Toro 70185 Manual

2003 by The Toro Company

8111 Lyndale Avenue South

Bloomington, MN 55420-1196

Printed in Italy

13-32

Rear Engine Rider

Model Nos. 70185 and 70186

Form No. 3351-232

Setup Instructions

Loose Parts

Description Qty. Use

Wheels

Flat washers, M16 (3 mm thick)

Spacers, M16 (1 mm thick)

Cotter pins

Installing the front wheels

Seat

Screws, M8 x 18 mm

Flat washers, M9

Lock washers

Installing the seat

Socket pin 1Attaching the steering wheel

Engine cover

Screws, M6 x 25 mm 1

2Installing the engine cover

Frame

Fabric bag with clips

Handle

Locknuts, M8

Washers, M9

Assembling the grass collector

Z-brackets

Bolts, M6 x 16.2 mm

Nuts, M6

Grass collector cover

Pins

Full bag lever

Installing the grass collector

Bolts, M6 x 20 mm

Flat washers, M6.5

Nuts, M6

2Installing the battery

Recyclercover 1Recycling the grass clippings; refer to the tractor

Operator’s Manual

Draining tube 1Draining the engine oil

Keys 2 Using the keys in ignition and KeyChoiceswitches

Spark plug wrench 1Replacing the spark plug

Operator’s Manuals

(English and French)

Engine operator’s manual 2

1Reading before operating the tractor

Assembling the Tractor

Installing the Front Wheels

1. Slide a flat washer (M16, 3mm thick) onto each spindle

(Fig. 1).

Figure 1

1. Spindle

2. Wheel

3. Flat washer

(M16, 3 mm thick)

4. Spacers

(M16, 1 mm thick)

5. Cotter pin

2. Mount the wheels and secure each of them with

2 spacers (M16, 1 mm thick) and a cotter pin (Fig. 1).

3. Grease the wheels.

Installing the Seat

Attach the seat to the support plate with 4 flat washers

(M9), lock washers, and screws (M8 x 18 mm) (Fig. 2).

Figure 2

1. Seat Support plate

2. Flat washer (M9) 3. Lock washer

4. Screw (M8 x 18 mm)

Note: Before tightening the screws, adjust the seat to a

position that is most comfortable for you.

Attaching the Steering Wheel

1. Rotate the steering wheel upward until it is aligned with

the steering column.

2. Secure the steering wheel with the socket pin (Fig. 3).

Figure 3

1. Socket pin

Installing the Engine Cover

1. Slide the tabs on the engine cover into the slots on the

body of the tractor (Fig. 4).

m–5980

Figure 4

1. Engine cover 2. Screw

2. Secure the cover with 2 screws (M6 x 25 mm) (Fig. 4).

Assembling the Grass Collector

1. Slide the bag onto the frame and secure it with the clips

(Fig. 5).

Figure 5

1. Bag 2. Frame

2. Secure the handle to the bag assembly with 4 washers

(M9) and 2 locknuts (M8) (Fig. 6).

Figure 6

1. Bag assembly

2. Handle 3. Washer (M9)

4. Locknut (M8)

Installing the Grass Collector

1. Reach beneath the rear of the tractor and hold the full

bag switch and switch plate while removing the 2

screws on the rear panel (Fig. 7).

m-6101

123

Figure 7

1. Rear panel

2. Switch

3. Switch plate

4. Full bag lever

5. Screw

2. Hold the switch plate against the switch and slide the full

bag lever into the rectangular slot on the rear panel.

3. Hook the switch plate onto the lever and secure the

switch and switch plate to the rear panel with the 2

screws (Fig. 7).

4. Attach the grass collector to the rear of the tractor with

2 Z-brackets, bolts (M6 x 16.2 mm), and nuts (M6)

(Fig. 8).

Figure 8

1. Grass collector

2. Z-bracket 3. Bolt (M6 x 16.2 mm)

4. Nut ( M6)

5. Attach the grass collector cover to the tractor with

2 pins (Fig. 9).

Figure 9

1. Grass collector cover 2. Pin

Activating the Battery

Purchase bulk electrolyte with 1.260 specific gravity from a

local battery supply outlet.

Danger

Battery electrolyte contains sulfuric acid, a deadly

poison that can cause severe burns.

•Do not drink electrolyte and avoid contact with

skin, eyes or clothing. Wear safety glasses to

shield your eyes and rubber gloves to protect

your hands.

•Fill the battery where clean water is always

available for flushing the skin.

•Follow all instructions and comply with all

safety messages on the electrolyte container.

1. Remove the battery from the tractor and place it on a

level surface; refer to Removing the Battery in the

Operator’s Manual.

Important Never fill the battery with electrolyte while

the battery is installed in the tractor. You could spill

electrolyte on other parts and cause corrosion.

