Troll systems VLSG-01 Manual de usuario
Troll Systems Corporation
Ground-Based Products
VanLink System
Installation Guide
Troll Systems Corporation Technical Publications
Document VLSG-01 Revision – 0
10/17/2008
www.trollsystems.com
NOTICE
The information in this document incorporates proprietary rights of
Troll Systems Corporation
24950 Anza Avenue
Valencia, CA 91355, U.S.A.
Any party accepting this document acknowledges that it contains
proprietary confidential information and agrees that it shall not be
duplicated in whole or in part, nor disclosed to others without the
written consent of Troll Systems Corporation.
© 2008 Troll Systems Corporation
VANLINK SYSTEM GUIDE
VanLink System featuring TouchStar™ Technology - Troll Systems Corporation
Document VLSG-01 - 10/21/08 -1
Summary ...................................................................................................................................1
VanLink Equipment Components .............................................................................................1
Required Hardware ............................................................................................................... P-1
Software Requirements ......................................................................................................... P-1
Abbreviations, Acronyms, Terms ......................................................................................... P-2
Packaging .............................................................................................................................. P-4
Warranty ............................................................................................................................... P-4
Conventions Used in this Document ..................................................................................... P-5
VanLink Component Set-up and Operation ......................................................................... P-5
Warnings, Cautions, Notes, and Hints .................................................................................. P-5
Warnings ............................................................................................................................... P-5
Cautions ............................................................................................................................... P-6
Notes ..................................................................................................................................... P-6
Hints ..................................................................................................................................... P-6
Contact Information ............................................................................................................P-7
Hazard Advisory Placards/Signs ........................................................................................... S-1
Know and Comply with Local, State, and Federal Safety Requirements ............................. S-1
Do Not Service or Adjust Alone ........................................................................................... S-1
Electrical Power/Shock Hazards ........................................................................................... S-2
Be Familiar With Resuscitation Techniques ......................................................................... S-3
Coincidental Damage to Equipment in Cabinets .................................................................. S-3
Lifting/Handling Hazards ..................................................................................................... S-3
Electrostatic Discharge Sensitive (ESDS) Components ....................................................... S-4
System Overview .................................................................................................................. 1-1
VanLink System Features ............................................................................................... 1-2
Remote Control from the Studio or Control Center ....................................................... 1-3
SPECIFICATIONS ......................................................................................................... 1-4
Required System Components ........................................................................................ 1-4
Hardware Requirements ................................................................................................. 1-4
Table of Contents
C100 User Interface VanLink System featuring TouchStar™ Technology - Troll Systems Corporation
-2 Document VLSG-01 - 1/11/2007
Master Controller Software Requirements ..................................................................... 1-4
Introduction ..................................................................................................................... 2-1
Safety Recommendations ............................................................................................... 2-1
Installation Requirements ............................................................................................... 2-2
Power Requirements ....................................................................................................... 2-2
Rack Installation ............................................................................................................. 2-2
Rack Space Requirements .............................................................................................. 2-2
Cable Requirements........................................................................................................ 2-2
Running Cables .............................................................................................................. 2-3
V750 Cable and Connector Requirements ...................................................................... 2-3
Pan and Tilt Cabling and Connector Requirements ........................................................ 2-4
GPS/IMU Connectivity ................................................................................................... 2-5
EVDO/3G Router Connectivity ...................................................................................... 2-5
IP Connectivity ............................................................................................................... 2-5
Master Controller(s) and TNS Accessibility .................................................................. 2-5
Typical Network Configuration for VanLink ................................................................. 2-7
GPS/IMU Mounting Considerations .............................................................................. 2-7
GPS/IMU Assembly ....................................................................................................... 2-7
GPS/IMU Mounting Considerations .............................................................................. 2-7
VanLink GPS .................................................................................................................. 2-8
Calibration ...................................................................................................................... 2-9
Magnetometer Calibration .............................................................................................. 2-9
Antenna Calibration ........................................................................................................ 2-9
Remote and Local Control .............................................................................................. 2-9
Operating Requirements ............................................................................................... 2-10
Transmitter Control / Available Options ...................................................................... 2-10
Introduction ..................................................................................................................... 3-1
VANLINK SYSTEM GUIDE
VanLink System featuring TouchStar™ Technology - Troll Systems Corporation Introduction
Document VLSG-01 - 10/21/08 P-1
INTRODUCTION
This Installation Guide is intended for use with the VanLink System featuring
TouchStar™ Technology designed and fabricated by Troll Systems Corporation. The
sections and appendices that make up this manual are as follows:
Safety Considerations
Section 1 - Vanlink System Overview
Section 2 - VanLink System Requirements
Section 3 - Engineering Drawings
This guide or manual is based on the latest information available at the time of
publication.
