Siemens Stratos Outstation Manual de usuario

667/CI/45025/000

3G OTU

IP ROUTERS INSTALLATION

GUIDE

Jun-19

Issue 4

Contents

IP ROUTERS INSTALLATION GUIDE 3G OTU

667/CI/45025/000 Rev 4 Unrestricted

Contents

Contents 2

List of Figures 3

List of Tables 4

Health and Safety Protection 5

Handling Precautions 6

1. Introduction 7

1.1. Purpose 7

1.2. Document References 7

1.3. Key Terms and Abbreviations 7

2. Routers - General Description 9

2.1. MuLogic RSA ADSL 9

2.2. PROROUTE 3G/4G Router 9

2.3. Connection Types 9

2.3.1. Transparent Connection 9

2.3.2. VPN Connection 10

3. Installation and Configuration Guidance 11

3.1. Installation of the Antenna Cable 11

3.1.1. Installation of Pole Mounted Antenna Kit 13

3.2. Configuration and Installation of the 3G/4G Router 14

3.2.1. RMS over IP Gemini Mk2 14

3.2.2. STRATOS Outstation Connection 14

3.2.3. UTC Connection via 3G/4G router 16

3.3. Installation and Configuration of ADSL Routers 20

4. Maintenance 21

4.1. Modifications 21

4.2. Routine Maintenance Visits 21

4.3. First Line Maintenance 21

4.4. Second Line Maintenance 22

List of Tables

IP ROUTERS INSTALLATION GUIDE 3G OTU

667/CI/45025/000 Rev 4 Unrestricted

List of Figures

Figure 1 : SIM Card Slot 14

Figure 3 : 3G/4G Router Settings (WAN) 15

Figure 4 : 3G/4G Router Settings (ICMP) 15

Figure 5 : IPSec Configuration 16

Figure 6 : Example IPSec Instance 18

Figure 7 : Example IPSec Status 19

List of Tables

IP ROUTERS INSTALLATION GUIDE 3G OTU

667/CI/45025/000 Rev 4 Unrestricted

List of Tables

Table 1 : External Document References 7

Table 2 : Terms and Abbreviations 8

Table 3 : IPSec Settings Table 17

Health and Safety Protection

IP ROUTERS INSTALLATION GUIDE 3G OTU

667/CI/45025/000 Rev 4 Unrestricted

Health and Safety Protection

Safety of Installation and Maintenance Personnel

In the interests of health and safety, when installing, using or servicing this equipment the

following instructions must be noted and adhered to:

(1) Only skilled or instructed personnel, with relevant technical knowledge and experience,

who are also familiar with the safety procedures required when dealing with modern

electrical/electronic equipment, are to be allowed to use and/or work on this equipment.

All work shall be performed in accordance with the local regulations1,2.

(2) Such personnel must take heed of all relevant notes, cautions and warnings in this

Handbook and any other Document or Handbook associated with the equipment includ-

ing, but not restricted to, the following:

i. The equipment must be correctly connected to the specified incoming power supply.

ii. Only trained / competent persons should work on this equipment.

iii. Any power tools must be regularly inspected and tested.

iv. Any personnel working on site must wear the appropriate protective clothing, e.g. re-

flective vests, etc.

Safety of Road Users

It is important that all personnel are aware of the dangers to road users that could arise during

repair and maintenance of traffic control equipment.

Ensure that the junction area is coned and signed as necessary to warn motorists and pedes-

trians of any dangers and to help protect the personnel working on the site.

For UK this refers to Electricity at Work Regulations 1989.

For DE this refers to GV A3, DIN EN 50110-1 (VDE 0105-1) and VDE 0832 and the work-safety leaflet

ASM 0099-01

Handling Precautions

IP ROUTERS INSTALLATION GUIDE 3G OTU

667/CI/45025/000 Rev 4 Unrestricted

Handling Precautions

Safety of Handling

•Take care not to ‘kink’ the cable when installing. The impact may manifest in poor re-

turn loss.

•Due to the cable thickness the RF cable the minimum bend radius of 25cm must be ob-

served

•It is recommended that RF connectors exposed to the environment are protected using

amalgamating Tape, and electrical tape

Introduction

IP ROUTERS INSTALLATION GUIDE 3G OTU

667/CI/45025/000 Rev 4 Unrestricted

1. Introduction

1.1. Purpose

This User Guide gives a general description for the range of IP router used by Siemens ITS.

