Toshiba TDP-FF1A Manual de usuario

SERVICE MANUAL

FILE NO. 330-200603GR

LED DATA PROJECTOR

TDP-FF1A

The above models are classified as green product (s) (*1), as indicated by the underlined serial number (s).

This Service Manual describes replacement parts for green product (s). When repairing any green product (s), use

the parts described in this manual and lead-free solder (*2).

For (*1) and (*2) , see the next page.

Published in Japan, March 2006GREEN© TOSHIBA CORPORATION

(*1) GREEN PRODUCT PROCUREMENT

The EC is actively promoting the WEEE & RoHS Directives that define standards for recycling

and reuse of Waste Electrical and Electronic Equipment and for the Restriction of the use of

certain Hazardous Substances. From July 1, 2006, the RoHS Directive will prohibit any

marketing of new products containing the restricted substances.

Increasing attention is given to issues related to the global environmental. Toshiba Corporation

recognizes environmental protection as a key management tasks, and is doing its utmost to

enhance and improve the quality and scope of its environmental activities. In line with this,

Toshiba proactively promotes Green Procurement, and seeks to purchase and use products,

parts and materials that have low environmental impacts.

Green procurement of parts is not only confined to manufacture. The same green parts used in

manufacture must also be used as replacement parts.

(*2) LEAD-FREE SOLDER

This product is manufactured using lead-free solder as a part of a movement within the consumer

products industry at large to be environmentally responsible. Lead-free solder must be used in

the servicing and repair of this product.

WARNING

This product is manufactured using lead free solder.

DO NOT USE LEAD BASED SOLDER TO REPAIR THIS PRODUCT !

The melting temperature of lead-free solder is higher than that of leaded solder by 86°F to 104°F

(30°C to 40°C). Use of a soldering iron designed for lead-based solders to repair product made

with lead-free solder may result in damage to the component and or PCB being soldered. Great

care should be made to ensure high-quality soldering when servicing this product especially

when soldering large components, through-hole pins, and on PCBs as the level of heat

required to melt lead-free solder is high.

FF1

Preface

This manual is applied to FF1 0.55” DMD SVGA (S8) digital projection system. It’s the mode

of single Panel, Osram LED module and 800(H) x 600(V) resolution. The manual gives you a

brief description of basic technical information to help in service and maintaining the product.

Your customers will appreciate the quick response time when you immediately identify prob-

lems that occur with our products. We expect your customers will appreciate the service that

youofferthem.

This manual is for technicians and people who have an electronic background. Send the

product back to the distributor for repairing and do not attempt to do anything that is complex

or is not mentioned in the troubleshooting.

NOTICE :

The information found in this manual is subject to change without prior notice.Any subsequent

changes made to the data herein will be incorporated in further edition.

Manual Version 1.0

TableofContents

Chapter1Introduction 1-1

Highlight1-1

MechanicalSpecifications1-2

ElectricalSpecifications1-2

BatterySpecifications1-3

OpticalSpecifications1-4

Environmental1-5

CompatibleMode 1-6

Chapter2DisassemblyProcess 2-1

EquipmentNeeded 2-1

DisassembleTop Cover,MainBoard,Fan Module,LEDBoard

and Speaker2-2

DisassembleFrontCover,IRLens,Engine Module,FocusRing

andDMDModule 2-5

DisassembleI/O Board,PowerBoardand BatteryBoard 2-7

Chapter3Troubleshooting 3-1

EquipmentNeeded 3-1

MainProcedure 3-2

LED/Icon Message 3-3

Chapter4Function Testand AlignmentProcedure 4-1

TestEquipmentNeeded 4-1

ServiceMode 4-1

TestCondition 4-2

InspectionProcedure 4-2

Chapter5FirmwareUpgradeProcedure 5-1

EquipmentNeeded 5-1

HardwareSetup Procedure 5-2

FirmwareSoftwareInstallationProcedure 5-2

FirmwareUpgrade Procedure 5-6

Chapter6 Spare Parts 6-1

FF1

1-1 FF1

No Item Description

1 DMD One panel 0.55” DMD SVGA projection system with 15 ANSI

lumens

2 Lamp Osram LE ATB A2A LED module

3 Weight Light weight Approx. 565 Grams, (1.25 lbs)

4 Resolution True 800 x 600 resolution, 16.7M True colors

5Video capabil-

ity

Build-in full screen NTSC/PAL/SECAM/HDTV (480 i/p, 576i/p,

720p, 1080i) video capabilities with a Composite terminal

6 Expandiability UXGA/SXGA/XGA/SVGA/VGA/MAC compatibility with one D-

sub 15-pin input terminal

7 Language On-screen menu with 8 languages

8 Auto function

Auto image re-sizing to 800 x 600 full screen

Auto detection of computer signal input

Auto Image synchronization (Auto-tracking /frequency /posi-

tion adjustment)

