Whirlpool AVM 606 AV Manual de usuario

~ 1= ~ ~ I! Ce],; WhirlpoolInter~ational AVM 606Consumer Services

PHILIPS e

~Whirlpool -

Service Manual

M icrowave oven

AVM 606

Model AVM 606 AV

Version 853860601181

Version 853860620181

Version 8538 606~.29181

Version 853860631181

Model AVM 606 WH

Version 853860601281

Version 853860612281

Version 853860615281

Version 853860618281

Version 853860620281

Version 8538 606 29281

Version 853860631281

Version 853860632281

Version 8538606 38281

Introduction safty

Technical data 481271450017

Exploded view 481271460021

Wiring diagram 4812 714 70014

Spare part list 481271480005

Thls documentation is only Intpnded tor qualllied techniclans who are aware01the respective salety re-

gulations

Date: 17.071992

Document-No: 4912714 10017 Subject to modilication -Änderungen vorbehalten

INTRODUCT10N

Before leaving the factory each oven is carefulty checked.

It must however, be instalted and used correctly.

Despite all the steps taken to make the oven safe, the safety is dependent on the correct installation and the fact the user

understands how to use and maintain the oven.

The information in this section should be used as areminder thai the oven is safe and thai anyone who uses it must first

read the instructions tor use in order to be able to use the oven correctly and obtain the best results.

SAFETY

To avoid injury to yourself and damage to the appliance always work to the following rules when servicing an oven.

.Always disconnect the plug tram the mains before starting work.

Ifthere is no plug switch-off the electricity supply at the control box.

.When you have finished servicing an oven before you reconnect it to the mains, make sure thai:

-alt the internat connections are correct

-the wires are insulated and not touching the door or the cabinet or anything sharp

-alt the earth connections are electricalty and mechanicalty sound

-do not modity or anyway intertere with the safety devices built-in to the oven

-make sure that each replacement part you use conforms to the manufacturer's specifications

.00 not start arepair if you have any doubt as to your ability to complete it.

CAUTION -MICROWAVE RADIATION

PERSONNEL SHOULD NOT BE EXPOSED TO THE MICROWAVE ENERGY WHICH MAY RADIATE FROM THE

MAGNETRON, WAVEGUIDE OR ANTENNA IFTHEY ARE IMPROPERLY USED OR CONNECTED. ALL INPUT AND OUT-

PUT MICROWAVE CONNECTIONS, WAVEGUIDES, FLANGES AND GASKETS MUST BE SECURE.

NEVER OPERATE THE DEVICE WITHOUT A MICROWAVE ENERGY ABSORBING LOAD ATTACHED.

NEVER LOOK INTO AN OPEN WAVEGUIDE OR ANTENNA WHILE THE DEVICE IS ENERGIZED.

NEVER OPERATE AN OVEN WITH CABINET OFF WITHOUT MEASURING THE MICROWAVE LEAKAGE AROUND

MAGNETRON AND VISIBLE MICROWAVE CONNECnONS (WELDING JOINTS).

00 not operate the oven if the foltowing conditions exist:

-The door does not close firmly against the door support because of the door being warped or the hinges damaged.

-The door trims or seals are damaged.

-If there is any visible damage to the oven.

-If the door does not close properly.

Avoid operating the oven if known components in the interlock system, oven door or microwave generating assembly are

known defective. They must be replaced. .

WARNING -HIGH VOLTAGE

IT IS POSSIBLETO GaME IN CONTACTWITH LETHAL HIGH VOLTAGE WHEN WORKING WITH HVTRANSFORMER, HV

CAPACITOR, AND MAGNETRON.

THEREFORE NEVER TRY TO MEASURE THE HIGH VOLTAGE. ALWAYS TAKE UTMOST CARE WHEN PERFORMING

ELECTRIC MEASUREMENTS INSIDE THE OVEN.

[~ :8 a: ~y~ 11ral. WhirlpoolInternational ~

~~ ~ ~~ ..~.. 1I ~. ConsumerServices \VlIirlpool 481271450017

A A

t:ß ~

MICRO COMS! GRIL L

E:::::::J(::::~::::J[==~=]

A 350W. ..snow

160W

KEEP 300 W

WARM = '.,,~

~ .1

50 4

40 5

10 9

.t_if900i. *F@~~ij~~~2

[~ ,8 8! ~ ral r. WhirlpoolInternational ~

~~ l- ~~ i.'j ~ I~ ConsumerServices \Vhir\\Hlo\ 481271450017

1. Technical Data AVM 606

1.1. Dimensions of cabinet

Height 277 mm

Width 525 mm

Depth 338 mm

1.2. Dimensions of cavity

Height 210 mm

Width 340 mm

Depth 290 mm

1.3. Weight .

Net 16,8 Kg

Packed 17,5 Kg

1.4. Electrical

Voltagel frequency 230-240 I 50 V I Hz

Power consumption 2600 W

Current consumption 11,3 A

1.5. Power

Output power 900 W

Microwave frequency 2450 MHz

1.6 Grill

Quarzgrill 1000 W

1.7 Cavity volume 20 I

Turntable diameter 280 mm

1.8. Timer 60 min, mech.

1.9. Accessories

Built in kit (optional)

