WaterChef EVO100 Manual de usuario

System installation requires the

services of a licensed plumber.

PREMIUM WATER FILTRATION

EVO100

INSTALLATION, USE & CARE GUIDE

WHOLE HOUSE

Water Filtration System

Read & Save These Instructions.

IMPORTANT

QUESTIONS?

1.800.879.8909

(int’l +1.775.359.9500)

MON - FRI 8 AM - 5 PM PST

My System Serial #:

Serial Number is located on lter housing base.

System Certified by IAPMO R&T

against NSF/ANSI Standard 53 and

CSA B483.1 for the reduction of Lead,

Cysts, Perﬂuorooctanoic Acid (PFOA)

and Perﬂuorooctane Sulfonate (PFOS).

TABLE OF CONTENTS

Introduction ...................................................................... 2

Important Use Guidelines ........................................................... 2

Product Specications and Performance ............................................... 3

Where to Install ................................................................... 3

System Installation................................................................. 4

Filter Cartridge Installation .......................................................... 5

Replacing the Filter Cartridge ........................................................ 6

Warranty ......................................................................... 12

Product Registration ............................................................... 13

WHAT’S IN THE BOX [MODEL: EVO100]

EVO100 Filter Housing Assembly

(includes Top Cap and Snap Ring)

WaterChef®EVR1

Filter Cartridge

Flow Control Valve

Reducer Tees (2)

Flow Meter Assembly

Straight 1” MNPT

Connectors (2)

90º Elbow 1” MNPT

Connectors (2)

3/8” Drain Valve Assembly

with Shut-o

Umbrella Cover with

Monitor Assembly

and Battery Backup

Power Supply

Also Included:

- Food Grade Silicone

- AAA Batteries (3)

- 3/8” O.D. Drain Hose (5ft.)

- Installation, Use & Care Guide

- Performance Data Sheet

- Product Registration Card

waterchef.com

INTRODUCTION

 •Readthismanualcompletelybeforeattemptingtoinstallorusethisproduct.Ifsystemisnotmaintained

 andoperatedasspeciedinthismanual,thereisariskofexposuretocontaminants.

 •Testingwasperformedunderstandardlaboratoryconditions,actualperformancemayvary.Actual

 performanceisdependentoninuentwaterquality,owrates,systemdesignandapplication.

For optimal performance, replace your Filter Cartridge upon the rst occurrence of the following:

-Annually

-Younoticeatasteorodorrecurrence,orasignicantreductioninowrate

-System LEDs turn RED (indicating rated capacity of the lter cartridge has been reached)

 •Donotusewaterthatismicrobiologicallyunsafeorofunknownqualitywithoutadequatedisinfection

 beforeoraftertheSystem.

 •Individualsrequiringspecicmicrobiologicalpurityshouldconsulttheirphysician.

 •Systemscertiedforcystreductionmaybeusedondisinfectedwaterthatmaycontainlterablecysts.

 •InstallationofthisSystemmustcomplywithallstateandlocallawsandregulations.

 •Forresidentialuseonly.

 •ThecontaminantsorothersubstancesremovedorreducedbythisSystemmaynotbeinallusers’water.

 •Systemtobesuppliedonlywithcoldwater.

 •Ifthisoranyothersystemisinstalledinametal(conductive)plumbingsystem(i.e.copperofgalvanized

 metal),theplasticcomponentsofthesystemwillinterruptthecontinuityoftheplumbingsystem.Asa

 result,anyerrantelectricityfromimproperlygroundedappliancesdownstreamorpotentialgalvanicactivity

 intheplumbingsystemcannolongergroundthroughcontiguousmetalplumbing.Somehomesmayhave

 beenbuiltinaccordancewithbuildingcodesthatactuallyencouragedthegroundingofelectricalappliances

 throughtheplumbingsystem.Consequently,theinstallationofabypassconsistingofthesamematerial

 astheexistingplumbingoragrounded“jumperwire”bridgingtheequipmentandreestablishingthe

 contiguousconductivenatureoftheplumbingsystemmustbeinstalledpriortosystemuse.

