SMA SUNNY SENSORBOX Manual de usuario

Sensorbox-IUS084413 | 98-0003913 | Version 1.3 US

System Monitoring

SUNNY SENSORBOX

Installation Guide

SMA Solar Technology AG

Installation Guide Sensorbox-IUS084413 3

No part of this document may be reproduced, stored in a retrieval system, or transmitted, in any

form or by any means, electronic, mechanical, photographic, magnetic or otherwise, without the

prior written permission of SMA America, Inc.

SMA America makes no representations, express or implied, with respect to this documentation or

any of the equipment and/or software it may describe, including (with no limitation) any implied

warranties of utility, merchantability, or fitness for any particular purpose. All such warranties are

expressly disclaimed. Neither SMA America nor its distributors or dealers shall be liable for any

indirect, incidental, or consequential damages under any circumstances.

(The exclusion of implied warranties may not apply in all cases under some statutes, and thus the

above exclusion may not apply.)

Specifications are subject to change without notice. Every attempt has been made to make this

document complete, accurate and up-to-date. Readers are cautioned, however, that SMA America

reserves the right to make changes without notice and shall not be responsible for any damages,

including indirect, incidental or consequential damages, caused by reliance on the material

presented, including, but not limited to, omissions, typographical errors, arithmetical errors or listing

errors in the content material.

SMA America, Incorporated

4031 Alvis Court

Rocklin, California 95677-4011

Tel 916.625.0870

Fax 916.625.0871

www.sma-america.com

SMA Solar Technology AG

4Sensorbox-IUS084413 Installation Guide

IMPORTANT SAFETY INSTRUCTIONS

SAVE THESE INSTRUCTIONS

This manual contains important instructions for Models SUNNY SENSORBOX - SYSTEM

MONITORING UNIT, that shall be followed during installation and maintenance of the unit.

The Sunny SensorBox is designed and tested according to international safety requirements, but as

with all electrical and electronic equipment, certain precautions must be observed when installing

and/or operating the Sunny SensorBox. To reduce the risk of personal injury and to ensure the safe

installation and operation of the Sunny SensorBox, you must carefully read and follow all

instructions, cautions and warnings in this Installation Guide.

Warnings

A Warning describes a hazard to equipment or personnel. It calls attention to a procedure or

practice, which, if not correctly performed or adhered to, could result in damage to or destruction

of part or all of the SMA equipment and/or other equipment connected to the SMA equipment or

personal injury.

DANGER!

DANGER indicates a hazardous situation which, if not avoided, will result in death or

serious injury.

WARNING!

WARNING indicates a hazardous situation which, if not avoided, could result in death

or serious injury.

CAUTION!

CAUTION indicates a hazardous situation which, if not avoided, could result in minor or

moderate injury.

NOTICE!

NOTICE indicates a situation that can result in property damage if not avoided.

SMA Solar Technology AG

Installation Guide Sensorbox-IUS084413 5

Other Symbols

In addition to the safety and hazard symbols described on the previous pages, the following symbol

is also used in this Installation Guide:

General Warnings

Warranty

The current guarantee conditions are available at www.sma-america.com and can be downloaded

or are available on paper from the usual sales channels if required. For warranty coverage, or if

you have questions about the Sunny SensorBox warranty, contact SMA America at the address,

telephone number or Web site listed on page 3 (to send E-mail, see the Contact section of the SMA

America Web site).

Information

This symbol accompanies notes that call attention to supplementary information that you

should know and use to ensure optimal operation of the system.

General Warnings

All electrical installations must be done in accordance with the local and National

Electrical Code ANSI/NFPA 70.

Before installing or using the Sunny SensorBox, read all of the instructions, cautions, and

warnings on the Sunny SensorBox, the PV array, in this Installation Guide and in User

Manual.

PV arrays produce electrical energy when exposed to light and thus can create an

electrical shock hazard. Wiring of the PV-arrays shall only be performed by qualified

personnel.

Only use the plug-in power supply delivered with the Sunny SensorBox. Use of alternate

power supplies will void the warranty.

