Zodiac PW-5m Manual de usuario

PW

5M-7M-9M-11M

Ver. : 11/2011

H03579‐03.A1.SAVer.11/20111

Summary



Installation......................................................................................2



1.1General..............................................................................................................2

1.2Operatingconditions.........................................................................................3

1.3Installation.........................................................................................................3



Operation........................................................................................6



2.1TheControlPanel..............................................................................................6

2.2Checkstobeperformedbeforeoperatingtheappliance.................................7

2.3Startingtheappliance........................................................................................7

2.4Checkstoperformafteroperatingtheappliance.............................................7

2.5Winterizing........................................................................................................8



Maintenance...................................................................................8



3.1Maintenanceinstructions..................................................................................8

3.2Recyclingtheproduct........................................................................................9

3.3Additionalrecommendations............................................................................9



Errorcodes....................................................................................10



FAQ................................................................................................11



Technicalinformation....................................................................12



6.1Technicalspecifications...................................................................................12



Warranties.....................................................................................12



Registrationonline........................................................................14



Conformitycertificate....................................................................14



Pleasereadthismanualcarefullybeforeinstalling,maintainingorrepairingthis

appliance!Thesymbolindicatesimportantinformationthatmustbetakeninto

accountinordertoavoidriskofpersonalinjuryand/ordamagetotheappliance.The

symbolindicatesusefulinformation.

Aspartofourcontinuousimprovementpolicyourproductsmaybesubjecttochange

withoutnotice.

Availableintheappendixesattheendofthemanual:

- electricaldiagram

- dimensions

H03579‐03.A1.SAVer.11/20112

Installation



1.1General



1.1.1Caution



1.1.2Generaltermsofdelivery,storageandtransport

Anyequipment,includingcarriageandpackingfree,isshippedattherecipient’srisk.

Exclusiveuse:heatingswimmingpoolwater(notbeusedforanyother

application),

theproductmustbeinstalledbyaqualifiedtechnicianaccordingtothe

manufacturer’sinstructionsandincompliancewithlocalregulations.The

installerisresponsibleforthecorrectinstallationofthedeviceandalsofor

ensuringcompliancewithlocalregulationsinthisrespect.Themanufacturer

willnotbeheldresponsibleforanypotentialissuesthatmayariseduetofailure

tocomplywithlocalregulationspertainingtoinstallation,

incorrectinstallationmaycauseseriousdamageand/orpersonalinjuries

(possiblydeath),

thatthisdevicemustbehandledbycompetentandcapablepeople(physically

andmentally)whohavereceivedadequateinstructionsforuse(byreadingthe

userguideorasinstructedbytheinstaller).Personswhodonotsatisfythese

requirementsmustnothandletheappliancesoastoavoidexposureto

potentiallydangerousparts.

Intheeventofmalfunctiondonotattempttorepairtheapplianceyourself:call

yourretailer,

beforeworkingontheappliance,ensurethatthepowersupplyisdisconnected

andsecured,

Priortoanyoperation,checkthat:

- Thevoltageontheidentificationplateoftheappliancecorrespondstothe

mainvoltageavailableonsite,

- thesocketandthepowersuppliedareadaptedtothepowerrequirements

oftheheatpump,andthattheyaregrounded,

- theelectricalplugisadaptedtothesocketavailable.

eliminationorshuntingofoneofthesafetyleadsautomaticallytothe

cancellationoftheguarantee,asforthereplacementofpartsbynon‐original

parts,

Keeptheapplianceoutofthereachofchildren,

DonotventR410Aintotheatmosphere:R410Aisafluorinatedgreenhousegas,

coveredbytheKyotoProtocol,withaGlobalWarmingPotential(GWP)=1975‐

(DirectiveoftheEC842/2006).

H03579‐03.A1.SAVer.11/20113

Inthecaseofdamagecausedduringshippingtherecipientmustmentionany

reservationsinwritingonthecarrier'sdeliverynote(confirmationtobesenttothe

carrierwithin48hoursbyregisteredmailandAcknowledgementofReceipt).

Iftheappliancehasbeenturnedonitsside,mentionyourreservationsinwritingto

thecarrier.



1.1.3Contents



X1x2



1.2Operatingconditions

Operatingrange:



between7°Cand32°Cofairtemperature

between10°Cand32°Cofwatertemperature



1.3Installation



1.3.1Selectinganinstallationsite



theheatpumpmustbeinstalledataminimumdistancefromtheendofthepoolso

astoavoidexposuretowatersplashes.Theappropriatedistanceshouldbedefined

withreferencetothenationalelectricalstandardsthatapplyinthecountryof

installation.

