Ski-Doo NORDIK Manual de usuario

1982

OPERATOR6S

MANUAL

NORDIK*

SKANDIC*

®*Trademarks of Bombardier Inc.

Litho'd

in Canada All rights

reserved

©BombardierInc.

414472700

model

V.I.N.

purchase

date _

warranty

expiry

date

To be completed by dealer at time of sale

DEALER IMPRINT AREA

MOTO-SKI

FUTURA

SPIRIT

NUVIK

MIRAGE

SUPER SONIC

ULTRA SONIC

SONIC

TECHNICAL PUBLICATIONS

AFTER SALES SERVICE

BOMBARDIER INC.

VALCOURT, QUEBEC

CANADA,

JOE2LO

The following are trademarks of Bom-

bardier Inc.

BOMBARDIER EVEREST

SKI-DOO CITATION

ALPINE OLYMPIQUE

BLIZZARD

T'NT

CARRY-BOOSE NORDIK

ELAN SKANDIC

ELITE

GRAND PRIX SPECIAL

FOREWORD

The Operator Manual and the Snow-

mobile Safety handbook have been

prepared to acquaint the owner / oper-

ator of a new snowmobile with the var-

ious vehicle controls maintenance and

safe operating instructions. Each is in-

dispensable for the proper use of the

product, and should be kept with the

vehicle at all times.

Should you have any questions per-

taining to the warranty and its applica-

tion, please consult the "Often Asked

Question" section of this manual, or

your selling dealer.

This manual uses the following sym-

bols. .

•

WARNING:

Identifies an instruc-

tion which, if not followed, could

cause personal injury.

...

CAUTION: Denotes an instruc-

...

tion which, if not followed, could

severely damage vehicle components.

ONOTE: Indicates supplementary

information needed to fully com-

plete an instruction.

Although the mere reading of such in-

formation does not eliminate the haz-

ard, your understanding of the infor-

mation will promote its correct use.

Most specifications are given in both metric and customary units. Where precise

accuracy is not required, some conversions are rounded to even numbers for

easier use.

A shop manual can be obtained for complete service, maintenance and repair in-

formation.

SAFETY

MAINTENANCE

Observe the following

precautions:

•Throttle mechanism should be

checked for free movement before

starting engine.

• Engineshould be running only when

pulley guard is secured in place.

• Never run the engine

without

drive

belt installed. Running an unloaded

engine can prove to be dangerous.

• Never run the engine when the track

is raised

off

the ground.

• It can be dangerous to run engine

with the hood removed.

• Gasoline is flammable and explosive

under certain conditions. Always

manipulate in a well ventilated area.

Do not smoke or allow open flames

or sparks in the vicinity. If gasoline

fumes are noticed while driving, the

cause should be determined and

corrected without delay.

• Maintain your vehicle in top mechan-

ical condition at all times.

• Your snowmobile is not designed to

be driven or operated on black top,

bare earth, or other abrasive sur-

faces. On such surfaces abnormal

and excessive wear of critical parts

is inevitable.

• Your snowmobile is not designed to

be operated on public streets, road

or highways. In most States and

Provinces, it is considered an illegal

operation.

• Installation of other than standard

equipment, including ski-spreaders,

bumpers, pack racks, etc.. could

severelyaffect the stability and safe-

ty of your vehicle. Avoid adding on

accessories that alter the basic ve-

hicle configuration.

• The snowmobile engine can be

stopped by activating the emergen-

cy cut-out switch, tether switch or

by turning

off

the key.

• Whenever the vehicle is parked out-

doors, overnight or for a long peri-

od, it issuggestedto protect it against

the inclemency of the weather with

asnowmobile cover.

• Do not lubricate throttle

and/or

brake cables and housings.

• Only perform procedures as detailed

in this manual. Unless otherwise

specified, engine should be turned

OFF for all lubrication and mainte-

nance procedures.

• Clean and check operation of the

headlight, taillight and brake light.

•

PLEASE

READAND UNDERSTAND

ALL WARNINGS AND CAUTIONS

IN THIS

MANUAL

AND ON THE

VEHICLE.

This

vehicle

isbuiltwith

parts

dimensioned

inthe

metric

system.

All

fasteners

are

metric

and must not be

replaced

customary

fasteners.