 •FlushnewCartridgesforaminimumof10minutespriortouse.

 •Spentabsorptionmediawillnotberegeneratedandused.Ifabsorptionmediaisaectedbychlorine,

 inuentwillbetreatedtoremovechlorine.

 •DONOTUSEextralubricants,unapprovedsealants,ortoolstotightenhandtightenonlyparts.Useof

 toolsonhandtightenonlypartswillvoidwarranty.

 •ForthisSystemtocontinuetoperformastestedandrepresented,besuretouseonlygenuine,certied

WaterChef®FilterCartridges.Foradditionalpurchaseinformation,contactWaterChefCustomerCare

at 1.800.879.8909(int’l+1.775.359.9500)orvisitusonlineatwww.waterchef.com.

Congratulations on the purchase of your new WaterChef®Premium Whole House Water Filtration System!

WaterChefFiltrationSystemsarecraftedusingthenestmaterialsandworkmanship,andwillserveyoureliably

formanyyearstocomewhenoperatedandmaintainedaccordingtothedirectionscontainedinthisguide.

Youhavemadeawiseinvestmentinprovidingqualitywaterforyouandyourlovedones.Nowpleasetake

afewminutestolearnaboutallthefeaturesandbenetsyournewSystemhastooer!

IMPORTANT USE GUIDELINES

CITY

WATER

INLET

WELL

WATER

INLET

PRESSURE

TANK

PRE-FILTER

SYSTEM

EVO100

WATER

METER

PUMP

SERVICE

Relief Valve

MUST be

Installed

Grounded &

Unswitched

115-Volt Outlet

PRODUCT SPECIFICATIONS

PERFORMANCE

WHERE TO INSTALL

Installation . . . . . . . . . . . . . . . . . . Whole House

ParticleRetentionSize . . . . . . . . . . . . .Sub-Micron

IntelligentMonitor. . . . . . . . . . . . . . . . . . . . LED

RatedCapacity . . . . . . . . 100,000 gallons (378,541 L)

RatedServiceFlow . . . . . . . . . . . . . . . 4.51gpm

PeakFlow&ReductionofLead . . . . . 8gpm@99.62%

ReplacementFilterCartridge. . . . . . . . . . . . . EVR1

MaximumWorkingPressure . . . . 125psig(8.89kg/cm2)

MinimumWorkingPressure . . . . . 20psig(1.41kg/cm2)

MaximumOperatingTemperature . . . . . . 120˚F/50˚C

MinimumOperatingTemperature. . . . . . . . . 34˚F/1˚C

ElectricalRequirements. . . Grounded&Unswitched115V,

3-AAA Batteries

WATERCHEF®WHOLE HOUSE WATER FILTRATION SYSTEM (Model: EVO100)

RefertoPerformanceDataSheetforactualcontaminantandsubstancereductioncapabilities.

Manufacturerinternallytestedfor

Chlorine and Chloramine reduction.

waterchef.com

ThissystemhasbeencertiedbyIAPMOforNSF/ANSIStandard53andCSAB483.1forthespecic

performanceclaimsveriedandsubstantiatedbytestdata.Actualperformanceisdependentoninuent

waterquality,owrates,systemdesignandapplications.Yourresultsmayvary.Performanceclaimsare

basedonacompletesystem,includingltercartridge,housing,andconnectiontoapressurizedwater

source.Thisltermustbeoperatedaccordingtothesystem’sspecicationsinordertodelivertheclaimed

performance.Itisessentialtofollowoperational,maintenance,andlterreplacementrequirements,as

directedforeachapplication,forthislterandsystemtoperformcorrectly.ReadthePerformanceData

Sheetaccompanyingthesystemandchangetheltercartridgeassuggested.