~ i; i~ ~ l ~ l;

Date 24.09.92 Spare oari list

for MICRbwAVE OVEN

Spare part list No. 4812 714 80005

Model AVM 606 A V AVM 606 WH

Type 1 2

Pos. No. Spare Part No. Denomination Type

000 1 4819 532 58224 Lock wash not shown 1+ 2

0020 4819 440 59446 Wrapping AV 1

0020 4819440 59448 Wrapping WH 2

002 1 481946698739 Spacer AV 1

002 1 481946698741 Spacer WI-I 2

002 2 4819440 59444 Cover plate 1+ 2

0130 481946279423 Foot vip 1 +2

0420 4819417 19248 Hinge lower assy 1+2

1000 481944059461 Door AV cpl. 1

1000 4819440 59462 Door WH cpl. 2

1300 4819271 38148 Switch holder assy door 1+2

130 1 4819 404 78492 Lever tor switch holder 1+ 2

141 0 481945069504 Outer glass 1+2

1430 481945948548 Outer frame,AV 1

1430 481945948549 Outer frame WH 2

1960 481945948541 Inner frame 1+2

200 0 0000 000 00000 Oven cpl. not available 1 + 2

200 1 4819 462 38672 Air guide outer 1+ 2

2002 481946238671 Air guide top 1+2

200 3 4819 462 38669 Air guide chassi outer 1+ 2

2004 481946698742 Distance tor cables 1 +2

244 0 481945819898 Grill grid high 1 +2

2450 481946698731 Spacer 1+2

2550 481946678218 Turn table I glass plate 1+2

2640 481953578131 Turn table bearing 1+2

3200 481945349304 Panel AV 1

3200 481945349305 Panel WH 2

3320 481941028574 Button AV 1

3320 481941028575 Button WH 2

3340 481941358915 KnobAV 1

3340 481941358916 Knob WH 2

3341 481941338126 Knob tor rotacode 1+2

3520 4819271 38115 Switch VKS not shown 1+2

4040 4819131 58019 Magnetron 1+2

4042 481952648298 Air channel 1 +2

4043 4819 526 48297 Wall air channel 1+ 2

4060 4819361 18292 Turn table motor 1+2

406 1 481953268666 Rubber ring 1+2

406 2 4819 532 68665 Rubber seal 1+ 2

4120 481914868057 HT transformer SA version 1+2

4120 481914868058 HT transformer GB version only 1+2

4121 481946238665 Air guide transformator 1 +2

420 0 4819 121 48016 HT capacitor 1+ 2

420 1 481940478491 Holder tor capacitor 1+ 2

4202 4819 325 18036 Insulation tor capacitor 1+ 2

421 0 4819121 18197 Mains filter 1+2

4420 4819361 18313 Blower motor 1+2

4430 4819361 18314 Fan wheel assy 1+2

4520 4819 259 98261 Quartz tube element assy 1+ 2 'i~

Subject 10modificalion, \

,,~~~~~~,.

000 MM 00 ~ NO~O ~ 0 ~

~ N M =~ ~~ = ==NIn In N N

O!J ~ ~

,i 8 \

,'i 0 N \

I' ~ \

I '01" \

1 ,' ---

~.i 1 \ I I

1 .\ I I

i .1 \ I I

.1 \ I I

I .\

.1 I

I i \ I

~.\ II \4 i \ I

:::= ~ \ I

, \

~ \

r-,:- " \

c6 c6 \ I

~ = \ I

tO ~ ~ MtO \

~ ~ ~ ~ \~ = \\\\\

_.\

; 0 "Co)

