Alliance Laundry Systems BDEE6BGS173CW01 Instrucciones de funcionamiento
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
© Copyright 2018 Alliance Laundry Systems LLC
All rights reserved. No part of the contents of this book may be reproduced or transmitted in any form or by any means without
the expressed written consent of the publisher.
D515518ENR2 1
Table of
Contents
Section 1 – Safety Information
Locating an Authorized Servicer ..................................................... 4
Section 2 – Introduction
Customer Service ............................................................................ 5
Nameplate Location ........................................................................ 5
Model Identification ........................................................................ 6
How Your Dryer Works .................................................................. 7
Section 3 – Troubleshooting
1. Dryer Motor Does Not Run ...................................................... 9
2. Dryer Stops in Cycle; Quits After the First Few Loads; Has a
Burning Smell; Cycles On Motor Thermal Protector ............... 11
3. Dryer Motor Runs But Cylinder Does Not Turn ...................... 12
4. Dryer Motor Does Not Stop ..................................................... 13
5. Dryer Runs Only When Door is Open ..................................... 14
6. Dryer Heating Assembly Does Not Heat or Burner
Does Not Ignite ......................................................................... 15
7. Igniter Does Not Glow (Gas Supply Sufficient) –
Gas Dryer Models ..................................................................... 17
8. Burner Ignites and Goes Out Repeatedly –
Gas Dryer Models ..................................................................... 18
9. Igniter Glows But Burner Does Not Ignite –
Gas Dryer Models ..................................................................... 19
10. Dryer Heater Assembly or Burner Shuts Off Prematurely ....... 20
11. Dryer Heater Assembly or Burner Repeatedly Cycles Off
On Limit Thermostat ................................................................ 21
12. Dryer Heater Assembly or Burner Does Not Shut Off ............. 23
13. Clothes Do Not Dry in Dryer ................................................... 24
14. Timer/Electronic Control Does Not Advance
in Automatic Cycle ................................................................... 25
15. Clothes Are Too Hot When Removed From Dryer .................. 26
16. Excessive Chattering or Vibrating Noise in Dryer ................... 27
17. Excessive Humming or Whistling Noise in Dryer ................... 28
Section 4 – Error Codes
Section 5 – Adjustments
18. Leveling Legs ........................................................................... 31
19. Burner Flame (Gas Models) ..................................................... 32
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
2D515518ENR2
Section 6 – Test Procedures
20. Timer Contacts ......................................................................... 34
21. Fabric Selector Switch .............................................................. 35
22. Drive Motor .............................................................................. 36
23. Motor Switch ............................................................................ 39
24. Burner System Operation ......................................................... 41
25. Electrical Circuit To Ignition System (Gas Models) ................ 42
26. Gas Valve Coils Check (Gas Models) ...................................... 42
27. Sensor Check (Gas Models) ..................................................... 43
28. Igniter Check (Gas Models) ..................................................... 43
29. Thermal Fuse (Electric Models) ............................................... 43
30. Heater Assembly (Electric Models) ......................................... 44
31. Cycling or Limit Thermostat .................................................... 44
32. Door Switch .............................................................................. 44
Section 7 – Internal Wiring of Dryer Motor Switch
D515518ENR2 3
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
Section 1
Safety Information
Throughout this manual and on machine decals, you will find precautionary statements (“CAUTION,”
“WARNING” and “DANGER”) followed by specific instructions. These precautions are intended for the personal
safety of the operator, user, servicer, and those maintaining the machine.
DANGER
Danger indicates an imminently hazardous situation that, if not avoided, will cause severe personal injury or death.
WARNING
Warning indicates a hazardous situation that, if not avoided, could cause severe personal injury or death.
CAUTION
Caution indicates a hazardous situation that, if not avoided, may cause minor or moderate personal injury or
property damage.
Additional precautionary statements (“IMPORTANT” and “NOTE”) are followed by specific instructions.
IMPORTANT
The word “IMPORTANT” is used to inform the reader of specific procedures where minor machine damage will
occur if the procedure is not followed.
NOTE
The word “NOTE” is used to communicate installation, operation, maintenance or servicing information that is
important but not hazard related.
In the interest of safety, some general precautions relating to the operation of this machine follow.
• Failure to install, maintain, and/or operate this machine according to the manufacturer’s
instructions may result in conditions which can produce serious injury, death and/or
property damage.
• Do not repair or replace any part of the machine or attempt any servicing unless specifically
recommended or published in this Service Manual and that you understand and have the
skills to carry out.