Mismatched or

incor-

rect

fasteners

could

cause

damage

to the

vehicle

orpossible

personal

injury.

THIS

MANUAL

SHOULD REMAIN

WITH

THE VEHICLE

THE

TIME

OF RESALE.

INDEX

THE 1982

"LIMITED

WARRANTY"

.............

OFTEN ASKED

QUESTIONS

LISTING OF AREA DISTRIBUTORS 8

HOW

TO IDENTIFY YOUR

SNOWMOBILE

.......................

..9

CONTROLs/INSTRUMENTS

Throttle lever, brake lever, parking brake, ignition light switch, headlamp dimmer

switch, emergency cut-out switch, manual starter, handle, primer, tether cut-out

switch, speedometer, trip meter, reset button, horn, hood opening, tool box, fuel

gauge, spark plug holder! spare drive belt, hitch, ski tie

down.

......

...

.10

BREAK-IN PERIOD

Break-in! inspection 10-hourjinspection checklist. .

... ...

....

.13

FUEL

Recommended gasoline! recommended oil, fuel mixture ratio, fuel mixing proce-

dure,

fuelloil

mixing

chart.

.15

PRE-START CHECK

Check points 17

STARTING PROCEDURE

Manual starting, emergency

starting.

. . . . . . . . .

....

. . . . .

....

...

LUBRICATION

Frequency, steering mechanism, chaincase oil level, drive axle, suspension. .19

MAINTENANCE

Chart, drive belt, new drive belt, pulley guard removal, drive belt removal &in-

stallation, brake condition, brake adjustment, brake light switch adjustment,

spark pluqts), track condition, track tension and alignment, suspension condi-

tion, suspension adjustment, drive pulley, steering mechanism, steering adjust-

ment, muffler

attachment

carburetor adjustment, fan

belt

engine head nuts, en-

gine

mount

nuts, headlamp beam aiming, bulb replacement, general inspec-

tion.

........

.21

STORAGE

Track! suspension, skis, controls, chaincase, drive pulley, fuel tank and carbure-

tor, cylinder lubrication, chassis, general inspection 30

PRE-SEASON PREPARATION

Pre-season preparation chart 32

TROUBLE

SHOOTING

GUIDE 34

TOOLS 38

SPECIFICATIONS.

. . . . . .

.37

WIRING

DIAGRAMS.

...................................

.39

METRIC

INFORMATION

GUIDE

......

... 40

CHANGE

OF ADDRESS OF OWNERSHIP 41

LIMITED

WARRANTY

1982 SKI-DOO®

SNOWMOBILES

1.PERIOD

BOMBARDIER® INC. as manufacturer, warrants FROM THE DATE OF FIRST

CONSUMER SALES, every 1982SKI-DOO® snowmobile, sold as NEW AND UN-

USED, by an authorized SKI-DOO dealer, for periods of:

• 12 consecutive months

for

ELAN®, CITATION*, EVEREST®, ELlTE®,

ALPINE® models.

• 90 consecutive days for NORDIK*, SKANDIC*, BLiZZARD® 5500MX and 9500

models subject to the following:

1. If delivery is made after the 31st day of March of a given year and before the 1st

day of December of the same year, the above 90 day warranty will start on De-

cember 1st.

2. If delivery is made

on/or

after the 2nd day of January of a given year but before

the 31st day of March of the same year, all the unused portion of the 90 day pe-

riod will be carried over to the next winter and start again on the 1st day of De-

cember of the same year.

2·

WHAT

BOMBARDIER WILL DO

BOMBARDIER will repair

and/or

replace, at its option, components defective in

material

and/or

workmanship (under normal use and service,)

with

a genuine

BOMBARDIER component

without

charge for parts or labour, at any authorized

SKI-DOO dealer during said warranty period.

CONDITION

HAVE

WARRANTY

WORK

PERFORMED

Presentto the servicing dealer, the hard copy of the BOMBARDIER Customer Re-

gistration card received by the customer from the selling dealer at time of pur-

chase.

4•

WARRANTY

TRANSFER

This warranty is transferable to subsequent ownertsl

for

remainder of warranty pe-

riod from original date of sale.