SUMMARY
VanLink is a system composed of several Troll Systems components that are
coordinated work in a synchronous manner using proprietary software. This complex
and innovative system configuration enables complete studio control of a broadcast
news van while it is in the field.
VANLINK EQUIPMENT COMPONENTS
Required Hardware
The VanLink system is comprised of the following hardware components:
• V750 - Troll Systems Remote VanLink controller
• GPS/IMU – Troll Systems GPS & Magnetometer assembly
• Quickset Pan/Tilt – Pan/Tilt pedestal w/ Azimuth and Elevation feedback
• Pan/Tilt controller – Pan/tilt controller with remote interface capability
• EVDO or 3G Router
Software Requirements
• TouchStar 2008 – Windows application providing the control interface for VanLink.
• TouchStar 02 Mapping Software – Displays and provides control for all receive sites
including each vehicle equipped with VanLink.
INTRODUCTION
User Manual VanLink System featuring TouchStar™ Technology - Troll Systems Corporation
P-2 Document VLSG-01 - 10/17/2008
ABBREVIATIONS, ACRONYMS, TERMS
Listing of general abbreviations, acronyms, and terms that may be used throughout this
document are defined in the following list.
Term Definition
AC Alternating Current
ALT Altitude
ANT Antenna
AUX Auxiliary
Az Azimuth
BAS Broadcast Auxiliary Service
CAL Calibrate
CAM Camera
Ch Channel
COMM Communication
COTS Commercial-Off-The-Shelf
CPU Central Processing Unit
dB Decibel
DC Direct Current
DMM Digital Multimeter
e.g. Latin: exempli gratia, meaning “for example”
EMI Electro-Magnetic Interference
ENG Electronic News Gathering
ESD Electro-Static Discharge
et al Latin: et alia, meaning “and others”
FM Frequency Modulation
GPS Global Positioning System
GUI Graphic User Interface
HD High Definition
Hz Hertz
H/W Hardware
I/O Input/Output
i.e. Latin: id est, meaning “that is”
ABBREVIATIONS, ACRONYMS, TERMS
VanLink System featuring TouchStar™ Technology - Troll Systems Corporation Introduction
Document VLSG-01 - 10/17/2008 P-3
LAT Latitude
LCD Liquid Crystal Display
LED Light Emitting Diode
LNA Low-Noise Amplifier
LNG Longitude
MICOWV Microwave
NEMA National Electrical Manufacturing Association
NIC Network Interface Card
nm (NM) Nautical Mile (note: 1 nautical mile equals 1.150782 miles)
NTSC National Television System Committee
NAV NavTrack
NV Non-Volatile
PC Personal Computer
PED Pedestal
POL Polarization
PRSETS Presets
RAM Random Access Memory
RF Radio Frequency
RFI Radio Frequency Interference
ROM Read Only Memory
RPC Remote Procedure Call
RX Receiver/Receive
S/W Software
SDI Serial Digital Interface
SV System Variable
TX Transmitter/Transmit
V Volt
VAC Volts Alternating Current
VDC Volts Direct Current
WWatt
Term Definition
INTRODUCTION
User Manual VanLink System featuring TouchStar™ Technology - Troll Systems Corporation
P-4 Document VLSG-01 - 10/17/2008
PACKAGING
Use the original packaging material used for your TNS3000 network Server if available
and in good condition.
