Rola 59505 Manual de usuario
Product Code:
Product Name:
59505
Roof Top Carrier Extension
WARNING: The Maximum basket content weight capacity is 130 pounds (60 Kg).
DO NOT EXCEED the lowest of vehicle manufacturer’s cross bar rating or basket content weight limit
of 130 pounds (60 Kg).
WARNING: Not for transport of people, animals, or flammable liquids.
WARNING: Distribute your load evenly inside the basket.
WARNING: Securely fasten load to cargo basket. Make sure all bolts, screws, straps and plastic knobs are firmly
attached before every trip and check regularly during the trip.
WARNING: Check security of all cargo basket attachments and load at fuel and rest stops.
WARNING: Check for clearance between sunroof and cargo basket before operating sunroof. (if equipped)
WARNING: Do not carry any loads wider than your vehicle.
WARNING: Do not drill or weld to this product.
TOOLS REQUIRED:
Phillips Screwdriver
Tape Measure
LOAD RATING LIMITS:
-
Basket Weight with Extension (50 Lbs.)
=Basket
Weight Limit
(A)
PARTS LIST:
Vehicle Manufacturer’s cross bar rating
PART DESCRIPTION QTY.
A Basket Extension 1
B Screw, #10-32 (Self Tapping) 8
Please read all instructions carefully before assembly, installation and/or use of this product.
1ASSEMBLE CARGO BASKET
EXTENSION
NOTE: FOR COMPLETE ASSEMBLY
AND INSTALLATION STEPS,
REFER TO 59504 INSTRUCTIONS.
IF YOU ALREADY HAVE THE 59504
BASKET CARRIER INSTALLED:
• Remove basket from your vehicle.
• Separate the two halves of basket
by removing the four screws at the
joints.
• Insert the basket extension.
• Install the eight (8) self-tapping
screws into the existing holes, four
(4) per side as shown.
SHOWN ASSEMBLED
(B)
Product Code:
Product Name:
2POSITION CROSS BARS
• Re-adjust cross bars to a wider setting if
necessary.
• 26-1/4” center to center – Minimum
•NOTE: It is recommended to use the
widest setting for optimum load
distribution. Refer to 59504
instructions for more information.
cross bar
Please read all instructions carefully before assembly, installation and/or use of this product.
26-1/4”
MIN.
3INSERT SPACER BLOCKS
• Reinstall the spacer blocks into cargo basket. NOTE: Locate the spacer blocks in the widest position
possible. (The location of spacer blocks will depend on cross bar setting)
Attach mounting brackets to main basket sections only.
The spacer blocks
snap onto bars.
Tip: Use tape to hold
in place temporarily.
Do NOT attach mounting brackets in shaded area
25” MIN.
4LOAD BASKET ONTO VEHICLE CROSS BARS
• Center basket over vehicle’s cross bars.
•Check and adjust cross bars so they are
centered on spacer blocks.
• Center spacer blocks 25” apart (min.) in cargo
basket (see diagram).
• DO NOT locate spacer blocks on top of cross
bar brackets (if applicable).
• Check clearance for vehicle’s hatch.
½”
Do not locate spacer
blocks on top of
cross bar brackets.
cross bar centered
MAIN BASKET SECTION
CAUTION: Hatch interference may be
unavoidable on some vehicles.
59505
Roof Top Carrier Extension
SPACER BLOCKS – 4 PLACES
48-3/4” REF.
Product Code:
Product Name:
5ATTACH MOUNTING CLAMPS
• Place mounting brackets on top of each
spacer block. The square holes in
brackets must engage the squares on
spacer blocks.
• Install u-bolts around cross bars and into
slots in mounting brackets.
• Install plastic knobs onto u-bolts.
• Tighten all plastic knobs firmly and evenly.
• Tighten vehicle’s cross bars.
• Make sure installation is secure by pulling
side-to-side and fore and aft on basket.
NOTE: The cargo carrier should not move
on cross bars when plastic knobs are
tightened properly.
WARNING: There must be a minimum of ½”
of threads engaged on u-bolt on all plastic
knobs.
CAUTION:
• As with any metal equipment it is recommended that you keep the product clean and remove road salt and debris.
• Do not allow harsh chemicals, road salt, or mud to accumulate on the product for an extended period of time.
• Wash the product with mild soap and water only and a non-abrasive cloth.
Plastic Knob
Mounting
Bracket
Spacer Block
cross bar
U-Bolt
Basket
INCORRECT CORRECT 3-1/4” Max.
1-1/4” Max. ½” Min.
cross bar
•Longer loads, such as canoes or kayaks,
MUST be tied down to the front and rear of
vehicle.
Please read all instructions carefully before assembly, installation and/or use of this product.
59505
Roof Top Carrier Extension
Otros manuales de Accesorios para automóviles de Rola
Rola
Rola PMX208 Manual de usuario
Rola
Rola PMX023 Manual de usuario
Rola
Rola Roof Rack Box 59768 Manual de usuario
Rola
Rola 58966 Manual de usuario
Rola
Rola 59871 Manual de usuario
Rola
Rola PMX022 Manual de usuario
Rola
Rola RailExtended RE43 Manual
Rola
Rola PMX169 Manual de usuario
Rola
Rola J-Rac 59912 Manual de usuario
Rola
Rola Pick-Up-Rack Manual de usuario
Rola
Rola DAEWOO PMX Series Manual de usuario
Rola
Rola 59742 Manual de usuario
Rola
Rola 59400 Manual de usuario
Rola
Rola RMX430 Manual de usuario
Rola
Rola VORTEX 59502 Manual
Rola
Rola PMX143 Manual de usuario
Rola
Rola 59684 Manual de usuario
Rola
Rola PMX107 Manual de usuario
Rola
Rola PMX188 Manual de usuario
Rola
Rola TMX Series Manual de usuario