Theheatpumpmustnotbeinstalled:

- nearaheatsourceornearinflammablegas,

- neararoadwithariskofwaterandmudsplashes,

- facingstrongwind,

- withtheventfacingtowardapermanentortemporaryobstacle(window,wall,

hedge,etc…),itmustbeatleast3metersfromsuch.



1.3.2Installingtheappliance

placeontoastable,solid(concreteslabtype)and

levelsurface,

protectfromrisksoffloodingduetocondensation

producedbytheappliancewhilstitisoperating.

Theappliancemustbeinstalledoutdoorsandtheremustbeadequateopenspace

surroundingit(see§1.3.3).

Donotpickuptheunitusingtheoutercasing,usethebasetoliftandmovethe

unit.

Fixingholes

H03579‐03.A1.SAVer.11/20114



1.3.3Hydraulicconnections



 



ConnectionsshouldbemadeusingØ50PVCpipe,gluingthepipeworkconnectorsto

theswimmingpoolfiltrationsystem,afterthefilterandbeforeanywatertreatment

system.Inordertoensurethewatertightnessbetweenthesejointsandtheheat

pump,wrapTeflontapearoundthethreadingofthewaterintakeandoutput.

Evenifthewaterflowislowerthan8m³/h,itisrecommendedthataby‐pass

installationbeused(valveVBclosed,valvesVEandVSopen)soastofacilitate

interventionsontheappliance.

Respectthedirectionofthehydraulicconnection(see§"Dimensions"inthe

appendix).

Itispossibletofixtheappliancetothegroundusingtheholesinthebaseofthe

applianceorusingfixingrails(notsupplied).Itisalsopossibletofixtheappliance

withbrackets(notsupplied).

Adrillingexplanationdiagramisavailableontherearofthepackagingbox.

*Minimumdistance

filter

watertreatment

by‐pass







Withoutby‐pass

Withby‐pass

(recommended)

H03579‐03.A1.SAVer.11/20115

Installingaby‐passismandatoryifthewaterflowishigherthan8m³/h,usevalveVBto

adjustthewaterflowandleavevalvesVEandVSopen.



PW5M 7M 9M 11M

Testpressurebar 6

Operatingpressurebar 1.5

HeadLossmCE 2.3 2.45 4.95 5

Minimumwaterflow‐ratem³/h 2

Averagewaterflow‐ratem³/h 3 4 5 5

Maximumwaterflow‐rate*m³/h 8

*thisflow‐ratemustnotbeexceeded



1.3.4Electricalconnections



theunitisdesignedforconnectiontoageneralpowersupplywithfullearthand

neutralorneutralearthsystems,

electricalprotection:bycircuit‐breaker(curveD)orfuse(Am),andwitha30mA

differentialtripswitchattheheadofthesupplyline(circuit‐breakerorswitch).



PW5M‐7M‐9M

connectthepowercordsuppliedwiththeappliancetoa16Asocketcomplyingwith

thestandardsandregulationsinforceinthecountrywhereitisinstalled,

extensioncordsandadaptersmustnotbeused,

Ifthepowersupplycableisnotlongenough,contactaqualifiedtechnician.



PW11

theelectricalsupplyoftheappliancemustcomefromaprotectionandswitching

device(notsupplied)complyingwiththestandardsandregulationsinforceinthe

country,

theelectricalsupplycablemustnotbeexposedtoelementsthataresharp,hotor

representacrushhazard,

checkthatallcablesaresecureandallterminalconnectionsarecorrect.



Looseterminalsmaycausethesupplyterminalboardtooverheat, andwillvoid

thewarranty.

Theappliancemustbeearthed.

Acceptabletolerancefortensionvariation:‐10%,+7%(whileoperating)

Riskofelectricalshockinsidethedevice.

Onlyafullyqualifiedandapprovedtechnicianshouldperformcabling

connectionsinsidetheappliance.

Ifthepowercableisdamageditmustbereplacedbyaqualifiedtechnician.

H03579‐03.A1.SAVer.11/20116

supplycablesection:forcablesofamaximumlengthof20metres(calculationbase:

5A/mm²),mustbecheckedandadapteddependingoninstallationconditions



PFPVoltage

Maximumcurrent

consumptionCablesectionElectricalprotection

Amm²  A

11M230V‐50Hz15.5 3x2.53G2.5 16



Operation

2.1TheControlPanel



SymbolDesignationNotflashingFlashing Of



waterflowWaterflowis

correct

Waterflowtolowor

nowaterflow/



HeatingactiveStartingupinactive



externalpump

(option)Refertothemanualoftheoptionalfeature



ambientair

temperatureSufficientinsufficient/

DefaultSee§4

“on/off”button



Buttonfordisplayingthetemperatureofthepoolwaterorforsetting

parameters

electricalconduitsmustbesecured,

usethestuffingboxtobringthesupplycableintotheappliance.

phase(L)+neutral(N)+Earth(PE)

H03579‐03.A1.SAVer.11/20117



SymbolDesignation NotflashingFlashing Of





settingvaluesbuttons



2.2Checkstobeperformedbeforeoperatingtheappliance

thehydraulicconnectionsmustbetight,

theunitmustbestable(aswellaslevelandupright),

theelectricalsupplycablemustnotbeexposedtosharporhotelementswhichcould

damageitorcrushit.



