Frigidaire CAQE7077KW0 Manual del propietario

Bosch

Bosch WTX8HKM9SN Manual de usuario