Ski-Doo 2006 MX Z Manual

Mmo-2006-007 suppl MX Z X.FH8 Tue Jun 21 08:14:45 2005 Page 1

Composite

C M Y CM MY CY CMY K

SAFETY WARNING

Disregarding any of the safety precautions and instructions

contained in this Operator’s Guide,Safety Videocassette or on-

product warnings may result in injury, including the possibility of

death.

This Operator’s Guide and Safety Videocassette should remain

with the unit at time of resale.

In USA, products are distributed by BRP US Inc.

In Canada, products are distributed by Bombardier Recreational Prod-

ucts Inc.

The following are trademarks of Bombardier Recreational Products

Inc. or its subsidiaries.

SKI-DOO ROTAX®‘

REV®MX-Z®

Printed in Canada. (mmo2006-007 DR)

®™ and the BRP logo are trademarks of Bombardier Recreational Products Inc. or its affiliates.

* Trademark of Bombardier Inc. used under license.

Dear 2006 MX Z XTM 440 owner, informations in the 2006 REV®

Series Operator's Guide (P/N 520 000 547) also apply to your MX

Z X 440 except for the following.

__________________________ 1

TABLE OF CONTENTS

VEHICLE INFORMATION

RACING APPLICATION........................................... 4

CONTROLS/INSTRUMENTS/EQUIPMENT .................... 5

1) Brake/Parking Brake PilotLamp (Red)...................... 5

12) Tether Cord Cut-Out System .............................. 6

13) Engine Cut-Out Switch .................................... 6

14) High Beam/Low Beam Switch ............................ 6

18) Fuel Level .................................................. 7

43) Pre-Heat Switch............................................ 8

44) Primer Button .............................................. 8

RECOMMENDED FUEL AND OIL................................ 9

OPERATING INSTRUCTIONS.................................... 13

Engine Starting Procedure..................................... 13

Suspensions Adjustments..................................... 13

SPECIFICATIONS ................................................. 15

MAINTENANCE INFORMATION

ENGINE SYSTEM................................................. 20

Coolant Pump Shaft Oil Reservoir............................. 20

Cooling System ................................................ 20

DRIVE SYSTEM................................................... 21

Brake Fluid Level............................................... 21

Drive Belt Removal/Installation................................ 21

WARRANTY

LIMITED WARRANTY VALIDATION............................. 26

2__________________________

VEHICLE

INFORMATION

__________________________ 3

RACING APPLICATION

For racing application, the main jets have to be replaced according to

thechartfoundonbeltguard.

4__________________________

CONTROLS/INSTRUMENTS/EQUIPMENT

A33A1RC

6 7 9 13

NOTE: See description of numbered items in 2006 REV Series Op-

erator’s Guide (P/N 520 000 547) except for the following.

1) Brake/Parking Brake Pilot Lamp (Red)

This pilot lamp is disabled (does not light up) on the MX Z X 440.

WARNING

Make sure parking brake is fully disengaged before operating

the snowmobile.

When you ride the vehicle, brake that are caused to drag by

a continuous pressure on the lever may cause damage to the

brake system and cause loss of braking capacity and/or fire.

__________________________ 5

12) Tether Cord Cut-Out System

General

The tether cord cut-out system prevents snowmobile to runaway, if

the operator accidently falls off, by shutting off the engine.

WARNING

Always disconnect tether cord when leaving vehicle unattend-

ed and keep in a secured location.

Operation

Attach tether cord to clothing eyelet then snap tether cord cap over

post before starting engine.

To stop engine, completely pull cap from post.

13) Engine Cut-Out Switch

Locatedonrightsideofhandlebarthisswitchisusedtostopthe

engine.

OFF

A33E0HB

OFF

14) High Beam/Low Beam Switch

Allows selection of headlamp high beam or low beam.

6__________________________

mmo2006-007-002_a

1. Low beam

2. High beam

18) Fuel Level

Open fabric door to see the fuel level through the translucent fuel

tank.

