AFe Power 50-70007D Manual de usuario

Momentum HD Cold Air Intake System

Instruction Manual P/N: 50-70007D / 50-70007T__ __ ________________________

Make: Ford Model: Super Duty F-250/F350 Year: 2020-2021 Engine: V8-6.7L (td)

Page 2

• Please read the entire instruction manual before proceeding.

• Ensure all components listed are present.

• For technical support please call 951-493-7185.

• Ensure you have all necessary tools before proceeding.

• Do not attempt to work on your vehicle when the engine is hot.

• Retain factory parts for future use.

Label

Qty.

Description

Part Number

Air Filter (Pro 5R)

24-91061

Air Filter (Pro DRY S)

21-91061

Tube

05-5070007B1

Housing

05-5070007B2

Coupling, Silicone Bellows

05-01430

Clamp, T-bolt (4-9/16" - 4-7/8")

03-50319

Seal, Trim

05-01553

Clamp, T-bolt (8-5/16" - 8-5/8")

03-50267

Plug, Silicone

05-01429

Screw, Torx: M4x10mm

03-50490

Retainer Clip

05-01554

Fixing Clamp, 3/4"ID

03-50234

Washer, Flat: M6

03-50070

Screw, Hex Hd: M6x1x20, Gr 8.8

03-50057

Installation will require the following tools:

Panel clip remover, T20 Torx driver, 7mm & 10mm nut drivers, 7mm socket, 10” extension, 11mm deep

socket and driver

Emissions Disclaimer: This product is not currently CARB exempt and is not available for purchase in

California or for use on any vehicle registered with the California Department of Motor Vehicles.

Page 3

A1/A2

Page 4

Refer to Figure A for Step 1

Step 1: Using a 7mm nut driver, loosen the clamps 1 at the turbo inlet and the air filter cover. Remove the

hose 2 from the intake tube clip and remove the intake tube 3 .

REMOVAL

Figure A

Page 5

Refer to Figure B for Steps 2-6

Step 2: Disconnect the MAF sensor 4and the clip 5 holding the harness.

Step 3: Unclip the three taps 6 from the air filter cover.

Step 4: Remove the air filter cover and air filter.

Step 5: Using a panel clip remover, remove the retaining plastic clip 7 holding part of the scoop seal down

and set aside for later use.

Step 6: Snap out the plastic scoop 8 from the air filter housing.

REMOVAL

Figure B

Page 6

Refer to Figure C for Steps 7-8

Step 7: Using a 7mm socket, extension & driver, remove the screw 9 holding the air filter housing to the

grill inlet duct.

Step 8: Remove the air filter housing by pulling it straight up from its mounting grommets.

REMOVAL

Figure C

Page 7

Refer to Figure D for Steps 9-10

Step 9: Place the scoop seal trim 10 on the scoop opening of the aFe POWER housing.

Step 10: Align the holes from the scoop seal trim and the aFe POWER housing. Insert all four retainer clips

11 fully into the cavities and make sure the seal trim is secure to the aFe POWER housing.

INSTALL

Figure D

Page 8

Refer to Figure E for Step 11

Step 11: Remove the two grommets 12 from the air filter housing and install them onto the aFe POWER

housing. Make sure they are fully seated past the bead.

INSTALL

Figure E

Page 9

Refer to Figure F for Steps 12-13

Step 12: Install the aFe POWER housing on to vehicle. Make sure the bottom mounting pin is fully seated in

the mounting grommet and the two side mounting pins with grommets are fully engaged on the mounting

bracket.

Step 13: Make sure the scoop seal trim seats behind the plastic trim cover (please see picture). Install the

retaining plastic clip 13 removed on step 5 to secure the trim seal.

INSTALL

Figure F

TRIM SEAL TO BE BEHIND PLASTIC TRIM

Page 10

Refer to Figure G for Steps 14-16

Step 14: Slide the large T-Bolt clamp 14 over the air filter opening on the aFe POWER housing.

Step 15: Slide the aFe POWER filter with clamp into the housing. Do not tighten the clamps.

Step 16: Use the provided plug 15 to close the additional air inlet if you want to completely seal the airbox.

Best performance gain is obtained by having more air flow (no plug).

INSTALL

Figure G

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Accesorios para automóviles de aFe Power

aFe Power

aFe Power 46-20299-B Manual de usuario

aFe Power

aFe Power 46-71180A Manual de usuario

aFe Power

aFe Power 77-43023 Manual de usuario

aFe Power

aFe Power 77-83046 Manual de usuario

aFe Power

aFe Power 77-47001 Manual de usuario

aFe Power

aFe Power 50-70009S Manual de usuario

aFe Power

aFe Power 46-39102 Manual de usuario

aFe Power

aFe Power advanced FLO engineering Manual de usuario

aFe Power

aFe Power 77-86318 Manual de usuario

aFe Power

aFe Power Scorpion Manual de usuario

aFe Power

aFe Power F1-03003 Manual de usuario

aFe Power

aFe Power 54-82039 Manual de usuario

aFe Power

aFe Power 54-13053D Manual de usuario

aFe Power

aFe Power Scorpion 79-21005L Manual de usuario

aFe Power

aFe Power 57-10018D Manual de usuario

aFe Power

aFe Power Momentum hd Manual de usuario

aFe Power

aFe Power 77-43025 Manual de usuario

aFe Power

aFe Power SCORPION 79-21004L Manual de usuario

aFe Power

aFe Power 54-10468 Manual de usuario

aFe Power

aFe Power 52-10001D Manual de usuario

aFe Power

aFe Power 77-46316 Manual de usuario

aFe Power

aFe Power GT MOMENTUM 50-70087D Manual de usuario

aFe Power

aFe Power Magnum FORCE 54-13035D Manual de usuario

aFe Power

aFe Power SCORCHER BLUE 77-83043 Manual de usuario

Manuales populares de Accesorios para automóviles de otras marcas

James Baroud

James Baroud Odyssey Manual de usuario

Motorola

Motorola i50sx Manual de usuario

Yakima

Yakima 9MM STANDARD BIKE MOUNT Manual de usuario

Feniex

Feniex T3 Manual de usuario

Renault

Renault 77 11 423 180 Manual de usuario

Kia

Kia E8300-4D000 Manual de usuario

Brink

Brink 756843 Manual de usuario

Whispbar

Whispbar K085W Manual de usuario

v.link

v.link CI-VL2-PC-HSD Manual de usuario

Viking

Viking Stack-Rack Guía de configuración rápida

Aries

Aries 203015 Manual de usuario

Choetech

Choetech AT0005 Manual de usuario

ZZ2

ZZ2 ZZAIR-PRO Manual de usuario

Holman

Holman 4A80L Manual de usuario

Thule

Thule 2075 Manual de usuario

Motorola

Motorola T325 Manual de usuario

TAUBENREUTHER

TAUBENREUTHER 16-3950 Guía de instalación

DV8

DV8 FBJL-02 Manual de usuario

aFe Power 50-70007D Manual de usuario

Manuales populares de Accesorios para automóviles de otras marcas