5·EXCLUSIONS · ARE

NOT

WARRANTED

• Normal wear on all items such as, but not limited to:

- drive belts

- slider shoes

spark plugs

- breaker points

- runners on skis

• Replacement parts

and/or

accessories which are

not

genuine BOMBARDIER

parts

and/or

accessories.

• Damage resulting from installation of parts other than genuine BOMBARDIER

parts.

• Damage caused by failure to provide proper maintenance as detailed in the

Operator Manual. The labour, parts and lubricants costs of all maintenance ser-

vices, including tune-ups and adjustments will be charged to the owner.

• A sulphated battery.

• Vehicles used

for

racing purposes.

• All optional accessories installed on the vehicle.

(The normal warranty policy

for

parts and accessories, if any, applies).

• Damage resulting

from

accident, fire or other casualty, misuse, abuse or ne-

glect.

• Damage resulting

from

modification to the snowmobile

not

approved in writing

by BOMBARDIER.

• Losses incurred by the snowmobile owner other than parts and labour, such as,

but

not

limited

to,

transportation,

towing,

telephone calls, taxis, or any otherin-

cidental or consequential damages.

Some states or provinces do not allow the exclusion or limitation

inciden-

tal or consequential damages, so the above limitation or exclusion may not

apply.

8.EXPRESSED OR IMPLIED WARRANTIES

This warranty gives you specific rights, and you may also have other legal

rights which may vary from state to state, or province to province. Whereap-

plicable this warranty is expressly in lieu of all other expressed or implied

warranties

BOMBARDIER, its distributors and the selling dealer, inclUding

any warranty of merchantability

fitness for any particular purpose; othe

....

wise the implied

warranty

is limited to the duration of this warranty. How-

ever, some states or provinces do not allow limitations on

how

long an im-

plied warranty lasts, so the above limitation

may

not apply.

Neither the distributor, the selling dealer, nor any other person has been

authorized to

make

any affirmation, representation or warranty other than

those contained in this warranty, and if made, such affirmation, representa-

tion or warranty shall not be enforceable against BOMBARDIER or any other

person.

BOMBARDIER INC. reserves the right to modify its warranty policy at any

time, being understood that such modification will not alter the warranty

conditions applicable to vehicles sold while the above warranty is in effect.

7-CONSUMER ASSISTANCE

If a servicing problem or other difficulty occurs, we suggest the following:

Try

to resolve the problem at the dealership

with

the Service Manager or

Owner.

2. If this fails, contact your area distributor listed in the Operator Manual.

3. Then if your.grievance still remains unsolved, you may

write

to us:

Bombardier Inc.

Service Department

Recreational Products

Valcourt, Quebec, Canada, JOE

210

January 1981

Bombardier Inc.

Valcourt, Quebec, Canada,·JOE

210

"Trademarks of Bombardier Inc.

OFTEN ASKED QUESTIONS

Why

must

snowmobile

be registered?

After

alii

have

original

invoice

proof

when

purchased

snowmobile.

A. Your warranty is valid

any authorized dealer

the product. Your regis-

tration is the key element in providing the servicing dealer with the necessary

data to complete warranty claim forms. This information is also used to

notify

owners in the event

asafety recall.

How

do I

know

vehicle

has been registered at

the

factory?

When you

bought

yoursnowmobile the dealer shouldhave completed,

and

forwarded us the manufacturer's copy

the Customer Warranty Registra-

tion. YOUR DEALER SHOULD HA VEGIVEN YOU THE HARD

COpy

OF THE

WARRANTY

REGISTRATION FORM.

Q: I

bought

snowmobile

O'King

County

but

snowmobile

Washington

County.

Can

the

dealer

Washington

County

perform

warranty

work

snowmobile?

Yes,

any

authorizeddealer in North America can perform warranty repairs,

providing the customer warranty registration card is presented.

Where

can I

find

information

the

lubrication

and

maintenance

snow-

mobile?

A. In this Operator Manual

provided

with

the vehicle

the time

first sale.

Will

the

entire

warranty

void

cancelled,

if I do

not

operate

maintain

new

snowmobile

exactly

specified

the

Operator's

Manual?

The warranty

the

new

snowmobile

cannot

"Voided"

or "Cencetted".

However,

aparticular failure is caused by operation or maintenance

other

than is

shown

in the OperatorManual, THATfailure may

not

be coveredunder

warranty. This includes service

work

performed

the customer, especially

the critical adjustments to ignition, timing, carburation

and

oil

injection/or

oil

mixture.

