Toyota Celica guide Manual de usuario
TOYOTA NAVIGATION SYSTEM
PART NUMBER
NAVIGATION KIT PART N° 08545-00803
TOYOTA MOTOR CORPORATION
INSTALLATION INSTRUCTIONS
FOR **T23*R
Manual Ref. Nr.N1RT23-0-00
09-99 Celica (RHD) - 2
Celica TNS 500
PRECAUTIONS
• Do not pinch the rear wiring or har-
ness in the tightened part.
PLEASE READ THOROUGHLY THESE PRECAUTIONS BEFORE THE INSTALLATION
• Be sure to disconnect the negative
(-) lead from the battery terminals.
• When passing the wires through the
dashboard or other panels, use a
grommet to ensure waterproofing.
• Protect the wiring with tape when it is
passed through a hole.
• When disconnecting the connectors,
be sure to grip the connector body.
Do not tug on the wiring.
• Do not forcibly pull any car wiring harness.
Rough tugging may result in opened con-
nections, or a broken wire or harness.
•
Confirm that lamps, horn, wiper and
other car accessories operate normally.
• Protect your car with fender covers, seat
and so on.
• Use the correct tool when tightening
bolts or nuts.
• Before drilling a hole, check that the rear of
the mounting wall is clear.
• Be sure to firmly tighten connectors
and terminals.
• Before connecting the power wiring to
the battery, check the wiring con-
nections, harness, etc. to see that they
are properly secured.
• Check body and trim near area of installation to be certain no
dirt or scratches resulted from the installation.
waterproof - O.K. !!
Taping
Grommet
Insert
completely
Stop it !
09-99Celica (RHD) - 3
Celica TNS 500
Precautions ..................................................................................................................................................................... 2
Required Parts/Subkits ................................................................................................................................................... 4
Navigation System Assy ................................................................................................................................................. 5
Wire Harness .................................................................................................................................................................. 7
Installation Overview ...................................................................................................................................................... 8
How to connect .............................................................................................................................................................. 9
Fujitsu Ten Audio Unit (with AVC-LAN) .......................................................................................................................... 10
Matsushita Audio Unit (with AVC-LAN) .......................................................................................................................... 11
Audio Units with 13PIN Connector (without AVC-LAN) .................................................................................................. 12
Vehicle Disassembly........................................................................................................................................................ 13
Installation of the GPS Antenna ...................................................................................................................................... 17
Wire Harness Installation ............................................................................................................................................... 19
Installation of the Computer ........................................................................................................................................... 25
Monitor Installation ......................................................................................................................................................... 28
Wire Harness Connection ............................................................................................................................................... 31
Storage of the Remote Control ....................................................................................................................................... 34
System Start Up ............................................................................................................................................................. 35
TABLE OF CONTENTS
09-99 Celica (RHD) - 4
Celica TNS 500
COMBINATION
Radio/Cassette + Navigation
Radio/Cassette + CD-Changer
+ Navigation
HEAD UNIT
TF4301 (08600-00922)
or
TM4000 (08600-00888)
18401 (86100-20510)
or
58408 (86100-60080)
TF4301 (08600-00922)
or
TM4000 (08600-00888)
18401 (86100-20510)
or
58408 (86100-60080)
ADD ON UNITS
CD-CHANGER
TM0461 (08601-00879)
TM0461 (08601-00879)
NAVIGATION-ASSY
08545-00803
08545-00803
08545-00803
08545-00803
NECESSARY PARTS
W/H (08695-00260)
W/H (08695-00260)
REQUIRED PARTS/SUBKITS
09-99Celica (RHD) - 5
Celica TNS 500
No. Description / Description Qty
MONITOR 1
W/H SUB-ASSY
1
WIRE HARNESS 1
TAPE 5
FOAM TAPE 3
W/H SUB-ASSY
1
W/H SUB-ASSY
1
WIRE TIE 15
SCREW (M5 x 8) 4
VELCRO (Yellow) 2
VELCRO (Blue) 2
REMOTE CONTROL 1
STORAGE BATTERY 2
13
12
11
10
9
8
7
6
5
4
3
2
1
COMPUTER 1
GPS ANTENNA 1
*1NAVIGATION DISC 1
COMPUTER BRACKET 2
SET BOLT (M5 x 8) 4
CORD CLAMP 6
TAPE 2
WIRE TIE 6
EARTH PLATE 1
ANCHOR BOLT 4
BOLT (M5 x 16) 4
BOLT (M5 x 20) 1
HOLD BRACKET 1
ADHESIVE TAPE 3
33
32
31
30
29
28
27
26
25
24
23
22
21
20
*1: NAVIGATION DISC (CD-ROM) is not included in the navigation kit.