2.3Startingtheappliance

openthewatersupplyandadjustthevalves,ifany(see§1.3.3),

connecttheheatpumptothepowersupply:then,

toturnontheappliance:pressfor2secondson:

thenbydefaultthescreenwilldisplaytherequestedtemperature,

tosetthedesiredtemperature("requestedtemperature"):whentheheatpumpis

operating,pressonortosetthevalue.

It’spossibletoreadthewatertemperature:whenwaterisflowingthroughtheheat

pump,presson:flashesfor10secondsthendisplaysthe

fixedrequestedtemperature,

It’spossibletolockthekeyboard:

- lockthekeyboard:pressonandsimultaneouslyfor3seconds:

willbedisplayedfor3secondsthen:,

- unlockthekeyboard:pressonandsimultaneouslyfor3seconds:

willflashfor4secondsthen:,



2.4Checkstoperformafteroperatingtheappliance



Afterfollowingthestepsforrunningtheheatpump,temporarilycutthewater

circulationtocheckthattheheatpumpstopsoperating:thewater

flowdiodeshouldflash.



H03579‐03.A1.SAVer.11/20118

2.5Winterizing



switchofftheheatpumpbypressingthe buttonfor2seconds,thendisconnect

thepowercable,

ensurethatnowaterisflowingthroughtheheatpump,

drainthewatercondenser(riskoffreezing)byremovingthetwopoolwaterinletand

outletconnectionsatthebackoftheheatpump,

inthecaseofafullwinterizingofthepool:connecttheinletandoutletconnections

"lightly"withouttightening(oneturn)inordertoavoidforeignbodiesenteringinto

thecondenser,

inthecaseofwinterizingtheheatpumpalone:donotreconnecttheinletandoutlet

connectors,insteadplacetwostops(supplied)onthecondenserwaterinletand

outlet.



Maintenance



3.1Maintenanceinstructions





ensurethatnoforeignbodiesobstructthefangrid,

cleantheinsideoftheappliance,donotusesolvent‐basedcleaningproducts,

cleantheevaporator(forplacingsee§“Dimensions”inappendix)withasoftbrush

andafreshwaterhose(disconnectthepowercable),donottwistorbendthemetal

blades,

checkthecorrectoperationoftheregulator,

checkthatthecondensationisdrainedproperlywhilsttheapplianceisoperating.



Thefollowingoperationsmustbeperformedbyaqualifiedtechnician:

checkthecorrectworkingconditionofallsafetycomponents,

checkthatallmetalelementsareearthed,

checkthetighteningandconnectionsoftheelectriccablesandthecleanlinessofthe

electricalequipmentbox,

Ageneralservicingoftheapplianceisrecommendedbothwhenwinterizingand

whenrestartinginordertoensuretheproperoperationofyourheatpump,to

preserveitsperformanceandtopreventpotentialfailures.

Servicingcostswillbebornebytheuser.

Donotuseahigh‐pressurewaterhose.

Toavoiddamagingtheappliancewithcondensation,donotcoveritwithanair‐

tightcover.

Winterizingisessentialduetotheriskofthecondenserfreezing.Thissituationis

notcoveredbythewarranty.

H03579‐03.A1.SAVer.11/20119



3.2Recyclingtheproduct

Thissymbolmeansthattheequipmentmustnotthrowitintoyour

householdwaste.Itwillbecollectedselectivelysothatitcanbereused,

recycledorrecovered.Anysubstancesitmaycontainwhicharepotentially

dangeroustotheenvironmentwillbeeliminatedorneutralised.

Enquirewithyourretailerfortheconditionsthatapplytotherecyclingofyourproduct.