System Certiﬁed by IAPMO R&T against NSF/ANSI

Standard 53 and CSA B483.1 for the reduction of

Lead, Cysts, Perﬂuorooctanoic Acid (PFOA) and

Perﬂuorooctane Sulfonate (PFOS).

waterchef.com

To Power Supply

INLET

NOTE: Flow Direction arrows embossed on

the Flow Control Valve are incorrect for this

application. Plumb unit opposite of arrows.

Drain Valve

Plumber’s Tape Threads

DO NOT Overtighten

OUTLET

SYSTEM INSTALLATION

PART IDENTIFICATION

1.ConnectReducerTees3toInlet/OutletCap

 Assembly2locatedonbottomofFilterHousing

. (Reducer Tee with plugged tting installs

on the right side.) Hand Tighten Only

2.ConnectFlowMeterAssembly4toReducerTees

 3;wiredFlowMetershouldbeplacedonthe

Outlet Side (right). (Note the ow direction arrow

on meter body.) Hand Tighten Only

3.ConnectFlowControlValve5toFlowMeter

 Assembly4.Hand Tighten Only

4.UseeitherStraightor90ºElbow1”MNPT

 Connectors6forconnectingyourplumbing

system. Hand Tighten Only

5.InstallDrainValveAssembly7intoleftReducer

 Tee3usingthethreadedconnectionand

 plumber’stape.Hand Tighten Only

6.Install3AAAbatteriesinUmbrellaCover8;

 connecttopowersupply.

Filter Housing

 BottomInlet/OutletCapAssembly

 ReducerTees(2) (1 plugged tting)

 FlowMeterAssembly

 FlowControlValve

6 Straightor90ºElbow1”MNPTConnectors (2 each)

7 3/8”DrainValveAssemblywithShut-O

8 UmbrellaCover(with Monitor Assembly and Battery Backup)

NOT SHOWN: Power Supply

PlacewiredFlowMeter

on the Outlet Side (right).

Note the ow direction

arrow on meter body.

IMPORTANT

DO NOT USE extra lubricants or unapproved sealants;

DO NOT USE tools to tighten hand tighten only parts.

Use of tools on hand tighten only parts will void warranty.

NOTE

Allow 3 feet of open space above the System to allow for ﬁlter

cartridge installation and replacement.

waterchef.com

FILTER CARTRIDGE INSTALLATION

System comes pre-assembled without the Cartridge installed.

1.PressdownontheHousingAssembly’sTopCapwithbothhands

 tounseattheSnapRing. (g. A) RemovetheSnapRingbycarefully

 graspingthehandleandpullinginward,thenupward.TheRing

 shouldslidecompletelyoutofthegroove. (g. B)

2.RemovetheTopCapfromtheHousingbyholdingtheCapHandles

and lifting. (g. C) (Place the Cap on a clean and dry surface, free

of debris, so that no contamination of the O-ring occurs.)

3.RemovepackagingfromFilterCartridge.

4.SlidetheCartridgeintotheHousingTankwiththedoubleO-ring

 facingdown. WhileloweringCartridgeintoTank,aligntheCartridge

 withthecenteropeninginthebottomoftheTank.Pressdown

 ontheCartridgesothatthedoubleO-ringseatsintothebottom,

 centeropening.(g. D)

5.RepositiontheTopCapintoitsoriginallocationontheHousing.

6.ReattachtheSnapRingthenpullupontheTopCaphandlesto

seat the O-ring.

7.TurnwatersupplyONbyopeningtheInlet&OutletValveson

 theFlowControlValve.

8.AstheSystemllswithwater,pushdownontheREDPressure

 ReleaseButtonontheTopCaptorelievetheSystemofair.Keep

Button pushed down until ALL air is released and water starts

to come out of the Button. Release Button. (g. E)

9.SeatUmbrellaCoverontopofHousingAssembly(g. F) and

check for leaks.

10.FlushSystembyrunningwaterthroughSystemfor10minutes

 beforeuse.

IMPORTANT

Repeat ﬂushing procedure each time a new Filter Cartridge is installed.