Chapter 1

Introduction

1-1 Highlight

1-2 FF1

No Item Description

1Dimensions

(WxHxD) 140mm x 48mm (min. front view) x 102mm

2Cooling

System

One fan with low system acoustic noise level

Maximum touch temperature follows the UL60950 regulation

3 Cabinet Provides space for PCB boards, fan, optical engine, speaker and

LED

4Keystone

correction +/ -16 degree

No Item Description

1Power

Supply

External adapter: 100--240V AC, 50/60 Hz input; 15V DC, 4A

output.

System power input: 15V DC

2Power

Consumption

< 18W, where USB power(5V, 0.5A) is used to drive an USB-

HDD.

3 Terminals

One D-Sub 15-pin female connector for analog RGB / HDTV /

compoment video

One Phone Jack for audio input

One Phone Jack for headphone out

One RCA Jack for Composite Video Input

USB connector for USB pendrive

4Input signal

spec.

Hsync Frequency: 15 ~ 100 kHz

Vsync Frequency: 43 ~ 85 Hz

Video Signal RGB (PC)

-Analog RGB 0.7 Vp-p, 75 ohms, separate TTL H&V Sync

-Analog RGB 1.0 Vp-p, 75 ohms, Sync on Green

-Analog RGB 0.7 Vp-p, 75 ohms, composite TTL Sync

Video

-Composite video 1.0 Vp-p, 75 ohms

-S-video Luminance 0.714 Vp-p, 75 ohms

-Chrominance 0.286 Vp-p, 75 ohms

1-3 Electrical Speciﬁcations

1-2 Mechanical Speciﬁcations

1-3 FF1

No Item Description

5System Con-

troller

TI DDP2000 component set,

Micronas VPX3226 Video decoder

ADI AD9883 compatible A/D converter

Atmel AT76C120 Digital Image Processor

6Video Com-

patibility

Standards :

-NTSC: M (3.58MHz), 4.43 MHz

-PAL: B, D, G, H, I, M, N

-SECAM: B, D, G, K, K1, L

-HDTV: 480i/p, 576i/p, 720p, 1080i

Wireless

Remote Con-

troller

One IR receiver in front

8 Audio 0ne 4-ohm 0.5W speaker

On-Screen

Display

8 languages selection: Japanese, English, French, German,

Italian, Spanish, Simpliﬁed Chinese, Swedish.

1-4 Battery Speciﬁcations

No Item Description

1 Battery cell Samsung 18650, 2200mAH, Li-Ion, Rechargable

2 Capacity 4400mAH, 7.4V, 4-cell, 2S2P

3 Battery life ~1.8 hours for operation at 18W.

4 Weight 250g

5Dimentions

(WxDxH)(mm) 140 x 21 x 57

6 Charging time ~3.5 hours, non-operating and operating

7Charging

method CC-CV

8Charging Cur-

rent 2000mA (If thermal test OK, will increase to 2200mA)

1-4 FF1

No Item Description

1Projection

lens F# 2.6, Fixed Lens.

2Focus

Range

40cm to 2.5m with full optical performance

30cm to 4m mechanical travel

3Throw

Ratio 1.8

4 Brightness 15 ANSI Lumens ( Typical ) / 12 ANSI Lumens ( Minimum)

5 Contrast 1500:1 Typical / 1000:1 Minimum (Full on / full off)

6 Uniformity 75% Typical / 60% Minimum (Japan standard)

7White color

uniformity

In white screen, the color coordinate of any two poits of ANSI 13

p ∆x<=0.02, ∆y<=0.02t

8 Lens Offset 110% +/- 10%

9TV distor-

tion <1.0% (at 100% offset condition)

1-5 Optical Speciﬁcations

1-5 FF1

No Item Description

1Tempera-

ture

Operating: 5 - 35°C

Storage: -20- 60°C

2Maximum

Humidity

Operating: 5 - 35°C, 80% RH (Max.), non-condensing

Storage: -20 - 60°C, 80%RH (Max.), non-condensing

3Acoustic

noise level 30+/-2 dB(A), typical, at 23 +/-2 degree C.