2. Clean the top of the battery with a paper towel.

3. Remove the vent caps from the battery (Fig. 10).

m5004

Figure 10

1. Vent caps

2. Upper line 3. Lower line

4. Slowly pour electrolyte into each battery cell until the

electrolyte level is up to the Upper line on the battery

case (Fig. 10).

Important Do not overfill the battery because

electrolyte (sulfuric acid) can severely corrode and damage

the chassis.

5. Wait 5 to 10 minutes after filling the battery cells, then

add electrolyte, if necessary, until the electrolyte level is

up to the upper line (Fig. 10) on the battery case.

6. Install the battery vent caps.

7. Charge the battery for 1 hour at 25 to 30 amps or

6 hours at 4 to 6 amps. Do not overcharge the battery.

Charging the battery produces gasses that can

explode.

Never smoke near the battery and keep sparks and

flames away from battery.

Warning

8. When the battery is fully charged, unplug the charger

from the electrical outlet, then disconnect the charger

leads from the battery posts (Fig. 11).

Figure 11

1. Positive post

2. Negative post 3. Charger red (+) wire

4. Charger black (–) wire

9. Install the battery in the tractor and connect the battery

cables; refer to Installing the Battery in the Operator’s

Manual.

Checking the Engine Oil Level

Before you start the engine and use the tractor, check the oil

level in the engine crankcase; refer to Checking the Oil

Level in the Operator’s Manual.

Filling the Fuel Tank

Add fuel to the fuel tank; refer to Filling the Fuel Tank in

the Operator’s Manual.

Checking the Tire Pressure

Check the front and rear tires for proper inflation; refer to

Checking the Tire Pressure in the Operator’s Manual.

Testing the Safety System

Test the safety interlock system; refer to The Safety

Interlock System in the Operator’s Manual.

Otros manuales para 70185

Este manual sirve para los siguientes modelos

Otros manuales de Cortacésped de Toro

Toro

Toro 03708N Manual de usuario

Toro

Toro TimeCutter Z4200 Manual de usuario

Toro

Toro greensmaster 04128 Manual de usuario

Toro

Toro 30432 Manual de usuario

Toro

Toro 03550 Reelmaster 5500-D Manual de usuario

Toro

Toro 74806 Manual de usuario

Toro

Toro 74264 Manual de usuario

Toro

Toro Recycler 20331 Manual de usuario

Toro

Toro Reelmaster 7000-D Manual de usuario

Toro

Toro GrandStand Multi Force 72524 Manual de usuario

Toro

Toro Recycler 20961 Manual de usuario

Toro

Toro Reelmaster 5010- H Manual de usuario

Toro

Toro Groundsmaster 1200 Series Manual de usuario

Toro

Toro 30857N Manual de usuario

Toro

Toro ProLine 30177 Manual de usuario

Toro

Toro Recycler 147-8696 Manual de usuario

Toro

Toro GrandStand 74583 Manual de usuario

Toro

Toro TITAN ZX 5400 Manual de usuario

Toro

Toro Reelmaster 3555 Manual de usuario

Toro

Toro 72098 Manual de usuario

Toro

Toro TimeCutter 75762 Manual de usuario

Toro

Toro LX420 13AX60RG744 Manual de usuario

Toro

Toro TimeCutter 74780 Manual de usuario

Toro

Toro Recycler 21321 Manual de usuario

Manuales populares de Cortacésped de otras marcas

RHINO

RHINO 1958 Manual de usuario

Wolf Garten

Wolf Garten Compact plus 40 B Manual de usuario

Cub Cadet

Cub Cadet LTX 1045 Manual de usuario

Craftsman

Craftsman 917.378461 Manual de usuario

GGP ITALY SPA

GGP ITALY SPA CR/CS 434 SERIES Manual de usuario

Challenge

Challenge CH18V2 Instrucciones de operación

TALEN TOOLS

TALEN TOOLS AVR HGM30 Manual de usuario

DEWEZE

DEWEZE ATM-725 Manual de operación

Weed Eater

Weed Eater 180083 Manual de usuario

Husqvarna

Husqvarna Poulan Pro PP185A42 Manual de usuario

Better Outdoor Products

Better Outdoor Products Quick Series Manual de usuario

Cub Cadet

Cub Cadet 23HP Z-Force 60 Manual de funcionamiento

MTD

MTD 795, 792, 791, 790 Manual de usuario

Dennis

Dennis FT 610 Manual de usuario

AIRFORCE

AIRFORCE F-15 Gen 3 Manual de usuario

MTD

MTD 126-220-000 Manual de usuario

Stihl

Stihl RMA 443 PV Manual de usuario

Yard-Man

Yard-Man 3700-0 Manual de usuario