SnapRing

TopCap

Umbrella

Cover

CapHandles

Bottom,CenterOpening

HousingTank

Pressure

Release

Button

waterchef.com

REPLACING THE FILTER CARTRIDGE

FILTER STATUS NOTIFICATIONS

1.TurnOFFthewatersupplytotheSystembyshuttingotheInlet

 &OutletValvesontheFlowControlValve.

2.RemoveUmbrellaCoverfromthetopoftheHousing.Replacethe

 3AAAbatterieswithnewbatteries.ResettheIntelligentMonitor™

bypushingandholdingtheResetButtononthemonitorboard

 for3seconds.TheGREENLEDlightswillash3timesto

 conrmreset. (g. G)

3.DepressurizetheSystembypushingdownontheREDPressure

 ReleaseButtonontheTopCapoftheHousinguntilALLtheairor

 waterpressureiscompletelyreleased. (g. H)

4.PressdownontheTopCapwithbothhandstounseattheSnap

Ring. (g. I) RemovetheSnapRingbycarefullygraspingthe

 handleandpullinginward,thenupward.TheRingshouldslide

 completelyoutofthegroove. (g. J)

5. RemovetheTopCapfromtheHousingbyliftingupontheCap

 Handles.RemovetheoldFilterCartridge.

6.Connect3/8”O.D.Tubing(included with EVO100 System) to the

 DrainValvethatconnectstotheinletsideoftheFiltrationSystem.

  RunthehosetoaoordrainorbucketthenOPENtheDrainValve

 andushoutthebottomoftheSystem.

Thebuilt-inIntelligentMonitor™measureswaterandowrateinreal-time,notifyingyouaboutremaininglter

cartridgelifewithsimplecolor-codedLEDnotications.

GREEN

Peak Operating

Performance

FILTER IS

GOOD

YELLOW

Under 10% of

Filter Life Remains

ORDER NEW

FILTER

RED

End of Filter Life

has Been Reached

REPLACE

FILTER NOW

(continued on following page)

AAA

SnapRing

Pressure

Release

Button

UmbrellaCover

(underside) AAA Batteries

Reset Button

TopCap

waterchef.com

REPLACING THE FILTER CARTRIDGE

7.RemovepackagingfromnewFilterCartridgethenslideinto

 HousingTankwiththedoubleO-ringfacingdown. (g. K)

8.PositiontheCartridgesothatitisalignedwiththebottom,center

 openingintheTank.(g. ) PressdownontheCartridgesothat

 thedoubleO-ringsealseatsintothebottom,centeropening.

9.RepositiontheTopCapintoitsoriginallocationonHousing.

10.ReattachtheSnapRingthenpullupontheTopCapHandlesto

seat the O-rings.

11.CLOSEtheDrainValvethenturnONthewatersupplytotheSystem

 byopeningtheInlet&OutletValvesontheFlowControlValve.

12.AsSystemllswithwater,pushdownontheREDPressure

 ReleaseButtononTopCaptorelieveSystemofair.(g. M) Keep

Button pushed down until ALL air is released and water starts

to come out of the Button. Release Button.

13.SeatUmbrellaCoverontopofHousingAssembly(g. N) and

check for leaks.

14.FlushSystembyrunningwaterthroughSystemfor10minutes

 beforeuse.If lights are not ashing GREEN, see step 2.

Housing

Tank

Umbrella

Cover

Bottom,

Center

Opening

Filter

Cartridge

Pressure

Release

Button

IMPORTANT

Repeat ﬂushing procedure each time a new Filter Cartridge is installed.

waterchef.com 8

INTELLIGENT MONITOR™

POWER

OPERATION

Thisunitistobepoweredusing+12VDC.Thepowerunitisawiretailwith2.5mm,centerpositivebarreljack.

TheIntelligentMonitor™hasabatterybackupthatuses3AAAsizebatteries.Thebatteryholderispartofthe

MonitorAssemblylocatedinsidetheUmbrellaCaponthetopoftheSystem.Itcanbeaccessedbyliftingthe

UmbrellaCapfromtheSystem.Batterylifewillvarybasedonwaterowwhenrunningonbatterymodeand

typeofbatteriesused.Withhighcontinuousow,thebatteriesareexpectedtolastapproximately14days.