= = = 0 ~=~ ~

~ In ,. N M

~ ~ In ~ M M

N N ~ tO M

N N

Model AVM 606 AV AVM 606 WH

Type 1 2

Pos. No. Spare Part No. Denomination Type

4521 481940478511 Holder quartz 1+2

462 1 481921838038 HV-Rectifier 1+2

4850 481932028014 Wire HT probe 1+2

4851 481932028013 Wire HT probe 1+2

4900 4819321 18129 Mains cable SA not shown 1+2

5020 481921478371 Control unit 1+2

502 1 481911388001 Fail safe resistor 1000hm 1+2

5022 481913038055 Led not shown 1+2

502 3 4819 105 18006 Potentiometer not shown 1+ 2

5024 481913028015 Triac not shown 1+2

5030 4819282 18566 Combitimer 1 +2

561 0 481928248237 Thermostat magnetron 1 +2

562 0 4819 282 48242 Thermostat 1+ 2

5640 4819 28248243 Thermostat grill 1+ 2

611 0 4819 280 28005 Relay 48V 1+ 2

6330 4819271 38151 Microswitch 1+2

651 0 481913488151 Cavity lamp 240V 25W 1+2

901 0 4819401 18512 Mains cable clamp 1+2

9020 481932528039 Insulation 1 +2

9710 481925338019 FuseT8A 1+2

9720 481925338006 Fuse T100MA 1 +2

Subjecl 10modific.,lion

_c_-

,---

000 MM 00 -NO-O -0-

NM O-.t _-.t 0 OONIn In N N

~~ 0 0 ~ 0 N NN ~ = = --

-.t

\\\\

.i 8 \

.' iON \

I. -\

i I -.t \ 1-~\

I .\ 1 I

I .I

I .\ I I

i I \ 1 1

.I \ I I

I i \ I

~ .\ II \ 1~ i \ I :

l ~~ \ I.\ I

~ \: I

, , \\ I

\ I

00 \ I

c1 ~ ~ M~ \ I

In '" a1 ~ 0 \\

\\\\

_.\

-'-'-'--'

; 0 "CC)

0 0 0 0 ~o~-.t

-.t In ..N M

-.t ~ on -.t M M

N N on tO M

N N

~~ ' ~

r.- , Ct: .., U LAJ

, 0 :> Zz" z:> EI""""" -I ~ ::><::>~::>~-.J 0::-

,""'"'4' <9 :><..JOCt:Ct:O..,l cu~

II_rj~===~1 I 0 'a)Ct:"a)Za) ~ 0, ,U C> 0I> --.1 I ~ cu t'--

i 0 ,'... :c 0::-

,.-- "- Ct:

, 0 I- I' .., % < ~

1 C\.J 00 ~ z .' I 0

0a) m :>:> ~ :> CO) t'--

, a)' ..J-~«:I:<

! 1\ ID § ~ U ~ ~ ~ ~ ~ ~ ~ :S ~

I Z r-9- --I ~ ! LAJ ~ co

I 0 I~ 1 ~ I g 0::-

'- I I ~ ' :.:

I Cf) I I I ~

i z. 81 I i < ~ % :.:

, W ~I I , "- 3 ~ >- ~ <) ~

1,--- I ..J-O~O<:>

,.- 'LAJ~:I:LAJCt:Ct:..J..J

I I- I 0 >-~Ct:"a)a)a)

,-,- ~ ,0

I -'- I <)

,c.;; Ct:

I -:I: I:>

L~ l___J 03 ~ ~ 0>- Ct::':

0 , , Ct: 5- ~ a)..J..J

0 I J ~ <) ~ Ct:" a) a)

~ '

, >-

, "

,,0 0

co co ~

'" --- J

.u .u z

00 0

C\Jft, C\JO 0 ~

_.~ ~.'" ~ 0...,

:I: 0 :I:- f- Zf-- ~- oo!jj ..J ~...,0 0 < J:

a. :I: U

..J ..J ~ 0 z...,

.a) ~ U ..., i ~ ~

I .I oa: "u a)Ct:

I 1 0 a) CI) ..., ~

I 1 % 00 <..., 0

-"LAJ

, 1 0 a: '""

I-H I Z:I: a:a: :>a:

I --1 ~ ~ ...,:> 00

, '0 ~ :I: '"" "- a.

, ,

C\J I I

a. 1 1

~ :

r, ,

I ,

I -I

I liDO. I

5" ZOOE '

0' 1 :.:

' 5" I..J >-

'0 ja) "

1 -,

1 ,

, 1 1

I I 1

I I I 1 J:

~-- I U

C\J -C\J I-J::I:

a. a. 2:. a. a. ~uu

C\J C\J -In CI)~,""

'" ~ -

..J >- ~ ~

a) a:(/)(/)

:.: <a:>-

~0 ..J ~ ~ °oa:

In a) z'""<

C\J 0 -~

U % -

a: 0 ...,Oa:

W w (/) ~ a.

0 " " "

-000 ~lntO

~ 000

>- ~ ---

,..

a: '"

C\J on ..J :f

, ~ a) ..J

, ,>- c!),

, I

,- I

o.~ I

;oiE ,

~.- ,

,'"" I

, I ..J

J a)

..J :.:

a) ..J

a: a) a)

a) U

I C'1 -I I a.

a:, c3" I

~, I %

..J' )( , 0

-, U '

"-I 1 Ct:

CI), , ~

%1 a: 1 ..J

<I 1 ~

~I 1 C\J

, 1 CI) -~ 0

01 I % -00 M-

C'1,..J ..J , ~ 0 (0' M C\J0

0 1 ~MC\JC\J.M

-' IM" " >-In

.' C\J ,,-')( >->-.