This document either outlines the general procedures for installation, commissioning and

maintenance or refers to appropriate and applicable documents.

1.2. Document References

External Document References

667/HB/31601/000

UTMC OTU/ MOVA Handbook

667/HB/32600/000

GEMINI² Traffic Outstation Handbook

667/AY/45025/000

3G/4G OTU Communications Site Selection Guide

667/DZ/31601/000

Family Tree

667/CI/32630/000

Gemini MK2 3G/4G Conversion GUIDE

667/CI/52251/000

Stratos Outstation 3G/4G Comms Installation QS Guide

Table 1 : External Document References

1.3. Key Terms and Abbreviations

Key Terms and Abbreviations

PSTN

Public Switching Telephone Network

GSM

Global System for Mobile communication (This Usually Refers to 2nd Generation,

2G Networks)

GPRS

Global Packet Radio Service, Used on, 2G networks as a packet data service.

Second Generation GSM Networks optimised for Voice Communication

Third Generation GSM Network optimised for Data Communications

Fourth Generation GSM Network optimised for Data Communications

EDGE

Enhanced Data rates for GSM Evolution (or EGPRS). Used on 2G networks to

increase the data rates achievable.

PSU

Power Supply Unit

I/O

Inputs / Outputs

Introduction

IP ROUTERS INSTALLATION GUIDE 3G OTU

667/CI/45025/000 Rev 4 Unrestricted

Key Terms and Abbreviations

MOVA

Microprocessor Optimised Vehicle Actuated

UTC

Urban Traffic Control

OTU

Outstation Transmission Unit

SCOOT

Split Cycle Offset Optimisation Technique

IPT

Intelligent Portable Terminal

RAM

Random Access Memory

PROM

Programmable Read Only Memory

CPU

Central Processor Unit

UTMC

OTU

Urban Traffic Management and Control (Outstation Transmission Unit)

UTMC

VMS

Urban Traffic Management and Control (Variable Message Sign)

NAT

Network Address Translation (sometimes referred to as Port Forwarding)

VPN

Virtual Private Network

LAN

Local Area Network

WAN

Wide Area Network

ADSL

Asymmetrical Digital Subscriber Line

SDSL

Symmetrical Digital Subscriber Line

Table 2 : Terms and Abbreviations

Routers - General Description

IP ROUTERS INSTALLATION GUIDE 3G OTU

667/CI/45025/000 Rev 4 Unrestricted

2. Routers - General Description

Siemens ITS (Poole) provide and support three types of routers, namely a 3G/4G Router, xDSL

Route and Instation Router for use in customer networks.

This chapter outlines these devices and provides an overview on their use.

2.1. MuLogic RSA ADSL

This type of router can be used to connect IP based equipment to a customer network using

an ADSL “Broadband“ Connection. The ADSL line will allow a connection to the Public Inter-

net, and the router can provide a IPSEC VPN (Virtual Private Network) tunnel to another Rout-

er to allow the WAN (Wide Area Network) connection back to the customer LAN (Local Area

Network). For details please refer to 667/CI/99107/000.

2.2. PROROUTE 4G Router

The current router is the PROROUTE H685 4G (667/1/99110/000), which can be used to con-

nect IP based equipment to a customer network using a Mobile Phone connection (3G or 4G

GSM). Wireless connections of this type are not normally as reliable as using wired communi-

cations solutions and are not always suitable in some locations or for certain applications. If

in doubt, please contact the Engineering department in Poole for clarification.

The PROROUTE H685 4G (667/1/99110/000) Router also allows IPSEC VPN tunnels to be con-

figured for secure connections across the public Internet, these settings would be provided

by the Customer or Poole Engineering department.

2.3. Connection Types

There are two types of equipment connections used in Siemens ITS. The first is the ‘transpar-

ent’ connection and the second is the ‘VPN’ connection.

2.3.1. Transparent Connection

In this type of connection the STRATOS Outstation, or ST950 controller, will be the VPN cli-

ent. Therefore any communications interface only needs to act as a transparent ‘pipe’ to and

from the STRATOS Outstation/ST950 Controller.

Safety of Licences

The STRATOS Outstation/ST950 Controller needs to be supplied with the appropriate certifi-

cates in order to enable connection through to the STRATOS Instation.

