Trane BAYCCHT101AA Instrucciones de montaje

Installer’s Guide

MODEL:

18-HE71D1-7

Crankcase Heater

ALL phases of this installation must comply with NATIONAL, STATE AND LOCAL CODES

IMPORTANT — This Document is customer property and is to remain with this unit. Please return to service information

pack upon completion of work.

HAZARDOUS VOLTAGE - DISCONNECT POWER BEFORE SERVICING

WARNING:

BAYCCHT101AA

BAYCCHT102AA

BAYCCHT404BA

For this Unit Use this Heater

4WC*3018, 2WC*3024-030,2WC*3048,

4YC*3018, 4YC*3024B, 2YC*3024-030,

2YC*3042-048, 4TC*3018-024, 4WCY4024-

030, 4TCY4024-030, 4YCY4024-030,

4DCY4024-030 (230V)

BAYCCHT101AA

(Reciprocating)

(65 Watts)

2WC*3036-042, 2WC*3060, 4WC*3036-060,

2YC*3036, 4YC*3036-060, 2YC*3060,

4TC*3030-060, 4YCY4036-060, 4WCY4036-

060, 4TCY4036-060,4DCY4036-060,

4WCZ6036-060, 4YCZ6036-060,

4DCZ6036-060 (230V)

BAYCCHT102AA

(Scroll)

(60 Watts)

4WC*3036-060, 4YC*3036-060, 4TC*3036-060,

4WCZ6036-060, 4YCZ6036-060 (460V)

BAYCCHT404BA

(Scroll)

(60 Watts)

Table 1. Crankcase Heater Accessory Numbers

SAFETY HAZARD!

Bodily injury can result from high voltage electrical compo-

nents, fast moving fans, and combustible gas. For protection

from these inherent hazards during installation and service,

the electrical supply must be disconnected and the main gas

valve must be turned off. If operating checks must be per-

formed with the unit operating, it is the technicians respon-

sibility to recognize these hazards and proceed safely.

▲

WARNING

Installation

1. Set the thermostat to OFF.

2. Open all unit electrical switches.

3. Remove the unit's Control Box, Blower, and Compressor ac-

cess panels.

4. Open the Crankcase Heater Kit and remove the crankcase

heater. The BAYCCHT101AA is a cartridge type and the

BAYCCHT102AA and BAYCCHT404BA are the band type.

5. Cartridge Type Crankcase Heater - Insert the crank-

case heater fully into the mating tube attached under the

compressor near the electrical header.

Secure the cartridge into the tube with the spring provided

in the kit. The hook end connects to the back end of the

tube. The hoop end latches around the cartridge. See Fig-

ures 1 and 2.

Band Type Crankcase Heater - Place the crankcase

heater band around the bottom of the compressor within 1

inch of the base. See Figure 3.

Tighten the crankcase heater around the compressor

and attach the green ground wire to the base as shown.

Torque heater to 20-25 inch-pounds.

7. Route the black crankcase heater leads from the Compres-

sor compartment, through the Blower compartment, and

into the Control Box compartment.

8. In the Control Box compartment, connect the leads to the

Compressor

Blower

Compartment

Compressor

Compartment

Control Box

Compartment

Compressor

Contactor

Load Line

Figure 2. BAYCCHT101AA (Reciprocating Compressor)

Insert Cartridge Heater

Fully into Tube under

Compressor. Secure with Spring

Figure 1. Cartridge Latching Spring

End View Side View

Hook.

Connect

hook to end

of tube

Hoop. Latch

hoop around

cartridge

(CC) compressor contactor as shown in the diagram. Refer to

Figure 4 if you have a single phase unit. Refer to Figure 5 if

you have a three phase unit.

NOTE: Connect both leads on the line side of the contactor.

(See Figures 4 (page 3) or 5 (page 4)

9. Secure the crankcase heater leads with wire ties. Care must

be taken to ensure the leads do not come in contact with the

compressor discharge line, with any moving parts, or any sharp

edges.

10. Place the wiring diagram provided with the kit on the inside

of the Control Box access panel.

11. Reinstall the Compressor, Blower, and Control Box access

panels.

12. Reapply power to the unit.

13. The crankcase heater should immediately begin to heat. The

crankcase heater will heat at all times.

14. Reset the thermostat.

Figure 3. BAYCCHT102AA and BAYCCHT404BA (Scroll Compressor)

Figure 4. Single Phase Wiring

Field Wiring =

Factory Wiring =

GND

Wire

Screw

Compressor

Contactor

Load Line

Compressor

Blower

Compartment

Compressor

Compartment

Control Box

Compartment

Page 4

Trane

6200 Troup Highway

Tyler, TX 75707-9010

The manufacturer has a policy of continuous product and product data improvement, and it

reserves the right to change design and specification without notice.

Figure 5. Three Phase Wiring

Field Wiring =

Factory Wiring =

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Calentador de Trane

Trane

Trane FVAE Guía de inicio rápido

Trane

Trane BAYHTR1504BRKC Instrucciones de montaje

Trane

Trane GANE Instrucciones de instalación y funcionamiento

Trane

Trane UniTrane Manual del propietario

Trane

Trane BAYSPEK060 Instrucciones de montaje

Trane

Trane BAYHTFB318 Series Manual de usuario

Trane

Trane BAYEACC25BK1B Instrucciones de montaje

Trane

Trane GKNE Manual del propietario

Trane

Trane UHAA-15 Manual del propietario

Trane

Trane UHEC-IM-7A Guía de mantenimiento y servicio

Trane

Trane GBPD Manual de usuario

Trane

Trane Arctic PolyTherm TP Series Instrucciones de instalación y funcionamiento

Trane

Trane BAYHTRV105 Instrucciones de montaje

Trane

Trane UHSB Instrucciones de instalación y funcionamiento

Trane

Trane Force-Flo Manual del propietario

Trane

Trane TR250 Manual de usuario

Trane

Trane UniTrane Instrucciones de instalación y funcionamiento

Trane

Trane SRV-SVN06C-EN Manual de usuario

Trane

Trane UniTrane Fan-Coil Manual del propietario

Trane

Trane BAYCCHT101AA Instrucciones de montaje

Manuales populares de Calentador de otras marcas

oventrop

oventrop Regucor Series Manual de usuario

Blaze King

Blaze King CLARITY CL2118.IPI.1 Manual de usuario

ELMEKO

ELMEKO ML 150 Manual de usuario

BN Thermic

BN Thermic 830T Manual de usuario

KING

KING K Series Guía

Empire Comfort Systems

Empire Comfort Systems RH-50-5 Guía de inicio rápido

Well Straler

Well Straler RC-16B Manual de usuario

EUROM

EUROM 333299 Manual de usuario

Heylo

Heylo K 170 Manual de usuario

Eterna

Eterna TR70W Manual de usuario

Clarke

Clarke GRH15 Manual de instrucciones

IRSAP

IRSAP The Radiator Company Ovali Manual de usuario

Empire Heating Systems

Empire Heating Systems WCC65 Manual de usuario

Wetekom

Wetekom 92 86 43 Manual de usuario

Desa

Desa SPC170-F Manual de usuario

Watlow

Watlow Watrod Electric Tubular Heaters Manual de usuario

Haverland

Haverland ECO-DRY GPS Series Manual de lista de piezas

Stelpro

Stelpro ASILVC2060 Series Manual de usuario