Salus SPMV32 Manual de usuario
3 PORT MOTORISED
VALVE (22 mm)
Instruction Manual
Model No SPMV32
Salus SPMV32 (3 port 22mm) Manual.qxd:Layout 1 9/1/11 09:48 Page 1
SPMV32 INSTRUCTION MANUAL2
Salus SPMV32 (3 port 22mm) Manual.qxd:Layout 1 9/1/11 09:48 Page 2
SPMV32 INSTRUCTION MANUAL 3
PRODUCT COMPLIANCE
This product complies with the essential requirements of the following EC Directives:
• Electro-Magnetic Compatibility Directive 2004/108/EC
• Low Voltage Directive 2006/95/EEC
• EC Marking Directive 93/68/EEC
SAFETY INFORMATION
These instructions are applicable to the Salus Controls model stated on the front cover of this manual only,
and must not be used with any other make or model.
These instructions are intended to apply in the United Kingdom only, and should be followed along with any
other statutory obligations.
This accessory must be fitted by a Competent person, and installation must comply with the guidance provided
in the current editions of BS7671 (IEE Wiring Regulations) and Part ‘P’ of the Building Regulations. Failure to
comply with the requirements of these publications could lead to prosecution.
Always isolate the AC Mains supply before removing or refitting the actuator assembly.
Please leave these instructions with the end user where they should be kept in a safe place for future reference.
Salus SPMV32 (3 port 22mm) Manual.qxd:Layout 1 9/1/11 09:48 Page 3
INTRODUCTION
A motorised valve is used to control the flow of water in a central heating system. The motorised valve can be
used for control of both heating and hot water, and it works by controlling the flow of water from the heating
boiler to other parts of the system.
There are two types of motorised valve used in domestic heating systems: two port (also called zone valves),
and three port (also called mid position valves). Salus Controls offers both types of valve in a range of standard
port sizes.
FEATURES
• 2 and 3 port in 32mm
• Removable actuator assembly
• Manual lever and position indicator
• Spring return
• Industry standard wiring
• Plug in cable
• LED indication
SPMV32 INSTRUCTION MANUAL4
Salus SPMV32 (3 port 22mm) Manual.qxd:Layout 1 9/1/11 09:48 Page 4
SPMV32 INSTRUCTION MANUAL 5
INSTALLATION
Please read the important safety information at the start of this manual before you begin to install the device.
Before Installation
This valve must only be installed in compatible systems. Before installing, please check that:
• The system pipework has been flushed out to remove any residue.
• There is enough clearance around the valve to allow removal and refitting of the actuator.
• The valve is not installed with the actuator facing down.
• The supply voltage is the same as the voltage indicated on the actuator cover.
• The mains water pressure and the pressure differentials between valve ports are suitable for this valve
(see Product Specification).
Do not restore the mains supply to the system until all associated items are fully installed.
NOTE: All electrical installation work should be carried out by a suitably qualified Electrician or other competent
person. If you are not sure how to install this motorised valve consult either with a qualified electrician, heating
engineer or your boiler / heating system supplier for advice on how to continue.
NOTE: The SPMV32 has a detachable power lead and LED indicator lights.
Salus SPMV32 (3 port 22mm) Manual.qxd:Layout 1 9/1/11 09:48 Page 5
OPERATION
Three way valves
This type of three way motorised valve has port A normally
closed with no power to the valve. In this state, water can flow
from port AB to port B. When the electrical supply is activated,
the actuator motor overcomes the force of the internal spring
and closes port B.
This allows water to flow from port AB to port A. The valve is
kept in this position until the electrical supply is interrupted.
When the electrical supply is interrupted the internal spring
drives the valve back and closes port A. If power is activated on
both channels, the valve will sit in mid position and allow water
to flow through ports A and B.
Plug in and LED models
The plug in will help to connect and disconnect
the valve electrically in a easy way. (See picture)
The LEDs will show the position of the valve
in each moment.
• When CH is demanded, the CH LED will be ON.
• When HW is demanded, the HW LED will be ON.
• When CH and HW are demanded,
both LED will be on.
• When neither CH nor HW are demanded,
both LED will be OFF.
SPMV32 INSTRUCTION MANUAL6
Include if Programmer
has a heating only
selection
CYLINDER STAT
PROGRAMMER
ROOM STAT
COM
CALL SAT
240V AC 50Hz
supply fuse 1
at 3A
CALL=STAT CALLING
SAT=STAT SATISFIED
COM=COMMON
COM
CALL SAT
Mid-position Valve
Typical circuit showing Programmer.