A33H1OA 1

1. Fabric door

__________________________ 7

43) Pre-Heat Switch

Racing Application Only

NOTE: This switch is disabled (not operative) on vehicles modified

forwarrantyvalidation. Torunenginewith91octanenumberfuel

(R + M)/2 inside North America (95 RON outside North America),

this switch must be disabled.

A33E0SA

1. Button depressed: Pre-heat timing curve

2. Button released: 108 (R + M)/2+ octane timing curve for North America

version (98 RON + Octane timing curve for outside North America)

After starting the engine, push and hold the pre-heat switch button

in order to pre-heat the tuned pipe. Release pre-heat switch button

once the tuned is pre-heated.

44) Primer Button

Pull and push button. It is not necessary when engine is warm.

To prime, activate button until a pumping resistance is felt. From

this point, pump 2 or 3 times to inject fuel in intake manifold. After

priming, ensure that primer button is pushed back.

NOTE: In very cold temperature, it is recommended to rotate primer

button 3-4 turns prior to pull it. This will eliminate the possibility of

sticking.

8__________________________

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Vehículo todoterreno de Ski-Doo

Ski-Doo

Ski-Doo 2000 ZX series Manual

Ski-Doo

Ski-Doo EVEREST L/C ELECTRO 1981 Manual de usuario

Ski-Doo

Ski-Doo Blizzard 9500 Manual de usuario

Ski-Doo

Ski-Doo RT series Manual

Ski-Doo

Ski-Doo RV 340 Manual de usuario

Ski-Doo

Ski-Doo Mini Z 2000 Guía de instalación

Ski-Doo

Ski-Doo ZX series Manual

Ski-Doo

Ski-Doo MX Z X 600 RS Manual

Ski-Doo

Ski-Doo RF series Manual

Ski-Doo

Ski-Doo Mini Z Manual

Ski-Doo

Ski-Doo 2006 RF series Manual

Ski-Doo

Ski-Doo 2005 ZX series Manual

Ski-Doo

Ski-Doo MX Zx 600 RS Manual

Ski-Doo

Ski-Doo Expedition LE Manual

Ski-Doo

Ski-Doo 2005 SUMMIT HIGHMARK X Guía de instalación

Ski-Doo

Ski-Doo Grand Touring SE 1997 Manual del propietario

Ski-Doo

Ski-Doo Mini Z Manual

Ski-Doo

Ski-Doo REV-XP 2009 Manual

Ski-Doo

Ski-Doo 2005 Rt series Manual

Ski-Doo

Ski-Doo Mini Z Manual

Ski-Doo

Ski-Doo Tundra Skandic Series Manual

Ski-Doo

Ski-Doo Scandic WT 550F Manual

Ski-Doo

Ski-Doo 1980 Everest 500 Manual de usuario

Ski-Doo

Ski-Doo 2006 Mini Z Manual

Manuales populares de Vehículo todoterreno de otras marcas

Polaris

Polaris RANGER XP 1000 EPS 2018 Manual de usuario

Yamaha

Yamaha Tri Moto 125 Manual de usuario

Yamaha

Yamaha YFM350X Warrior Manual de usuario

APRILIA

APRILIA QUASAR 100 Manual de usuario

Polaris

Polaris RZR 900 Manual de usuario

Suzuki

Suzuki LT-A700X Manual de usuario

Suzuki

Suzuki LT-Z400 Manual de usuario

Arctic Cat

Arctic Cat 120 sno pro Manual de usuario

Yamaha

Yamaha RS90PB Manual de usuario

Yamaha

Yamaha FX Nytro FX10X Manual de usuario

Dinli

Dinli DL702 Manual de usuario

Yamaha

Yamaha SXV70ML Manual de usuario

Baja motorsports

Baja motorsports ATV 90 Manual

Polaris

Polaris Sportsman 550 XP EPS Manual de usuario

Arctic Cat

Arctic Cat ALTERRA 450 Manual de usuario

Polaris

Polaris Sportsman 9922233 Manual de usuario

Yamaha

Yamaha YFM45FAT Manual

Polaris

Polaris RZR XP 1000 Manual de usuario