• Whenever ground wires are removed during servicing, these ground wires must be
reconnected to ensure that the machine is properly grounded and to reduce the risk of fire,
electric shock, serious injury, or death.
W284
WARNING
4D515518ENR2
Section 1 Safety Information
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
NOTE: The WARNINGS and IMPORTANT INSTRUCTIONS appearing in this manual are not meant to
cover all possible conditions and situations that may occur. Common sense, caution and care must be
exercised when installing, maintaining or operating the machine.
Always contact your dealer, distributor, service agent or the manufacturer about any problems or conditions you do
not understand.
Locating an Authorized Servicer
Alliance Laundry Systems is not responsible for personal injury or property damage resulting from improper
service. Review all service information before beginning repairs.
Warranty service must be performed by an authorized technician, using authorized factory parts. If service is
required after the warranty expires, Alliance Laundry Systems also recommends contacting an authorized
technician and using authorized factory parts.
To reduce the risk of electric shock, fire, explosion, serious injury or death:
• Disconnect electric power to the dryer(s) before servicing.
• Close gas shut-off valve to gas dryer(s) before servicing.
• Never start the dryer(s) with any guards/panels removed.
• Whenever ground wires are removed during servicing, these ground wires must be
reconnected to ensure that the dryer is properly grounded.
W001R1
WARNING
Repairs that are made to your products by unqualified persons can result in hazards due to
improper assembly or adjustments subjecting you, or the inexperienced person making such
repairs, to the risk of serious injury, electrical shock, or death.
W007
WARNING
If you or an unqualified person perform service on your machine, you must assume the
responsibility for any personal injury or property damage which may result. The manufacturer
will not be responsible for any injury or property damage arising from improper service and/or
service procedures.
W286
WARNING
D515518ENR2 5
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
Section 2
Introduction
Customer Service
If literature or replacement parts are required, contact
the source from whom the machine was purchased or
contact Alliance Laundry Systems at
+1 (920) 748-3950 for the name and address of the
nearest authorized parts distributor.
For technical assistance, call +1 (920) 748-3121.
Nameplate Location
When calling or writing about your product, be sure to
mention model and serial numbers. Model and serial
numbers are located on nameplate(s) as shown.
DRY2527N
Nameplate
6D515518ENR2
Section 2 Introduction
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
Model Identification
Information in this manual is applicable to these
dryers:
BDEE6BGS173CW01
BDEE6BGS173TW01
BDGE6BGS113CW01
BDGE6BGS113TW01
FDEE7RGS403UW01
FDLE7RGS303NW26
LDE30RGS543FW28
LDEA5RGS173TW01
LDEA5RGS173TW04
LDEE5BGS153TW01
LDEE5BGS173CW01
LDEE5BGS173TW01
LDEE5BGS303ZW30
LDEE5BGS543FW01
LDEE5RGS453UW01
LDEE7RGS153CW01
LDEE7RGS173CW01
LDEE7RGS303EW01
LDEE7RGS303UW01
LDEE7RGS403UW01
LDEE7RGS453UW01
LDEE7RGS543FW01
LDEE7RWS173TW01
LDG30RGS113FW28
LDGA5RGS113TW01
LDGE5BGS113CW01
LDGE5BGS113FW01
LDGE5BGS113TW01
LDGE7RGS113CW01
LDGE7RGS113FW01
LDGE7RGS303EW01
LDGE7RGS303EW80
LDGE7RSS303UW01
LDGE7RWS113TQ01
LDGE7RWS113TW01
LDGE7RWS303UW01
LDLE5BGS303NW26
LDLE5RGS303NW35
LDLE5RGS303UW01
LDLE7RGS303LW01
LDLE7RGS303LW26
LDLE7RWS303NW26
LSEA5FGS153TW01
LSEA5FGS153TW04
LSEA5FGS173TW01
LSEA5FGS173TW04
LSEE5AGS153TW01
LSEE5AGS173TW01
LSEE5AGW153TW01
LSEE5AGW173TW01
LSEE5AGW283CW01
LSEE5AGW293CW01
LSGA5FGS113TW01
LSGE5AGS083NW01
LSGE5AGS103NW01
LSGE5AGS113TW01
LSGE5AGW093CW01
LSGE5AGW113TW01
