Scotsman KDIL-PN-ID3 Manual de usuario

Kit Number: KDIL-PN-ID3

Kit Purpose: To lower the ice level in an ED300 ice dispenser when a Scotsman

Nugget ice machine is stacked on top of the dispenser.

Kit Contents:

Bin thermostat Baffle/cap tube bracket, grommets & fasteners Wire

KDIL-PN-ID3 11-0353-23 included included

Applications & Other Requirements:

•N0422, N0622, N0922 or N1322 onto ED300. Also requires Cornelius adapter and

agitator kit.

Installation Sequence:

1. Agitators

2. Diverting plates

3. Adapter

4. Ice separator and thermostat bracket

5. Ice machine

6. Thermostat

Instructions

17-3301-01

Installation: Dispenser

1. Disconnect electrical power

from both the ice machine and

the dispenser.

2. Replace agitators.

3. Install adapter onto ED300

per its instructions.

4. Install triangular separator

into adapter per its instructions.

5. Attach thermostat bracket to separator, using

bolts from the Scotsman kit. Bracket mounts

inside of front separator flange, and it angles

back to the dispenser. Be sure grommets are

installed onto bracket's lower holes.

6. Install left and right diverting plates per

supplied instructions.

7. Place nugget ice machine onto adapter.

Position so that the ice chute is over the drop

zone hole in the adapter.

Note: Machine will have to be moved during

installation of the bin thermostat. Do not seal

to adapter until the bin thermostat

installation is complete.

Ice Machine

8. Remove front panel.

9. Push bail clip back and remove chute cover.

10. Remove ice sweep.

11. Lift chute up and out of base.

12. Uncoil the bin thermostat capillary tube.

13. Mount the thermostat the control box support using the pre-punched holes.

Electrical Shock Hazard

Disconnect electrical

power before beginning

Angle Bracket Back To Ice

Mount Bracket Here

14. Open the control box door. Locate the blue wires connected together with an

insulted double male quick connect. Disconnect the blue wires at the quick connect.

15. Route the blue wires thru the snap bushing the bottom of the control box and

connect them to the thermostat.

16. Route bin thermostat capillary tube through the space next to the ice chute.

Thermostat Bracket

17. Route thermostat cap tube thru the hole in the top of the separator and down into

the dispenser. Pull all of it thru. See Figure A on next page.

18. Thread the cap tube thru the holes in the bracket as shown in Figure B on the next

page. A horizontal loop of cap tube will be on the ice side of the bracket.

19. Position the ice machine 14.5" from the right edge of the adapter. This will allow the

ice to fall into the dispenser equally to the left and right.

20. Seal the ice machine to the adapter.

Dispenser:

21. Set the agitation for 2 seconds on, 3 hours off.

Reconnect electrical power.

Return all panels and covers to their normal positions and secure with the original

screws.

14.5 in

Ice Machine

ED300

Adapter

Figure A: Route Cap Tube Thru Hole In Separator

Figure B: Route Cap Tube in Thermostat Bracket

Thermostat

Cap Tube Mounting

Bracket

Tabla de contenidos

Otros manuales de Máquina de hielo de Scotsman

Scotsman

Scotsman CMS1402 Manual de usuario

Scotsman

Scotsman Self Contained Cuber CU1526 Manual de usuario

Scotsman

Scotsman CME506 Manual de usuario

Scotsman

Scotsman ACM 25 Manual de usuario

Scotsman

Scotsman CMS1002W Manual de usuario

Scotsman

Scotsman CSWE1 Manual de usuario

Scotsman

Scotsman ID150 Manual de usuario

Scotsman

Scotsman MF 47 Manual de usuario

Scotsman

Scotsman FME800R Manual de usuario

Scotsman

Scotsman NME1250R Manual de usuario

Scotsman

Scotsman CME256 Manual de usuario

Scotsman

Scotsman EC 106 Manual de usuario

Scotsman

Scotsman MDT5N40A-1J Manual de usuario

Scotsman

Scotsman FM2402RH Manual de usuario

Scotsman

Scotsman HID312 Manual de usuario

Scotsman

Scotsman HID207 Manual de usuario

Scotsman

Scotsman Brilliance SCCG50 Manual de usuario

Scotsman

Scotsman FM1200 Manual de usuario

Scotsman

Scotsman CM3 Manual de usuario

Scotsman

Scotsman Air and Water Cooled C1448 Manual de usuario

Scotsman

Scotsman NDE754 Manual de usuario

Scotsman

Scotsman TDE470 Manual de usuario

Scotsman

Scotsman MDT5N25 Manual de usuario

Scotsman

Scotsman Prodigy ELITE A Series Manual de usuario

Manuales populares de Máquina de hielo de otras marcas

Hoshizaki

Hoshizaki KMD-460MWJ Manual de usuario

Sub-Zero

Sub-Zero 315I Instrucciones de uso

Unold

Unold 48945 Manual de usuario

Kenmore

Kenmore 2217402A Manual de usuario

Cornelius

Cornelius WM600 Instrucciones de funcionamiento

GE XPIO43SCSS Manual de usuario

Hoshizaki

Hoshizaki KMD-901MAH Manual de usuario

Whynter

Whynter FIM-450HA Manual de usuario

U-Line

U-Line UMCR014-SC01A Manual de instalación

Andrew James

Andrew James AJ000522 Manual de usuario

Kärcher

Kärcher IP 120 Manual de usuario

U-Line

U-Line SS1095 Manual de usuario

Maytag

Maytag MIM1554WRS - Ice Maker Manual de usuario

Hoshizaki

Hoshizaki KM-630MAH Manual de usuario

Princess

Princess Yonanas Manual de usuario

Unold

Unold 48946 Manual de usuario

Electrolux

Electrolux E15IM60GP Manual de usuario

Cornelius

Cornelius UC150 ICE ONLY Manual de usuario