'- ' -CI: U U U ..J

Ct: ..J .

a) a)

..J Z

r~ ..:8: ~~ , '"Al r. WhirlpoolInternational ~jrl }'ml 481271470014

~J ~ ~~ ,. ~ I~ Consumer Services I

4PO3

7 I" IPS

Irr 7001 P826 ", --~' lPel ---J

uPO756'

2 ,.. ,ps I.

POl --(I .

19PI13 -

10 Vdd -

aB,

F. 'Cl ,ps11 .,--

R.. ,,. ""l J

3PQ2 )

,os.~]~

"2 20v" '" ."""-1

.1- PlI ..~

~ --~ll. ~' I

", ':1 :' 3,.

""1." ,,"I ~9 ~,- '070

I~_- !IA..IlO70

""8 ,~-I- --;!t--

i,) ~

c:: ~

'(J ~

") "

OJ ~~ ~ ~,~

I.. 0, I". "

f\ ~ CI ~

' "" "1-..""" """

1.'\ "" C' "~ r-..

' '"' ,,' \;:

' Q , " ~\) ., " ,.

, " '-' "-

" '" " '"

' l/)..'(~~-'(

~ ';:) ~:") :::: ~ ~ ~

IV) ~ -~

'.') '( ~ .;::. \;\

\:) ~ ~ ..") "

.,~ '. " "'-

";:) ~ ';::) ~

,,~ ~ ~ ">

"\~ , '" 'Q

.'-1'\ -1\ '" '.(\

"1 ::J.. ~ V- ':)..

~ <\)

" ~ ,'" % ~

'\) "V ~\ Q)

CI( " -::) ,~ ~

'" "'-. "'-

'::I ,:") !'-') ") t"'")

~ \"\J ~ '."\J "\I

~ ::J::: :::r: ~

..~-

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Microondas de Whirlpool

Whirlpool

Whirlpool RMC275PVS - Combination Oven With 1.4 Cubic... Manual de usuario

Whirlpool

Whirlpool MT1071SG Manual de usuario

Whirlpool

Whirlpool MT4210SL Manual de usuario

Whirlpool

Whirlpool GUSTO GT 285 SL Manual de usuario

Whirlpool

Whirlpool WOC75EC0HS Manual de usuario

Whirlpool

Whirlpool W10482078A Manual de usuario

Whirlpool

Whirlpool YGH8155XM Manual de usuario

Whirlpool

Whirlpool 8205964 Manual de usuario

Whirlpool

Whirlpool AMW 833 Manual de usuario

Whirlpool

Whirlpool MWX 201BL Manual de usuario

Whirlpool

Whirlpool AMW4910 Manual de instalación y operación

Whirlpool

Whirlpool MT4110SP Manual de lista de piezas

Whirlpool

Whirlpool GSC308PJS3 Manual de usuario

Whirlpool

Whirlpool GH4155XPB2 Manual de usuario

Whirlpool

Whirlpool AMW 575 - GUIDE Manual de usuario

Whirlpool

Whirlpool MW87OOXL Manual de usuario

Whirlpool

Whirlpool GH4184XS Manual de usuario

Whirlpool

Whirlpool MT 255 Manual de usuario

Whirlpool

Whirlpool MHE13XH Instrucciones de funcionamiento

Whirlpool

Whirlpool MH6701XW0 Manual de usuario

Whirlpool

Whirlpool JT 379 Manual de usuario

Whirlpool

Whirlpool MT8116XE Manual de usuario

Whirlpool

Whirlpool GH7208XR - 1-03-07 Manual de usuario

Whirlpool

Whirlpool WMH75021H Manual de usuario

Manuales populares de Microondas de otras marcas

Daewoo

Daewoo KOG-574R0S Manual de usuario

LG MH7040SS Manual de usuario

Sharp

Sharp R-895(AL)M Manual de usuario

Dometic

Dometic DOTRM13W Manual de usuario

Sanyo

Sanyo EM-X680 Manual de usuario

Sharp

Sharp R-393M Manual de usuario

KitchenAid

KitchenAid KMCX4510 Instrucciones de instalación

Smeg

Smeg S45MCX1 Manual de usuario

Russell Hobbs

Russell Hobbs RHM2044 Manual de usuario

Sunbeam

Sunbeam SMW759 Manual de usuario

Gallet

Gallet FMOE230S Manual de usuario

Bosch

Bosch CEG732X.1B Manual de usuario

Dometic

Dometic Roadmate 230 Manual de usuario

Samsung

Samsung SJ0396W Manual de usuario

Sanyo

Sanyo EM-P494WS Manual de usuario

Sharp

Sharp R-240 Manual de usuario

Electrolux

Electrolux EMS2840 Manual de usuario

Daewoo

Daewoo KOC-984T2S13 Manual de usuario