Routers - General Description

IP ROUTERS INSTALLATION GUIDE 3G OTU

667/CI/45025/000 Rev 4 Unrestricted

Safety of Security

Although the 3G/4G router modem does not handle the STRATOS Outstation to Instation secu-

rity explicitly, it is nevertheless incumbent on the installers to secure the router. Having a se-

cure router may discourage accidental or intentional re-configuration that could end up

providing third parties with access to customers’ internet bandwidth.

The process for securing the 3G/4G router is as follows;

1Generate a random password. It is recommended that KeePass (www.keepass.com) is

used for such a purpose.

2Configure the router such that the spare Ethernet port is not active.

3Confirm and configure the modem such that the WiFi device is in-operable.

4Update the modem with the password generated above.

5Export the router configuration

6Store the password for the router along with router configuration in the STRATOS Outsta-

tion site-log or the ST950 Site Log.

7Delete local copies of the configuration and password.

2.3.2. VPN Connection

This type of connection relies on the router to become the VPN client. Product applications

such as RMS over IP (Gemini Mk2), OMU, Saphire JTM will use this methodology.

Safety of Security

It should be noted that this method of connection is not considered as secure as the ‘Transpar-

ent’ connection method.

Otros manuales para Stratos Outstation

Tabla de contenidos

Otros manuales de Controladores de Siemens

Siemens

Siemens OpenAir G B181.1E/KN Series Manual de usuario

Siemens

Siemens SIMATIC S7 Manual de usuario

Siemens

Siemens Desigo RXC32.1 Manual de usuario

Siemens

Siemens SIRIUS 3RW52 Manual de usuario

Siemens

Siemens Simatic S7-300 Instrucciones de montaje

Siemens

Siemens RVA63.242 Manual de usuario

Siemens

Siemens CU240E-2 Manual de usuario

Siemens

Siemens SQM40 Series Manual del propietario

Siemens

Siemens OpenAir GMA 1 Series Manual de usuario

Siemens

Siemens OpenAir GIB132.1P Manual del propietario

Siemens

Siemens SIPART DR22 Manual de usuario

Siemens

Siemens 353 Manual de usuario

Siemens

Siemens Simatic S7 Series Manual de usuario

Siemens

Siemens SSD161S.05DU Manual de usuario

Siemens

Siemens SINUMERIK 828D Turning Guía de inicio rápido

Siemens

Siemens SQL36E50F04 Manual de usuario

Siemens

Siemens ERTEC200 Manual de usuario

Siemens

Siemens SINUMERIK 840D sl Manual de usuario

Siemens

Siemens LMV51 Series Manual del operador

Siemens

Siemens RAJA+ 3TE7111-2SC18-1A Series Instrucciones de funcionamiento

Siemens

Siemens SIMATIC FM 455 C Manual de usuario

Siemens

Siemens Simatic S7-1500 Manual de usuario

Siemens

Siemens SITRANS LUT400 Manual de usuario

Siemens

Siemens SIMATIC S5-90U Guía del usuario

Manuales populares de Controladores de otras marcas

Digiplex

Digiplex DGP-848 Instrucciones de funcionamiento

YASKAWA

YASKAWA SGM series Manual de usuario

Sinope

Sinope Calypso RM3500ZB Manual de usuario

Isimet

Isimet DLA Series Style 2 Manual de instalación

LSIS

LSIS sv-ip5a Manual de usuario

Rockwell Automation

Rockwell Automation 1769-L31 Manual de usuario

Airflow

Airflow Uno hab Manual de usuario

ABB

ABB ACS580-01 drives Manual de usuario

Panasonic

Panasonic GM1 Series Manual de usuario

Emerson

Emerson SW93 Manual de usuario

AutoAqua

AutoAqua Smart ATO micro SATO-120P Manual de usuario

Panasonic

Panasonic FP? Positioning Unit RTEX Manual de usuario

Samson

Samson Type 5824 Manual de servicio

Alpha IP

Alpha IP MIOB 21001 Manual de usuario

Surecom

Surecom SR-629 Manual de usuario

Fishman

Fishman TriplePlay Manual de usuario

Regulus

Regulus SRS1 T Manual de usuario

3M MicroTouch EX113 Manual de usuario