SMA Solar Technology AG

6Sensorbox-IUS084413 Installation Guide

SMA Solar Technology AG Table of Contents

Installation Guide Sensorbox-IUS084413 7

Table of Contents

1 Notes on this Manual. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11

1.1 Area of Validity. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11

1.2 Target Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11

2 Security . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12

2.1 Appropriate Usage. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12

2.2 Safety Precautions. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13

3 Unpacking. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15

3.1 Packing List . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15

3.2 Identifying the Product . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16

3.2.1 Type Plate . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16

3.2.2 Firmware Version . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16

4 Mounting the Device . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17

4.1 Selecting the Mounting Location. . . . . . . . . . . . . . . . . . . . . . . . 17

4.1.1 Sunny SensorBox . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17

4.1.2 RS485-Power Injector . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17

4.1.3 Module Temperature Sensor. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18

4.2 Mounting the Sunny SensorBox . . . . . . . . . . . . . . . . . . . . . . . . 18

4.2.1 Mounting on a Module Frame . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19

4.2.2 Mounting on a Rafter. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20

4.3 Mounting the RS485-Power Injector. . . . . . . . . . . . . . . . . . . . . 22

4.3.1 Wall Mounting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22

4.4 Mounting the Module Temperature Sensor . . . . . . . . . . . . . . . 24

5 Electrical Connection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26

5.1 Overview of the Connection Area . . . . . . . . . . . . . . . . . . . . . . 27

5.1.1 Sunny SensorBox . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27

5.1.2 RS485-Power Injector . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28

Table of Contents SMA Solar Technology AG

8Sensorbox-IUS084413 Installation Guide

5.2 Operation of the clamps. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28

5.2.1 Operating the Plug of the RS485-Power Injector . . . . . . . . . . . . . . . . . . . . . 28

5.2.2 Operating the Terminals in the Sunny SensorBox . . . . . . . . . . . . . . . . . . . . . 29

5.2.3 Operating the Connection Terminal for Cable Shield. . . . . . . . . . . . . . . . . . 29

5.2.4 Operating the Terminals for the Sensors . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30

5.3 Connecting the Sunny SensorBox to the RS485 Communication

Bus . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30

5.3.1 Connecting the RS485-Power Injector to the RS485 Bus Subscribers . . . . . 30

5.3.2 Connecting the RS485-Power Injector to the Sunny SensorBox . . . . . . . . . . 33

5.3.3 Connecting the Sunny SensorBox to an additional Sunny SensorBox . . . . . 36

5.3.4 Connecting the Sunny SensorBox to an Additional RS485 Bus Subscriber . 40

5.3.5 Terminating the RS485 Bus. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42

5.4 Connecting the Module Temperature Sensor . . . . . . . . . . . . . . 42

6 Commissioning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 44

6.1 Connecting the RS485-Power Injector to the Power Supply. . . 44

7 Maintenance and Care . . . . . . . . . . . . . . . . . . . . . . . . . . . 45

7.1 Maintenance. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 45

7.2 Care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 45

8 Decommissioning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46

8.1 Removing the Sunny SensorBox . . . . . . . . . . . . . . . . . . . . . . . . 46

8.2 Removing the RS485-Power Injector. . . . . . . . . . . . . . . . . . . . . 46

8.3 Removing the Sensors. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 47

8.4 Packaging the Sunny SensorBox and Sensors . . . . . . . . . . . . . 47

8.5 Disposing of the Sunny SensorBox and Sensors. . . . . . . . . . . . 47

9 Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 48

9.1 Sunny SensorBox . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 48

9.1.1 Meaning of the LED . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 48

9.2 Ambient Temperature Sensor . . . . . . . . . . . . . . . . . . . . . . . . . . 49

SMA Solar Technology AG

Installation GuideSensorbox-IUS0844139

9.3 Anemometer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 49

9.4 Integrated Irradiation Sensor . . . . . . . . . . . . . . . . . . . . . . . . . . 49