4 Lamp life >10,000 Hours

5 Altitude

Operating 0~2,500 ft, for 5°C~35°C

2,500~5,000 ft, for 5°C~30°C

5,000~10,000 ft, for 5°C~25°C

Storage 40,000 ft

1-6 Environmental

1-6 FF1

1-7 Compatible Mode

Analog

Compatibility Resolution V-Sync[Hz] H-Sync[KHz]

VGA 640x350 70 31.5

640x350 85 37.9

640x400 85 37.9

640x480 60 31.5

640x480 72 37.9

640x480 75 37.5

640x480 85 43.3

720x400 70 31.5

720x400 85 37.9

SVGA 800x600 56 35.2

800x600 60 37.9

800x600 72 48.1

800x600 75 46.9

800x600 85 53.7

XGA 1024x768 60 48.4

1024x768 70 56.5

1024x768 75 60

1024x768 85 68.7

SXGA 1152x864 70 63.8

1152x864 75 67.5

1152x864 85 77.1

1280x1024 60 63.98

1280x1024 75 79.98

SXGA+ 1400x1050 60 63.98

UXGA *Note(1) 1600x1200 60 75

MAC LC 13” 640x480 66.66 34.98

MAC II 13” 640x480 66.68 35

MAC 16” 832x624 74.55 49.725

MAC 19” 1024x768 75 60.24

MAC 1152x870 75.06 68.68

MAC G4 640x480 60 31.35

i Mac DV 1024x768 75 60

i Mac DV 1152x870 75 68.49

i Mac DV 1280x960 75 75

Otros manuales para TDP-FF1A

Tabla de contenidos

Otros manuales de Proyector de Toshiba

Toshiba

Toshiba TLP-MT7 - LCD Projector - 1000 ANSI Lumens Manual de usuario

Toshiba

Toshiba TDP-T420U - XGA DLP Projector Manual de usuario

Toshiba

Toshiba TDP-SC35U Manual de usuario

Toshiba

Toshiba TDP-TW355 Manual de usuario

Toshiba

Toshiba TLP-560 Manual de usuario

Toshiba

Toshiba P500DL Manual de usuario

Toshiba

Toshiba TLP-X2000B Manual de usuario

Toshiba

Toshiba TDP-MT700 Manual de usuario

Toshiba

Toshiba TLP-T720U Manual de usuario

Toshiba

Toshiba TDP-S3 Manual de usuario

Toshiba

Toshiba TDP-T98 Manual de usuario

Toshiba

Toshiba TDP-B1-US Manual de usuario

Toshiba

Toshiba TLP-B2U Manual de usuario

Toshiba

Toshiba TDP TDP-T9 Manual de usuario

Toshiba

Toshiba X100U - TLP XGA LCD Projector Manual de usuario

Toshiba

Toshiba TDP-T355 Manual de usuario

Toshiba

Toshiba TLP780U Manual de usuario

Toshiba

Toshiba TLP411E Guía de instalación

Toshiba

Toshiba TDP-P5 Manual de usuario

Toshiba

Toshiba TDP-P5 Manual de usuario

Toshiba

Toshiba TLP-XC2000U Manual de usuario

Toshiba

Toshiba TDP-MT5 Manual de usuario

Toshiba

Toshiba TLP-MT7E Manual de usuario

Toshiba

Toshiba TLP-X10E Manual de usuario

Manuales populares de Proyector de otras marcas

iEmmet

iEmmet MP-312 Manual de usuario

Epson

Epson VS400 Manual de usuario

Sony

Sony VPL-HS10 Marketing Specifications & Features Manual de usuario

Sony

Sony VPL-HW65ES Manual de servicio

Philips

Philips LC1341 Guía de referencia

Panasonic

Panasonic PTL735NTU - LCD PROJECTOR-NETWORK IB Manual de usuario

NEC

NEC NP600S EDU Manual de usuario

BenQ

BenQ SH753P Manual de usuario

Eiki

Eiki EK-623U series Manual de usuario

Epson

Epson PowerLite Pro Cinema 6020UB Manual de usuario

Epson

Epson PowerLite Home Cinema 705HD Manual de usuario

Christie

Christie LHD700 Manual de usuario

Navitar

Navitar FX Manual de usuario

InFocus

InFocus LitePro 560 Manual de usuario

Sony

Sony SRX-R815P Manual de usuario

Vivitar

Vivitar DP1500 X Manual de usuario

Acer

Acer C20 Series Manual de usuario

Asus

Asus ZenBeam Latte Manual de usuario