AFA AFUR3322TE Manual de usuario
33" STAINLESS STEEL KITCHEN SINK & FAUCET KIT
AFA USA LLC
2450 Alton Parkway Irvine, CA 92606
Toll Free: (877) 778-6888
Monday-Saturday 8 a.m-6 p.m Pacific Time Zone
Email: customer.service@afastainless.com
AFUR3322TE/03CCOMB
·15.75" × 14" Dual Bowl Sink
·Extra deep 9 inch Bowl
·Top or Under Mount
·18 Gauge Solid Stainless
·Cast Stainless Pull Down Faucet
·Stainless Steel Soap / Lotion Dispenser
·2 Stainless Drains w / Strainers
·17" × 18-1/2" Stainless Roller Mat
Owners Manual
Français P.18
Español P.35
AFA STAINLESS PRODUCT SUPPORT TEAM
Customer service hotline
Toll Free: (877) 778-6888
Monday-Saturday 8 a.m-6 p.m Pacific Time Zone
Email: customer.service@afastainless.com
AFA USA LLC
2450 Alton Parkway
Irvine, CA 92606
SAFETY INFORMATION
Please read and understand this entire manual before attempting to
assemble, operate or install the product. Before beginning the assembly of
this product, compare the parts with the package contents and list. If any
part is missing or damaged do not attempt to assemble the product and
contact AFA Stainless customer service for assistance.
WARNING
• Follow the installation instructions carefully. Proper installation is the
installer’s responsibility.
CAUTION
• Check local building codes before beginning installation to ensure compliance.
• These instructions are based on application of composite material or solid surface countertop installation only.
Countertop applications of stone, granite, marble or butcher block should be referred to
an experienced countertop fabricator for custom installation.
• AFA stainless does not accept any liability for damage to countertop; sink fixture, faucet,
or personal injury during installation. Warranty may be void if it is determined installation
instructions were not followed.
This unit meets or exceeds the following:
• ASME A112.18.1
• CSA B125.1
• Listed by CUPC for use in the US and Canada
• Listed by California Energy Commission
California Title 20 Water-Efficiency Standards
Flow rate Kitchen faucet max. 1.8 GPM
AFUR3322TE/03CCOMB
Owners Manual
2
A-6 A-7
A-8
x2
x12
x12
E-1
E-2
F-1
F-2
F-3
F-4
F-5
PARTSLIST
x12
x12
x12
x12
x12
D-1
D-2
D-3
D-4
D-5
A-1
A-2
A-3
A-4
A-5
A-9
B-1
B-2
C-4
C-1 C-3
C-5
C-6
x 2
C-2
B-3
B-4
3
Faucet
A-1 Faucet Body
A-2 Deck Plate
A-3 Horseshoe Gasket
A-4 Hex M19 Nut
A-5 Hose Protector
A-6 Hot & Cold Supply Line
A-7 Weight With 2 screws
A-8 Installation Tool
A-9 Spray Hose
Sink
B-1 Sink
B-2 Soap/Lotion Hole Cover
B-3 Topmount Installation Template
B-4 Undermount Installation Template
Soap Dispenser
C-1 Spout & Pump
C-2 Tube
C-3 Bottle
C-4 Threaded Shank
C-5 Rubber Gasket
C-6 Lock Nut
Strainer
D-1 Strainer Basket Assembly
D-2 Strainer Bowl
D-3 Top Gasket
D-4 Bottom Gasket
D-5 Lock Nut
Top-mount Installation Clips
E-1 Screw 2"
E-2 Clip
Under-mount Installation Clips
F-1 Drop-In Anchor
F-2 Mounting Clip
F-3 Metal Washer
F-4 Wing Nut 1/4"-20
F-5 Screw
Rough-in Dimensions
4
Recommended Tools for Installation:
Electric Jig Saw Adjustable Wrench
T-5 T-6 T-7 T-8
Foam Adhesive
Pencil
T-1 (Included) T-2(Included) T-3 T-4
Important Information
·Before and during installation, please read and familiarize yourself with all installation
instructions for this product.
·Please keep all components, parts and accessories of this product away from small children
and minors. During installation, all screws, tools and small parts should be supervised so that
they do not fall into the hands of children.
·Use caution at all times when installing this product. Please ensure that you are physically able
to perform all parts of the installation and that you have the correct tools and equipment
needed. Before beginning, remove all wrappers and packing materials including staples and
packing straps.
·Please check to ensure that all components and parts are complete.
·For top-mount installations: For ease of installation we recommend installing the faucet and
soap dispenser to the sink prior to installation of the sink.
1/2" Drill Bit
Silicone Sealant
Electric Drill
T-9 T-10
Hammer
Flathead Screwdriver Phillips Screwdriver
1/4" Drill Bit
Channel Lock Wrench
T-11
Safety Glasses
T-12
Plumber Putty
T-13 T-14
5
Tape Measure Denatured AlcoholCloth
T-15 T-16
5/64" Allen Wrench
E
A-4
A-8
A-3
E
A-8
E
A-1
A-3
E
A-3
A-2
A-1
A-3
A-4
A-5
Remove Hose Protector (A-5), Hex
M19 Nut (A-4) and Horseshoe
Gasket (A-3) from bottom of faucet.