Would

you

give

some

examples

abnormal

use or

strain,

neglect

or abuse?

These terms are general

and

overlap each

other

in areas. Some specific ex-

amples

may

include: running the machine

out

oil, chain failure causedby a

lack

lubrication, operating the machine

with

abroken

damaged

part

which causes

another

part

to fail,

and

so on.

you have any specific questions

on operation or maintenance, please

contact

your dealer

for

advice.

What

costs are my responsibility during the

warranty

period?

The customer's responsibility includes all costs

normalmaintenance ser-

vices, non-warranty repairs, accidents and collision damage, as well as oils,

and spark plugs, and incidental or consequential damages costs as explained

in the warranty.

Q: Are

"Genuine"

Bombardier replacement parts used in

warranty

repairs covered

by warranty?

Yes.

When installed by an authorized dealer, any

"genuine"

Bombardier

part used in warranty repairs assumes the remaining warranty that exists on

the machine.

I sell my snowmobile within the warranty period, will the

new

owner

qualify

for

the balance

the warranty?

Yes,

provided the

unit

has already been registered with the manufacturer.

Note that the change

ownership card in this manual should be completed

and sent to Bombardier Inc.

How

can I receive the best

owner

assistance?

Thesatisfaction

and

goodwill

the owners

Bombardierproducts are

primary concern to your dealer

and

Bombardier Inc. Normal/y, any problems

that arise in connection with the sales transaction or the operation

your

snowmobile will be handled by your Dealers Sales or Service Departments. It

is recognized, however, that despite the best intentions

everyone concern-

ed, misunderstandings will sometimes occur.

you have a problem that has

not

been handled to your satisfaction through normal channels, we suggest

that you discuss your problem with a member

dealership management Fre-

quently, complaints are the result

abreakdown in communications and can

quickly be resolved by a member

the dealership management.

the prob-

lem already has been reviewed with the Sales Manager or Service Manager,

contact the Dealer himself or the General Manager.

LISTING OF AREA DISTRIBUTORS

CANADIAN

DISTRIBUTORS

ALPINE DISTRIBUTORS LIMITED

Kalamalka Lake Road

P.O. Box 159

Vernon, British Columbia, V1T 6M2

(604) 545-1314

British Columbia

BOMBARDIER INC.

EASTERN

CANADA

DISTRIBUTION

DIVISION

Atlantic Branch

P.O. Box 670

Shediac, New Brunswick,

EOA

3GO

(506) 532-4454

Magdalen Island, Nova Scotia,

New

Brunswick, Prince Edward Island

BOMBARDIER INC.

EASTERN

CANADA

DISTRIBUTION

DIVISION

(Quebec Branch)

1350 Nobel Boulevard

Boucherville, Quebec, J4B 1A1

(514) 527-2469 or 655-6121

Province of Quebec

BOMBARDIER INC.

EASTERN

CANADA

DISTRIBUTION

DIVISION

Ontario Branch

230 Bayview Drive

Barrie, Ontario, L4N 4Y8

(705) 728-8600

Province of Ontario

BROOKS EQUIPMENT LIMITED

1616 King Edward Street

P.O. Box 985

Winnipeg, Manitoba, R3C 2V8

(204) 633-7247

Manitoba, Saskatchewan

HUDSON'S BAY CO. LTD.

165 Hymus Blvd

Pointe-Claire. Quebec,

M4W

1A8

(514) 697-8500

North-West Territories, Franklin

District &Keewatin

J.W.

RANDALL

LIMITED

West

Street

P.O.

Box 1050

Corner Brook, Newfoundland, A2H 6G7

(709) 634-3533

Newfoundland, Labrador

TRACT EQUIPMENT

14325, 114th Avenue

Edmonton, Alberta, T5M 2Y8

(403) 452-9910

Alberta, Dist. Mackenzie, Yukon,

N.W.T.

AMERICAN DISTRIBUTORS

BOMBARDIER CORPORATION

4505 West Superior Street

P.O. Box 6106

Duluth, Minnesota 55806

(218) 628-2881

North Dakota, Minnesota, Wisconsin,

Illinois, Missouri, Michigan, Indiana,

Ohio (less eastern half), Tennessee,

Kentucky, West Virginia, Virginia,

Northern Idaho, Northern Wyoming,

Montana, Iowa, Washington.