If you must return your product to Troll Systems Corporation for repair (and you no
longer have your original box and packing materials), Troll will send you a packing box
specifically designed to ship the product without damage.
WARRANTY
Troll warrants, to the original Customer only, that the product is free from defects in
material and workmanship and conforms to the specification, if any. If no specification
is listed, the items are warranted to conform to our currently published specification for
the product. The warranty period is for a period of one year from the date of shipment.
Troll will repair or replace (at its option) any such device which is returned to the Troll
factory office, with transportation charges prepaid and within the warranty period. The
liability of Troll shall be limited to the repair or replacement of the device and shall not
include installation, or any other charge or expense incurred. This warranty shall not
apply to any unit or part thereof which, in the opinion of Troll, has been installed or used
improperly; damaged by accident, corrosion, misused, or negligence; or altered or
repaired in such a manner as to impair performance. Troll must receive written notice of
the defect within the warranty period. Customer must pay packing, crating and
transportation costs to and from the factory. At the Customer’s request, Troll will make
reasonable efforts to provide warranty service at the Customer’s premises, provided that
Customer pays Troll’s then current rates for field service and the associated travel and
living expenses. If a fault has been caused by improper installation, maintenance or use,
or by abnormal conditions of operation, those repairs will be billed at normal rates. Troll
shall have the right of final determination as to the existence and cause of any such
defect.
CONVENTIONS USED IN THIS DOCUMENT
VanLink System featuring TouchStar™ Technology - Troll Systems Corporation Introduction
Document VLSG-01 - 10/17/2008 P-5
CONVENTIONS USED IN THIS DOCUMENT
VanLink Component Set-up and Operation
The Troll Systems V750 Remote Site Controller and its innovative capabilities is the
heart of the VanLink system. For comprehensive information for this complex and
dynamic component, consult the Troll Systems manual for the S750 Remote Site
Controller manual which is identical to the V750 in almost all respects and functions.
Text appearing on the bottom line of the front panel display (just above the function
keys) of the V750 Remote site controller (i.e., commands associated with function keys
A, B, C, D, and E) appear in the font, Arial Rounded MT Bold
Text and terms that are emphasized to draw the reader’s attention (due to their
significance within the text) appear in italics. See the example below.
WARNINGS, CAUTIONS, NOTES, AND HINTS
Warnings
Warnings are included to alert the user that possible hazards are associated with the
processes/procedures described. These may cause death or injury in any form, if the
instructions in the operational or procedural task are not followed precisely. Warnings
describe the potential hazards and possible impact that could occur if the warnings are
not observed.
WARNING: This format is used for general warnings.
WARNING: This format is used for electrical warnings.
WARNING: This format is used for mechanical warnings.
INTRODUCTION
User Manual VanLink System featuring TouchStar™ Technology - Troll Systems Corporation
P-6 Document VLSG-01 - 10/17/2008
Cautions
Cautions are included to alert the user that damage to the equipment is possible if the
instructions in the operational or procedural task are not followed precisely. Cautions
describe the hazards and possible impact that could occur if the cautions are not
observed.
Notes
Notes are included to provide the user with supplemental information, which is helpful
but does not necessarily belong in the core text. Many operational and procedural tasks
are easier with the addition of notes.
Hints
Hints are generally included to inform the user of special features and/or methods of
performing various tasks. These are usually unique features/methods that provide
streamlined use of the equipment and/or user interface.
Hint: This format is used for all hints.
WARNING: This format is used for warnings which include the risk
of fire.
CAUTION: This format is used for all cautions.
NOTE: This format is used for all notes.
Este manual sirve para los siguientes modelos
1
Tabla de contenidos