TOP MOUNT INSTALLATION
6
Soap/Lotion Hole Cover
23
Apply foam adhesive (T-1 ) Included
to the back of sink (B-1).
T-1
B-1
1
Tighten Hex M19 Nut (A-4) with
Installation Tool (A-8). Use
screwdriver through hole in
Installation Tool (A-8) to tighten
firmly.
Place Deck Plate (A-2) on to sink.
Place Faucet Body (A-1) into deck
plate and sink.
Slide Horseshoe Gasket (A-3) up on
to Faucet Body (A-1) under sink.
5
46
Remove soap/lotion hole cover (B-2)
from hole.
C-3
C-6
C-5 C-6
C-3
C-5
A-7
T-4
A
B
1
2
3
C
D
A-5
From under the sink, thread and
tighten the Bottle (C-3) onto
Threaded Shank (C-4)
Thread and tighten Hose Protector
(A-5) onto bottom of Faucet (A-1). Connect Faucet (A-1) Spray Hose
A to Quick Connect Adaptor B. Tighten weight (A-7) to spray hose
(A-9) with 2 screws provided. Measure
15 inches down from the underside
of the faucet on the spray hose. Pull
the faucet out of the spout to test
the distance and the retracting action.
Move the weight if necessary.
Be careful not to put weight so far
down on the hose that it rests on
the floor of the cabinet, or the spray
head won't retract all the way.
Secure Threaded Shank (C-4) by
sliding 1 Rubber Gasket (C-5)
onto bottom of Threaded Shank
(C-4) and tighten Tightening Nut
(C-6).
Slide 1 Rubber Gasket (C-5) onto
the bottom of the Threaded Shank
(C-4). Insert Threaded Shank
through Soap Dispenser sink hole.
10
89
12
7
11
7
T-7
T-11
D-2
D-2
D-3
D-3
D-4
D-4
D-5
D-5
D-1
D-2
D-3
D-4
D-5
T-5
B-3
Drill pilot holes (1/2" bit) on cut line.
Warning: Safety Glasses
recommended (T-12).
Place Top-mount Template (B-3) on
counter, cut along top-mount
installation line. Trace outside line
installation (as shown on template).
Prepare strainer for installation.
Loosen the Lock Nut, check to
ensure that all parts are complete.
Wipe any excess Plumber's Putty
away from top of the sink hole.
Place the Bottom Seal (D-4) on the
underside of the Strainer Bowl (D-2)
and tighten with Strainer Nut (D-5)
using Channel Lock Wrench (T-11).
Set the Strainer Bowl (D-2) and Top
Seal (D-3) into the hole from above
and push down firmly.
Apply a 1/4” bead of Plumber's
Putty (T-13) around the sink drain
hole as shown above.
Repeat for both sink holes.
18
16 17
15
14
13
8
T-10
3/8"
(6mm)
1/8"
(3mm)
T-16
T-15
x12
E-1
E-2
T-6
Center sink within counter opening.
Apply even pressure to all sides.
Apply a bead of silicon 1/8"-1/4"
away from edge of counter cutout
and then align sink on counter.
Carefully cut the counter hole using
a Jig Saw ). Carefully cut along (T-6
the inside of the drawn cut line.
Clean edge of counter top cutout
by Cloth (T-15) and Alcohol (T-16).
Prepare to install mounting clips
with screws (E-1/E-2). Slide Mounting Clips (E1 & E2) into
sink mounting rails. Center Clips
along each side of the sink, 2 Clips
on the 22” sides and 4 Clips on
the 33” sides as shown.
24
23
22
9
21
19 20
Hot
Cold
3/8" (9.5mm)
Hot
T-8
10
6
12
4
7 1
9
5
2 3
8
11
Clean excess silicon from edge of
of sink with rag.
Turn on hot and cold water by
turning handles counter clockwise,
turn on sink faucet and run for 5
minutes to make sure no leaks.
Attach hot and cold supply lines
(A-6) to shutoff valves. Tighten
with wrench clockwise until secure.
Connect the P-trap ( ) Not included
to the strainer.
Tighten mounting clips in numeral
order using flat head screwdriver
as shown above.
(Do not over tighten).
Tighten the screw (E-1).
Note: You might find it handy to
use flash light or hand held
worklight.
27
3029
28
26
25
10
Este manual sirve para los siguientes modelos
1
Tabla de contenidos
Idiomas:
Otros manuales de Producto de plomería de AFA
Manuales populares de Producto de plomería de otras marcas
Weka
Weka 506.2020.00E Instrucciones de funcionamiento
Kohler
Kohler K-6228 Instrucciones de montaje
UBERHAUS DESIGN
UBERHAUS DESIGN 75175017 Manual de usuario
American Standard
American Standard DetectLink 6072121 Manual de usuario
Uponor
Uponor Contec TS Manual de usuario
Pfister
Pfister Selia 49-SL Manual de usuario