ELLIOTT &HUTCHINS INC.

East Main Street Road

Malone,

N~w

York 12953

(518) 483-4411

New

York, Massachusetts, Connec-

ticut, Rhode Island, Pennsylvania,

New

Jersey, Maryland, Delaware,

District of Columbia, Eastern half of

Ohio, Maine, New Hampshire, Vermont.

MILLER EQUIPMENT

AND

RECREATIONAL CENTER

1049

Whitney

Road

Anchorage, Alaska

99501

(07)

274-9513

Alaska

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Motonieve de Ski-Doo

Ski-Doo

Ski-Doo FORMULA III 1997 Guía de instalación

Ski-Doo

Ski-Doo NORDIK 50 1988 Manual de usuario

Ski-Doo

Ski-Doo Legend 800 2002 Manual de usuario

Ski-Doo

Ski-Doo 1982 Blizzard 5500 MX Manual de usuario

Ski-Doo

Ski-Doo Grand Touring 700 2000 Guía de instalación

Ski-Doo

Ski-Doo REV GEN4 Manual

Ski-Doo

Ski-Doo REV G4 Trail/Crossover E-TEC Series Manual

Ski-Doo

Ski-Doo ALPINE VALMOMT Manual de usuario

Ski-Doo

Ski-Doo 1997 Tundra II LT 3266 Manual de usuario

Ski-Doo

Ski-Doo EXPEDITION V-1000 Manual de usuario

Ski-Doo

Ski-Doo MX Z X 440 2002 Manual del propietario

Ski-Doo

Ski-Doo MX Z 440 Guía de instalación

Ski-Doo

Ski-Doo Tundra II LT 1998 Guía de instalación

Ski-Doo

Ski-Doo SKANDIC EXPEDITION 600 H.O. SDI 2005 Manual

Ski-Doo

Ski-Doo Tundra R Skandic LT 2003 Manual del propietario

Ski-Doo

Ski-Doo Blizzard 7500 Manual de usuario

Ski-Doo

Ski-Doo MXZ X 600 RS 2021 Manual de usuario

Ski-Doo

Ski-Doo Blizzard 5500 1979 Manual de usuario

Ski-Doo

Ski-Doo Grand Touring 500 1998 Guía de instalación

Ski-Doo

Ski-Doo 1980 citation 3500 Manual de usuario

Ski-Doo

Ski-Doo OLYMPIQUE 300 Manual de usuario

Ski-Doo

Ski-Doo REV Series Manual

Ski-Doo

Ski-Doo 1982 Elite Manual de usuario

Ski-Doo

Ski-Doo 861 002 700 Manual de usuario

Manuales populares de Motonieve de otras marcas

BRP

BRP Ski-Doo MXZ 120 2023 Manual de usuario

Arctic Cat

Arctic Cat ZR 900 Series 2006 Manual de usuario

Arctic Cat

Arctic Cat Wildcat EFI Mountain Cat 1994 Manual de usuario

BOMBARDIER

BOMBARDIER Ski-Doo Alpine 74 1959 Manual de usuario

Arctic Cat

Arctic Cat Cougar Manual de usuario

Yamaha

Yamaha SnoScoot SXR2NJ Manual de usuario

Yamaha

Yamaha VX500XTB Manual de usuario

Yamaha

Yamaha RS VENTURE 2014 Manual de usuario

Polaris

Polaris RMK Shift Manual de usuario

Yamaha

Yamaha VK540EF Manual de usuario

Yamaha

Yamaha VK540EF Manual de usuario

BOMBARDIER

BOMBARDIER ski-doo Nordic 640ER 1974 Manual de usuario

BOMBARDIER

BOMBARDIER ski-doo OLYMPIQUE 300 1974 Manual de usuario

Yamaha

Yamaha SXV4NP Manual de usuario

Ohlins

Ohlins PB 616 Manual de usuario

Polaris

Polaris 600 RUSH 2013 Guía

BOMBARDIER

BOMBARDIER Ski-doo MX ZX 440 Manual

Polaris

Polaris 600 INDY VOYAGEUR Manual de usuario