Withnoow,thebatteriesareexpectedtolastapproximately6months.

TheIntelligentMonitor™keepstrackofthegallonsofwaterthatpassthroughtheSystem.TheMonitoris

removableforinspectionandcleaning.MakesurewaterisbypassedorturnedowhenremovingtheMonitor

formaintenance.TheMonitorhasathreepinplugthatconnectstotheelectronicboardintheUmbrellaCap.

LEDs

Simplecolor-codedLEDnoticationsdisplaytheusagestatusoftheltercartridge:

GREEN 100%-10%oflterliferemains

YELLOW Under10%oflterliferemains

RED Endoflterlifehasbeenreached

Ifthereisow,LEDsshouldalternatelyblinkinthefollowingpattern:1-2-3-2(repeat).Thefrequencythatthe

LEDsblinkcorrespondstotheowratereceivedfromtheMonitor.ForeveryrevolutionfromtheMonitor,

theLEDpatternshouldbeincrementedtoturnothenextLED.Iftherearenorevolutionsfor2seconds,all

LEDswillturnonsolid.

Ifthebatteriesarelow,themiddleLEDwillturnWHITE.Thebatterylevelischeckedonceanhourto

minimizethebatterydrainfromcheckingthevoltage.

Reset Button

TheResetButtonallowsfortheIntelligentMonitor™tobereset.

ToresettheIntelligentMonitor™,pressandholdtheResetButtonfor3seconds.Oncereset,theLEDsshould

ashgreen3timestoconrmreset.

Power Monitoring and Battery Mode

Inadditiontomonitoringwaterusage,theIntelligentMonitor™alsomonitorstheSystem’s12VDCpower

andbatterypower.Ifthereisapowerfailureandnobatteriesareinstalled,theMonitor’svaluewillbesaved

tonon-volatilememory.Whenpowerisresumed,thegalloncountwillresumefromwhereitleftowhen

powerwaslost.

Ifthereisapowerfailureandbatteriesareinstalled,theMonitorgoesintobatterymode.Duringbattery

mode,theLEDsshouldshuto.IftheMonitorisintheYELLOWorREDstate,orifthebatteryvoltagegets

low,theLEDswillashonintheappropriatecolorfor.125secondsevery4seconds.IftheResetButtonis

pressedinbatterymode,theLEDswillturnonfor4secondsandthenreturntobatterymode.

waterchef.com

5-YEAR LIMITED WARRANTY

WaterChef®warrantsthat this ltrationsystemwill be freefromdefects in materials andworkmanshipin

manufacturingfortheperiodofveyears(60months)fromthedateofpurchase.Thiswarrantyisextendedto

theoriginalpurchaser.UseofthisproductconstitutesBuyer’sacceptanceofthisLimitedWarranty.

WaterChef,atitssolediscretion,willrepairorreplacethisproductorcomponentoftheproductfoundto

bedefectiveduringthiswarrantyperiod.Replacementwillbemadewithaneworremanufacturedproductor

component.Iftheproductisnolongeravailable,replacementmaybemadewithasimilarproductofequalor

greatervalue.Thisisyourexclusivewarranty.

Thiswarrantyisvalidfortheoriginalretailpurchaserfromthedateoforiginalretailpurchaseandisnot

transferable.Keeptheoriginalsalesreceipt.Proofofpurchaseisrequiredtoobtainwarrantyservice.

WHAT IS NOT COVERED

This warranty does not cover lter cartridges, systems that were not installed in compliance with the

installationinstructionsbyalicensedplumber,normalwearofcomponentsorthefollowing:

 •DamagecausedbyimproperinstallationorusecontrarytotheInstallation,Use&Care

Guide,disassembly,

  modicationoralterationbyanyoneotherthanWaterCheforaWaterChefauthorized

servicecenter.