3.3Additionalrecommendations

InrelationwiththePressurisedEquipmentDirective(PED‐97/23/CE)



3.3.1Installationandmaintenance

theunitmaynotbeinstalledclosetocombustiblematerials,ortheairductinletof

anadjacentbuilding.

forcertainappliances,itisessentialtofitprotectiongridsiftheunitisinstalledinan

areawhichisunprotectedandeasilyaccessible.

duringinstallation,repairandmaintenancework,itisstrictlyprohibitedtostepon

pipesandhosesasthesecouldbreakandtheescapingrefrigerantcouldcause

seriousscalding.

whenservicingtheappliance,thecompositionandstateofheatcarryingfluidmust

bechecked,aswellastheabsenceofanyrefrigerant.

duringtheannualunitsealingtestinaccordancewithvalidlegislation,thehighand

lowpressureswitchesmustbecheckedtoensuretheyaresecurelyfastenedtothe

refrigerationcircuitandthattheyshut‐offtheelectricalcircuitwhentripped.

duringmaintenancework,ensuretherearenotracesofcorrosionoroilaround

refrigerationcomponents.

beforebeginningworkontherefrigerationcircuit,isolatetheapplianceandwait

severalminutesbeforeremovingthetemperatureorpressuresensors.Certain

elementssuchasthecompressorandassociatedpipingmayattaintemperaturesin

excessof100°Candhighpressureswiththeconsequentriskofseverescalding.



3.3.2Repair

allbrazingworkmustbecarriedoutbyaqualifiedbrazer/welder,

replacementpipesmustalwaysbemadeofcopperincompliancewithstandardNF

EN12735‐1.

leakdetection,pressuretest:

- neveruseoxygenordryair,riskoffireorexplosion,

- usedrynitrogenorthemixtureofnitrogenandrefrigerantindicatedonthename

plate,

- thetestpressureforboththehighandlowpressurecircuitsmustnotexceed42

bar.



Otros manuales para PW-5m

Tabla de contenidos

Otros manuales de Bomba de calor de Zodiac

Zodiac

Zodiac PF Premium 6M Manual de usuario

Zodiac

Zodiac PF 6M-8M-11M-13M-15M Manual de usuario

Zodiac

Zodiac Z350iQ MD4 Manual de usuario

Zodiac

Zodiac Z400 iQ Manual de usuario

Zodiac

Zodiac Edenpac 2 Manual de usuario

Zodiac

Zodiac Z950 Manual de usuario

Zodiac

Zodiac HPO Manual de usuario

Zodiac

Zodiac Z550iQ Manual de usuario

Zodiac

Zodiac PF 6M-8M-11M-13M-15M Manual de usuario

Zodiac

Zodiac PW-5m Manual de usuario

Zodiac

Zodiac Jandy EE-Ti Manual de usuario

Zodiac

Zodiac ZHP-3216-TI Manual de usuario

Zodiac

Zodiac AquaLink Z350iQ Manual de usuario

Zodiac

Zodiac Z250 MD3 Manual de usuario

Zodiac

Zodiac PW-5m Manual de usuario

Zodiac

Zodiac PX50 MD12 Manual de usuario

Zodiac

Zodiac Z900 TD20 Manual de usuario

Zodiac

Zodiac POWER FORCE 25 Manual de usuario

Zodiac

Zodiac POWER FORCE Series Manual de usuario

Zodiac

Zodiac Z400 iQ Manual de usuario

Zodiac

Zodiac POWER PAC 1M Manual de usuario

Zodiac

Zodiac PF 6M-8M-11M-13M-15M Manual de usuario

Zodiac

Zodiac Pac Alpha 5M Manual de usuario

Zodiac

Zodiac Z300 Series Manual de usuario

Manuales populares de Bomba de calor de otras marcas

MICROWELL

MICROWELL HP 1000 GREEN Manual de usuario

Sanyo

Sanyo SAP120FCH Manual de usuario

Daikin

Daikin EHYHBH05AA Manual de usuario

Panasonic

Panasonic WH-SDF03E3E5 Guía

Bryant

Bryant 544B Manual de usuario

Airxcel

Airxcel 45000 Series Manual

Mitsubishi Electric

Mitsubishi Electric PUZ-SWM60VAA Manual de usuario

Dimplex

Dimplex LI 16I-TUR Guía del usuario

Carrier

Carrier WSHP Open v3 Guía de configuración rápida

TGM

TGM CTV14CN018A Manual de usuario

Carrier

Carrier 38MGQ Series Manual de usuario

Kokido

Kokido K2O K880BX/EU Guía de solución de problemas

Viessmann

Viessmann VITOCAL 300-G PRO Type BW 2150 Guía rápida

Carrier

Carrier 48EZN Manual de usuario

Viessmann

Viessmann KWT Vitocal 350-G Pro Series Instrucciones de funcionamiento

Ariston

Ariston NIMBUS Manual de usuario

Weishaupt

Weishaupt WWP L 7 Guía del usuario

GE Zoneline AZ85H09EAC Manual de usuario