Room ‘Stat and Cylinder’ Stat
as control elements.
L N ON OFF ON OFF
H.WATERHEATING
Yellow
Earth
Blue
Neutral
White
CH call
ORANGE
HW Call
GREY
HW Sat
Salus SPMV32 (3 port 22mm) Manual.qxd:Layout 1 9/1/11 09:48 Page 6
SPMV32 INSTRUCTION MANUAL 7
MANUAL LEVER
There is a lever on the side of the actuator cover: this lever allows manual
operation of the valve, e.g. for refilling and draining of the system or if the
actuator fails. For two way valves, the lever allows the valve to be kept open;
with three way valves the lever allows both ports A and B to be open at the
same time.
To manually operate the valve, gently push the lever forward and latch it in
the MAN position. The valve will automatically return to AUTO when the actuator is powered up again.
NOTE: Push the manual lever slowly to prevent damage to the actuator motor and gear system.
The valve should be in manual position to be fitted.
ACTUATOR REMOVAL
AND REFITTING
The valve actuator can be removed or refitted without
having to disturb the valve installation. The actuator is
designed to clip onto the valve body, making removal and
refitting very easy.
Note: Do not attempt to dismantle the actuator
assembly as it contains no user serviceable parts –
dismantling or tampering with the actuator assembly
will invalidate the product warranty.
Salus SPMV32 (3 port 22mm) Manual.qxd:Layout 1 9/1/11 09:48 Page 7
MAINTENANCE
The Motorised Valve requires no special maintenance. Periodically, the outer casing can be wiped clean using
a dry cloth (please DO NOT use solvents, polishes, detergents or abrasive cleaners, as these can damage the
thermostat).
There are no user serviceable parts within the unit; any servicing or repairs should only be carried out by Salus
Controls or their appointed agents.
Should the Motorised Valve fail to function correctly, check:
• The heating system is switched on.
• The lever is not latched in the MANUAL position.
WARRANTY
Salus Controls warrants that this product will be free from any defect in materials or workmanship, and shall
perform in accordance with its specification, for a period of two years from the date of purchase. Salus Controls
sole liability for breach of this warranty will be (at its option) to repair or replace the defective product.
SPMV32 INSTRUCTION MANUAL8
Salus SPMV32 (3 port 22mm) Manual.qxd:Layout 1 9/1/11 09:48 Page 8
SPMV32 INSTRUCTION MANUAL 9
PRODUCT SPECIFICATION
Model: SPMV32
Type: Motorised valve designed for domestic heating applications.
Electrical
Switching Voltage: 230V AC / 50Hz
Power Consumption: 6W
Response
Opening: 12 seconds
Closing: 5 seconds
Differential Pressure
Pipe size 3 Way
22mm 0.7 bar
28mm 0.6 bar
Max Static Pressure: 15 bar
Salus SPMV32 (3 port 22mm) Manual.qxd:Layout 1 9/1/11 09:48 Page 9
Operating Temperatures
Min Fluid Temperature: 5 ºC
Max Fluid Temperature: 88 ºC
Environment
Operating Temperature: 0 ºC to + 50 ºC
Storage Temperature: - 20 ºC to + 60 ºC
SPMV32 INSTRUCTION MANUAL10
Salus SPMV32 (3 port 22mm) Manual.qxd:Layout 1 9/1/11 09:48 Page 10
Otros manuales para SPMV32
1
Tabla de contenidos
Otros manuales de Unidad de control de Salus
Salus
Salus TC100 Manual de usuario
Salus
Salus KL04NSB 24V Manual de usuario
Salus
Salus SPMV22 Manual de usuario
Salus
Salus LG+5V Manual de usuario
Salus
Salus RXVBC605 Manual de usuario
Salus
Salus ARV10RFM-3 Manual de usuario
Salus
Salus PL06 Manual de usuario
Salus
Salus RXBC5V Manual de usuario
Salus
Salus SPMV22 Manual de usuario
Salus
Salus KL04RF Manual de usuario
Manuales populares de Unidad de control de otras marcas
Festo
Festo Compact Performance CP-FB6-E Manual de lista de piezas
Elo TouchSystems
Elo TouchSystems DMS-SA19P-EXTME Manual de usuario
JS Automation
JS Automation MPC3034A Manual de usuario
JAUDT
JAUDT SW GII 6406 Series Guía rápida
Spektrum
Spektrum Air Module System Manual de usuario
BOC Edwards
BOC Edwards Q Series Manual de usuario