 •Damagecausedbynegligent useormisuseofthe product,neglect,oxidizingagents(suchaschlorine,

  ozonechloraminesandotherrelatedcomponents).

 •Damageduetoexcessivesedimentinwatersupplyorclogging(replacementofpre-ltercartridgeisthe

  purchaser’sresponsibility),usewithnon-potablewatersuppliesorusewithwaterpressurethatisoutside

  thespeciedoperatingrange.

 •

Damagecausedbyaccident,re,freezing,oodoractsofGod.

 •

Cost of labor or expenses expended in the installation and/or removal of system, lter cartridges, or any

  surroundingdevice.

 •Incidentalorconsequentialdamagecausedbyafailureoftheproductorthebreachofanyexpressedor

  impliedwarranty.Excepttotheextentprohibitedbyapplicablelaw,anyimpliedwarrantyormerchantability

  islimitedtothedurationoftheabovewarranty.

ThisWarrantyifvoidediftheproductisusedwithnon-genuineWaterChefpartsorreplacementltercartridges.

Somestates,provincesorjurisdictionsdonotallowtheexclusionorlimitationoftheincidentalorconsequential

damages,sotheabovelimitationorexclusionmaynotapplytoyou.Thiswarrantygivesyouspeciclegal

rightsandyoumayhaveotherrightswhichvaryfromstatetostateorprovincetoprovince.

HOW TO OBTAIN WARRANTY SERVICE

Call 1.800.879.8909 (int’l +1.775.359.9500) or email customercar[email protected]withinthewarrantyperiod

todescribetheproblem.Ifitisdeterminedthatitisnecessarytoreturnthedefectivepart,aReturnAuthorization

Numberwillbeissued.Parts returned without a Return Authorization Number will be refused.Packthe

productinashippingcarton,usingnewspaperorotherpackingmaterialstoprotecttheproductfromdamage

intransit.Beforesealingthecarton,besuretoincludeproofofpurchaseandproofofinstallationbylicensed

plumber.BecertaintoincludeyourreturnshippingaddressandReturnAuthorizationNumberontheoutside

of the carton.

Uponreceivingtheproduct,wewillrepairorreplacethepartandreturnittothereturnaddressontheshipping

carton at no cost to you (U.S. customers only).

PREMIUM WATER FILTRATION

EVO100 WHOLE HOUSE WATER FILTRATION SYSTEM

Tabla de contenidos

Otros manuales de Sistema de filtración de agua de WaterChef

WaterChef

WaterChef Countertop C7000 Manual de usuario

WaterChef

WaterChef Countertop C7000 Manual de usuario

WaterChef

WaterChef U9000 Manual de usuario

WaterChef

WaterChef Countertop C7000 Manual de usuario

Manuales populares de Sistema de filtración de agua de otras marcas

Wisy

Wisy LineAir 100 Manual de usuario

Schaffner

Schaffner Ecosine FN3446 Series Manual de funcionamiento

Pentair

Pentair FLECK 4600 SXT Guía del usuario

H2O International

H2O International H20-500 Manual de usuario

Renkforce

Renkforce 2306241 Manual de usuario

Neo-Pure

Neo-Pure TL3-A502 Manual de usuario

FLTR

FLTR OBF Manual de usuario

STA-RITE

STA-RITE VERTICAL GRID DE FILTERS S7D75 Manual de usuario

Applied Membranes

Applied Membranes W-G844EM Manual de usuario

BEGA

BEGA 116 Manual de usuario

WATA

WATA Standard Manual de usuario

Price

Price FFU series Manual

Gaggenau

Gaggenau BRITA INTENZA 467873 Manual de usuario

Brita

Brita SAFF-100 Manual de usuario

HEISSNER

HEISSNER FPU24000-00 Manual de usuario

BGS technic

BGS technic 1518 Manual de usuario

Reverse Osmosis

Reverse Osmosis RF Series Manual de usuario

ubbink

ubbink Filtramax Series Manual de usuario