22
NAVIGATION SYSTEM ASSY
09-99 Celica (RHD) - 6
Celica TNS 500
1
7
8
9
10
11
12
13
2
3
5
4
6
*1: NAVIGATION DISC (CD-ROM) is not included in the navigation kit.
22
*1
20
26
27
28
29
30
31
32
21
22
23
24
25
;;;;;;;;;;;;;
;;;;;;;;;;;;;
;;;;;;;;;;;;;
;;;;;;;;;;;;;
;;;;;;;;;;;;;
;;;;;;;;;;;;;
33
Note :
In cases where the CD-Changer is installed together with the navigation system, the wire harness n°
08695-00260 is needed (See page 7).
The wire harness is not included in the navigation kit.
09-99Celica (RHD) - 7
Celica TNS 500
For CD- and MD-Changer only
48
WIRE HARNESS 08695-00260
09-99 Celica (RHD) - 8
Celica TNS 500
WIRE HARNESS SUB-ASSY - SPEED LINE (VIOLET/WHITE)
WIRE HARNESS
ANTENNA WIRE
WIRE HARNESS REVERSE SENSOR WIRE (RED/BLUE)
INSTALLATION OVERVIEW
2
6
Audio Assembly
Monitor
Wire Harness
3
Computer
20
Antenna Wire
(to the Deck Floor Box)
2
3
6
GPS Antenna
21
1
09-99Celica (RHD) - 9
Celica TNS 500
GENERAL OUTLINE (Audio with AVC-LAN)
Refer to the repair manual for information on removal of vehicle parts, installation methods, torque and so forth.
1
Monitor
Wire Harness
3
Computer
20
Antenna Wire
GPS Antenna
21
The wire harness connection depends on the type of audio; for more details see pages 10 - 11 - 12.
To connect the CD-Changer an additional subwire harness (08695-00260) is required.
See page 7.
Note : CD-Changer installation
Audio assy
Splicing connector
Vehicle wire harness
12P 10P6P 8P
1P
13P
2P
8P
DIN-13P
*do not remove the cover
HOW TO CONNECT
Wire
Harness Sub-Assy
- Speed Line (violet/white)
2
*Connecting
Terminal for
Multi-CD Changer
Audio Assy
18401
TF4301
CD-Changer
TM0461
09-99 Celica (RHD) - 10
Celica TNS 500
8P 8P 6P13P 10P
10P
12P
2P
Antenna
Antenna
Audio Assy
DIN 13P (No use)
Reverse signal
Reverse signal
SPD
SPD
• Audio Unit Application
AUDIO ASSY + NAVIGATION SYSTEM
AUDIO ASSY + NAVIGATION SYSTEM + CD-CHANGER
2
3
20
21
1
8P 8P 6P
13P 10P
10P
12P
12P
12P
1P
2P
* 08695-00260 To be ordered separately
* 08695-00260
Disconnect
To CD-Changer unit
3
20
21
1
DETAILED CONNECTION OUTLINE
FUJITSU TEN AUDIO UNIT (WITH AVC-LAN)
DIN 13P (No use)
Audio Assy
2
CD-Changer
wire
Otros manuales para Celica guide
2
Este manual sirve para los siguientes modelos
1
Tabla de contenidos
Otros manuales de Sistema de navegación para automóviles de Toyota
Toyota
Toyota TNS300ETA Manual de usuario
Toyota
Toyota Verso TNS510 Manual de usuario
Toyota
Toyota Prius PHV 2019 Manual de usuario
Toyota
Toyota Prius Navi Manual de usuario
Toyota
Toyota TNS 200 Manual de usuario
Toyota
Toyota Hilux 2017 Manual de usuario
Toyota
Toyota 4RUNNER 2010 Manual de usuario
Toyota
Toyota GR YARIS Manual de usuario
Toyota
Toyota VENZA NAVI Manual de usuario
Toyota
Toyota AYGO X-NAV RHD Manual de usuario
Toyota
Toyota TNS400 Manual de usuario
Toyota
Toyota AVALON - 2011 Manual de usuario
Toyota
Toyota TNS 300 Manual de usuario
Toyota
Toyota 2014 Prius V Manual de usuario
Toyota
Toyota 4Runner 2021 Manual de usuario
Toyota
Toyota TNS 300 Manual de usuario
Toyota
Toyota Aygo X-NAV Manual de usuario
Toyota
Toyota OM30875U Manual de usuario
Toyota
Toyota Verso Navi Manual de usuario
Toyota
Toyota TNS600 Manual de usuario
