Agri-Fab 501885A Manual de usuario

Step One

1) Remove rear door 2) Spread parts out in your work area

Step Two

1) Cut the straps holding the cart to the wooden pallet and

tilt the cart body off the pallet. Turn the cart onto its back-

side until it is standing upright.

Step Three

1) Securely lock the tongue to the latch stand bracket by

the latch lock lever (lock the tongue into the 'W').

2) Install the axle through the wheel support and the rear

tongue section.

Step Four

1) Assemble a spacer tube onto each end of the axle.

2) Install a 1" flat washer, a wheel (valve stem facing out),

and another 1" flat washer onto the axle.

3) Secure the wheel with a cotter pin, spreading the ends

so that a hub cap can fit over the pin.

4) Snap the hub cap into place by pressing it onto the flat

washer.

5) Repeat on the other side of the axle.

Model 501885A / 502492A Assembly Instructions

Tools needed:

1/2 inch wrench

9/16 inch wrench

1/2 inch socket

9/16 inch socket

Pliers

Standard screwdriver

Use in place of Cart assembly instructions in owner’s manual. Refer to owner’s manual for: Deck

Adapter assembly instructions and Safety, Operation, Maintenance, Storage and Troubleshooting instructio

Form 48708

Step Five

1) Flip cart over so it rests on the wheels

2) Assemble front tongue on top of rear tongue using

three 3/8" x 3" hex bolts and 3/8" Q\ORFNQXWV

Hint: Ease assembly by supporting the rearWRQJXHZLWK

a block of wood.

Step Six

1) Attach the engine/impeller housing assembly to the

upper holes in the angles welded to the tongue. Use four

5/16" x 3/4" hex bolts, 5/16" IODW washers and 5/16" nylock

nuts.

Step Seven

1) Assemble the elbow to the impeller housing using four

5/16" x 3/4" self tapping hex bolts and four nylon washers.

Push while turning to help start the bolts into the unthread-

ed holes.

2) To center the elbow with the opening in the hard top:

a. Push the vinyl boot back inside the opening

b. Loosen the bolts tightened in step six by

approximately ¼ turn each

c. Push against the elbow to center it with the sides of

the opening

d. Retighten the four bolts that you loosened

3) 0DNHVXUH the hose adapter (nozzle) LVVHFXUHO\DWWDFKHG

to the front of the impeller housingDQG the switch

actuator bracket contacts the housing switch.

4) Place a hose clamp onto the end of the hose and push it

onto the hose adapter (nozzle). Tighten hose clamp onto

hose and hose adapter but do not collapse hose adapter.

Step Eight (not shown)

1) Place the hose hanger rod assembly into the hose

hanger bracket on the impeller housing assembly.

2) Loop the 25" tarp strap under the hose. Fasten the

hooks to the hose hanger rod assembly.

Model 501885A / 502492A Assembly Instructions Form 48708

Step Nine (for Chip-n-Vac model only)

Hint: Tip the cart bed back for easier access in this step.

1) Attach the chipper chute assembly to the weld bolts on

the back side of the impeller housing using three 5/16” flat

washers and 5/16” Nylock nuts. Tighten.

2) Insert the tamper plug into the end of the chipper chute

assembly.

Este manual sirve para los siguientes modelos

Otros manuales de Carrito para exteriores de Agri-Fab

Agri-Fab

Agri-Fab 45-0345-062 Manual de usuario

Agri-Fab

Agri-Fab 45-02265 Manual de usuario

Agri-Fab

Agri-Fab Explorer 45-0175 Manual de usuario

Agri-Fab

Agri-Fab 14 cu. ft. Farm/Yard Cart 45-01772 Manual de usuario

Agri-Fab

Agri-Fab 45-03453 Manual de usuario

Agri-Fab

Agri-Fab 45-01772 Manual de usuario

Agri-Fab

Agri-Fab Explorer 45-0175 Manual de usuario

Agri-Fab

Agri-Fab 45-01754 Manual de uso y cuidado

Agri-Fab

Agri-Fab 45-02263 Manual de usuario

Agri-Fab

Agri-Fab 45-0345 Manual de usuario

Agri-Fab

Agri-Fab 45-01754 Manual de usuario

Agri-Fab

Agri-Fab Repair Parts For Utility Carts 190-425A Manual de uso y cuidado

Agri-Fab

Agri-Fab 45-01011 Manual de usuario

Agri-Fab

Agri-Fab 45-0351 Manual de usuario

Agri-Fab

Agri-Fab Utility Cart 45-01001 Manual de usuario

Agri-Fab

Agri-Fab Poly Lawn Cart 45-02264 Manual de usuario

Agri-Fab

Agri-Fab 45-02261 Manual de usuario

Agri-Fab

Agri-Fab 7 cu ft. Farm/Garden Cart 45-01761 Manual de usuario

Agri-Fab

Agri-Fab 45-01012 Manual de usuario

Agri-Fab

Agri-Fab 45-0270 Manual de usuario

Agri-Fab

Agri-Fab 45-0528 Manual de usuario

Agri-Fab

Agri-Fab 45-0350 Manual de uso y cuidado

Agri-Fab

Agri-Fab 45-0554 Manual de usuario

Agri-Fab

Agri-Fab 45-02175 Manual de uso y cuidado

Manuales populares de Carrito para exteriores de otras marcas

Costway

Costway TH10057 Manual de usuario

Vivo

Vivo CART-PC02S Manual de usuario

Ergotron

Ergotron STYLEVIEW SV42-3162-1 Manual de usuario

VEVOR

VEVOR SC01 Manual de usuario

Carts Vermont

Carts Vermont 20 Manual de usuario

Vivo

Vivo CART-PC01 Manual de usuario

Costway

Costway TL0400 Manual de usuario

XPOtool

XPOtool 30261 Manual de usuario

Branick

Branick 130 Manual de uso y cuidado

Anthro

Anthro PrinterCart Manual de usuario

Westward

Westward 2CZY4 Manual de servicio

Hupfer

Hupfer TTW/V Manual de usuario

Gorilla Carts

Gorilla Carts GCR-10P Manual de usuario

Numatic

Numatic EcoMatic EM-5 Manual de usuario

Bosch

Bosch XL-Cart Instrucciones de montaje

Tennsco

Tennsco Modular Cart Top Component Assembly Manual de instrucciones

Makita

Makita DCU601 Manual de usuario

Clam

Clam POLAR TRAILER HD MAX Manual de usuario