LSLE5AGS303LW01
LSLE5AGS303LW26
LSLE5AGS303NW22
LSLE5AGS303NW35
LSLE5AGW543NW23
LSLE5AGW543ZW01
PDEE4RGS173CG01
PDEE4RGS173CW01
PDEE4RGS173TG01
PDEE4RGS173TW01
PDEE4RGS433AG01
PDGE3BGS113CG01
PDGE3BGS113CW01
PDGE3BGS113TG01
PDGE3BGS113TW01
PDGE4RGS113CG01
PDGE4RGS113CW01
PDGE4RGS113TG01
PDGE4RGS113TW01
PDGE4RGS303AG01
UDEE5BGS173CW01
UDEE5BGS173CW08
UDGE5BGS113TW01
YDEE5BGS173CW01
YDEE7RGS153CW01
YDEE7RGS153TW01
YDEE7RGS173CW01
YDEE7RGS173TW01
YDEE7RGS303EW01
YDEE7RGS303UW01
YDEE7RGS403UW01
YDGE5BGS113CW01
YDGE7RGS113CW01
YDGE7RGS113TW01
YDGE7RGS303EW01
YDLE7RGS303NW26
YSEE5AGS153TW01
YSEE5AGS173TW01
YSGE5AGS113TW01
D515518ENR2 7
Section 2 Introduction
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
How Your Dryer Works
The dryer uses heated air to dry loads of laundry. When
the motor is started, the exhaust fan pulls room
temperature air in through louvers at the rear of the
dryer and over the heat source (burner flame for gas
and heating element for electric). The heated air moves
through the heater duct and into the cylinder, where it
circulates through the wet load. The air then passes
through the lint filter, air duct, and exhaust fan, where
it is vented to the outdoors.
DRY1819S
Lint
Filter
Cylinder
Heater
Duct Blower
Fan
8D515518ENR2
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
Section 3
Troubleshooting
IMPORTANT: Refer to wiring diagram for aid in testing dryer components.
To reduce the risk of electric shock, fire, explosion, serious injury or death:
• Disconnect electric power to the dryer(s) before servicing.
• Close gas shut-off valve to gas dryer(s) before servicing.
• Never start the dryer(s) with any guards/panels removed.
• Whenever ground wires are removed during servicing, these ground wires must be
reconnected to ensure that the dryer is properly grounded.
W001R1
WARNING
Este manual sirve para los siguientes modelos
96
Tabla de contenidos
Otros manuales de Secadora de Alliance Laundry Systems
Alliance Laundry Systems
Alliance Laundry Systems LEB07A*-1709 Manual de usuario
Alliance Laundry Systems
Alliance Laundry Systems DC0220SFG Manual de usuario
Alliance Laundry Systems
Alliance Laundry Systems CA120L Manual del propietario
Alliance Laundry Systems
Alliance Laundry Systems HSA030N Manual de usuario
Alliance Laundry Systems
Alliance Laundry Systems DRY2030N Manual de usuario
Alliance Laundry Systems
Alliance Laundry Systems 513123 Manual de usuario
Alliance Laundry Systems
Alliance Laundry Systems LES33 Manual de usuario
Alliance Laundry Systems
Alliance Laundry Systems JCD32DG Manual de usuario
Alliance Laundry Systems
Alliance Laundry Systems LWS01M series Manual de usuario
Alliance Laundry Systems
Alliance Laundry Systems SFG109*F Guía
Alliance Laundry Systems
Alliance Laundry Systems SFE107*A Manual de usuario
Alliance Laundry Systems
Alliance Laundry Systems 120 Manual de usuario
Alliance Laundry Systems
Alliance Laundry Systems 602004144 Guía de solución de problemas
Alliance Laundry Systems
Alliance Laundry Systems T433I Manual de usuario
Alliance Laundry Systems
Alliance Laundry Systems DRY735C SVG Series Manual de usuario
Alliance Laundry Systems
Alliance Laundry Systems DR7000WE Manual de usuario
Alliance Laundry Systems
Alliance Laundry Systems CHD25G2-CA025L Manual del propietario
Alliance Laundry Systems
Alliance Laundry Systems D677I Guía
Alliance Laundry Systems
Alliance Laundry Systems Drying Tumbler Manual del propietario
Alliance Laundry Systems
Alliance Laundry Systems 25 Pound Capacity Manual de usuario
Alliance Laundry Systems
Alliance Laundry Systems TLW1991N Manual de usuario
Alliance Laundry Systems
Alliance Laundry Systems DRY725C_SVG Manual de usuario
Alliance Laundry Systems
Alliance Laundry Systems 503806R1 Manual de usuario
Alliance Laundry Systems
Alliance Laundry Systems Speed Queen FF7009WN Manual de usuario