9.4.1 Connection of the Integrated Irradiation Sensor. . . . . . . . . . . . . . . . . . . . . . 50

10 Opening and Closing the Sunny SensorBox . . . . . . . . . . 51

10.1 Opening the Sunny SensorBox. . . . . . . . . . . . . . . . . . . . . . . . . 51

10.2 Closing the Sunny SensorBox . . . . . . . . . . . . . . . . . . . . . . . . . . 52

11 Channel List. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 53

11.1 General Parameters . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 53

11.2 Internal Solar Irradiation Sensor. . . . . . . . . . . . . . . . . . . . . . . . 54

11.3 Module Temperature Sensor . . . . . . . . . . . . . . . . . . . . . . . . . . 54

11.4 Ambient Temperature Sensor . . . . . . . . . . . . . . . . . . . . . . . . . . 54

11.5 External Irradiation Sensors . . . . . . . . . . . . . . . . . . . . . . . . . . . 55

11.6 Anemometer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 55

12 Technical Data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 56

12.1 FCC Compliance Information . . . . . . . . . . . . . . . . . . . . . . . . . . 58

13 Accessories . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 59

13.1 Mounting accessories . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 59

13.2 RS485-Power Injector . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 59

13.3 Seals of the Sunny SensorBox . . . . . . . . . . . . . . . . . . . . . . . . . 59

13.3.1 Packing List . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 60

13.3.2 Replacing the Cable Gland Seal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 60

13.4 Ambient Temperature Sensor . . . . . . . . . . . . . . . . . . . . . . . . . . 62

13.4.1 Packing List . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 62

13.4.2 Cabling Recommendations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 62

13.4.3 Selecting the Mounting Location. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 63

13.4.4 Mounting the Ambient Temperature Sensor . . . . . . . . . . . . . . . . . . . . . . . . . 63

13.4.5 Connecting the Ambient Temperature Sensor to the Sunny SensorBox . . . . 64

13.4.6 Technical Data for the Ambient Temperature Sensor . . . . . . . . . . . . . . . . . . 65

SMA Solar Technology AG

10 Sensorbox-IUS084413 Installation Guide

13.5 Anemometer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 66

13.5.1 Packing List . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 66

13.5.2 Cabling Recommendations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 66

13.5.3 Selecting the Mounting Location. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 67

13.5.4 Mounting the Anemometer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 68

13.5.5 Connecting the Anemometer to the Sunny SensorBox . . . . . . . . . . . . . . . . . 71

13.5.6 Technical Data of the Anemometer. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 72

14 Contact . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 73

Otros manuales para SUNNY SENSORBOX

Tabla de contenidos

Otros manuales de Instrumento de medición de SMA

SMA

SMA SUNNY WEBBOX with Bluetooth Manual de usuario

SMA

SMA SUNNY HOME MANAGER 2.0 Manual de usuario

SMA

SMA SUNNY WEBBOX with Bluetooth Manual de usuario

SMA

SMA HM-20 Manual de usuario

SMA

SMA SUNNY STRING-MONITOR Manual de lista de piezas

SMA

SMA SUNNY WEBBOX with Bluetooth Manual de usuario

SMA

SMA STRING-MONITOR SSM-U-1610 Manual de usuario

SMA

SMA STRING-MONITOR SSM-U-2410 Manual

SMA

SMA SUNNY WEBBOX with Bluetooth Manual de usuario

SMA

SMA SCHOOLMETERBOX Manual de usuario

SMA

SMA SUNNY HOME MANAGER 2.0 Manual de usuario

SMA

SMA SUNNY WEBBOX Bluetooth Wireless Technology Manual de usuario

SMA

SMA SUNNY WEBBOX with Bluetooth Manual de usuario

SMA

SMA SUNNY WEBBOX with Bluetooth Manual de usuario

SMA

SMA SUNNY WEBBOX with Bluetooth Manual de usuario

SMA

SMA POWER REDUCER BOX Manual de lista de piezas

Manuales populares de Instrumento de medición de otras marcas

Suaoki

Suaoki D40 Manual de usuario

Elster

Elster BK-G1.6 Manual de usuario

Endress+Hauser

Endress+Hauser Deltabar FMD71 Manual

Duratool

Duratool D03128 Manual de usuario

Vega

Vega VEGAPULS 65 Manual de usuario

Tonghui

Tonghui TH2618B Manual de usuario

Tenmars

Tenmars TM-801 Manual de usuario

MSR

MSR 145 Manual de usuario

TPS

TPS WP-82 Manual de usuario

ELMETRON

ELMETRON CP-511 Manual de usuario

PCB Piezotronics

PCB Piezotronics 003C30 Manual de usuario

Tenma

Tenma 72-10465 Manual de usuario

Endress+Hauser

Endress+Hauser Proline Promag 50 Especificaciones técnicas

Siemens

Siemens SITRANS F Coriolis FCT030 Manual de lista de piezas

KLINGER

KLINGER CMF V Series Manual de usuario

EXFO

EXFO FTB-2 Manual de operación y mantenimiento

Keysight

Keysight M8290A Manual de usuario

ADTEK

ADTEK MW-5 Manual de usuario